2004 Mitsubishi Montero Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Mitsubishi Montero, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes480.0%
- Steering120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
2004 Mitsubishi Montero Limited: Hydraulic Brake Booster is malfunctioning, making a ("gobble-gobble", squirrel-like chirping sound) almost every time the brake pedal is pressed. Hwy driving, without the use of brakes, the frequent "chirping" sounds still occur. Under medium to heavy braking, the vehicle shudders and shakes. This specific sound is made in all gear selections and even when the car's battery is on/engine off. Upon inspection of the hydraulic brake booster under the hood, the unit shakes when the chirp sound is made. Duration of the sound lasts around one second and it happens frequently (5-10 times per minute).
TL* THE CONTACT OWNS A 2004 MITSUBISHI MONTERO. WHILE DRIVING APPROXIMATELY 60 MPH AND ATTEMPTING TO ENGAGE THE BRAKES, THE BRAKE PEDAL WAS HARD TO DEPRESS. THE EMERGENCY BRAKE HAD TO BE ACTIVATED IN ORDER TO STOP THE VEHICLE. ALSO, THE CONTACT HEARD AN ABNORMAL NOISE FROM THE DRIVER SIDE OF THE INSTRUMENT PANEL WHEN THE BRAKES WERE APPLIED. THE DEALER STATED THAT THE HYDRAULIC BOOSTER SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS PREVIOUSLY REMEDIED ACCORDING TO NHTSA CAMPAIGN NUMBER: 01V254001 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 189,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
2004 Mitsubishi Montero Limited: Hydraulic Brake Booster is malfunctioning, making a ("gobble-gobble", squirrel-like chirping sound) almost every time the brake pedal is pressed. Hwy driving, without the use of brakes, the frequent "chirping" sounds still occur. Under medium to heavy braking, the vehicle shudders and shakes. This specific sound is made in all gear selections and even when the car's battery is on/engine off. Upon inspection of the hydraulic brake booster under the hood, the unit shakes when the chirp sound is made. Duration of the sound lasts around one second and it happens frequently (5-10 times per minute).
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .