2018 Mitsubishi Outlander Airbags Problems

The contact owns a 2018 Mitsubishi Outlander. The contact stated that while driving approximately 35 MPH over a pothole, the driver's side and passenger side curtain airbags erroneously deployed. The contact stated that no collision had occurred prior to the air bags deployment. The manufacturer and local dealer were not yet notified of the failures. The vehicle was not yet diagnosed or repaired. The failure mileage was 215,000.

NHTSA ID

11705401

Incident

Oct 5, 2025

Mileage

215,000 mi

SRS-Air Bag codes B1476, B1558, B1631 repeated triggering since 2020. History: - 9/30/20 - Dealer read code B1631 (DR Knee ABG Squib Short) & U0154 (OCM CAN Timeout), did not diagnose cause, erased codes - 4/12/21 ~0920 - check airbag light illuminated - 7/30/21 ~0800 & ~0920 - check airbag light illuminated -- called dealer; was informed since light extinguished I would be liable for diagnostic cost if not covered under warranty - 9/30/21 ~0700 twice - check airbag light illuminated - 11/16/21 ~0720 - check airbag light illuminated - 1/5/22 ~0630 - check airbag light illuminated - 1/14/22 ~1319 twice - check airbag light illuminated - 1/18/22 ~1550 & ~1700 - check airbag light illuminated - 1/19/22 ~1052 & ~1059 - check airbag light illuminated - 1/20/22 ~1304 - check airbag light illuminated - 1/25/22 ~1534 - check airbag light illuminated - 2/11/22 ~1000 - check airbag light illuminated - 3/19/22 ~1800 x 2, ~2245 - check airbag light illuminated - 5/16/23 ~1600 - check airbag light illuminated - 6/18/23 ~1426 - check airbag light illuminated - 6/22/23 ~0928 & ~0955 - check airbag light illuminated - 10/22/23 ~1040 - check airbag light illuminated - 6/16/24 - used personal car scan tool and found B1476 (IG1[A] voltage extraordinary low), B1558 (OCSS control unit), B1631 (DR knee ABG squib short) faults *** Original action by dealer in 2020 to simply delete latched codes did not remedy airbag problem...safety complaints at NHTSA indicate airbag failure during collision...this appears to be a serious public safety problem. ***

NHTSA ID

11594633

Incident

Jun 16, 2024

The contact owns a 2018 Mitsubishi Outlander. The contact stated while driving approximately 35 MPH, the air bag warning light began to flash off and on. The failure was a constant failure. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 98,330.

NHTSA ID

11566461

Incident

Jan 5, 2024

Mileage

98,330 mi

Air bag light comes on when drivers seat put back. When seat moved forward air bag light goes off. When air bag light is on system will not work, not safe to drive. Dealership on first repair did wire repair. They claimed when seat was put back it stretched harness turning on air bag light. Did repair under warranty. Second time they replaced harness due to same problem per Service Advisor. Second repair was not warranty due to being over on mileage. Vehicle is a 2018 with 31754 miles.

NHTSA ID

11562074

Incident

Dec 13, 2023

I was in a head on collision on 12/13/2022, and the air bag failed to deploy. The failure of the air bag deployment cause my chest to slam into the steering wheel along with my knees on the steering column. I went to the hospital for observation and any unknown injuries. My chest hurts and knees along with consistent visions of my life flashing in my mind due to the trauma of this incident. The police, nurses, family, and friends said that I’m lucky to not have serious injuries from the failure of the air bag deployment. I have pictures, police report, and other supporting documents. My 2018 Outlander air bag deployment failure is a serious issue, and it needs to be looked into due to safety, lives, and failure from the air bag. Police report number is on drivers involved. All other vehicles involved air bags deployed, but my Outlander’s air bag failed to deploy. Dangerous to myself or other air bag failures. The manufacturer of the vehicle need’s notified with a full investigation into this matter.

NHTSA ID

11497480

Incident

Dec 13, 2022

I was driving when a woman pulled out In front of me. I was going 49 mph and have the EDR report to prove so. (I was wearing my seatbelt). The front of my car smashed into the rear end of her car and I smashed the right side of my head into the steering wheel. I’ve sustained a traumatic brain injury, long term post concussion syndrome along with a page long list of injuries that I’m still dealing with. It’s been a little over a year and my injuries are just getting worse. Mitsubishi sent a guy out to read my Event Data Recorder with promises of giving me a copy of the report. After 6-7 months of them refusing me the report and telling me the air bags should not have went off i hires a lawyer to subpoena a copy of the report. It says the safety features failed. But here I am left with a car that’s totaled and injuries I will never recover from. I also did research and found out that my car was made in the same plant on the same line as the other 68,000 recalled 2018 outlanders. I can’t understand why mine wasn’t part of the recall?!?! It was made in between the dates as the other 68,000 that was recalled.

NHTSA ID

11437886

Incident

Jun 27, 2020

TL* THE CONTACT OWNS A 2018 MITSUBISHI OUTLANDER. THE CONTACT CALLED ON BEHALF OF THE DRIVER HIS DAUGHTER. THE CONTACT STATED THAT WHILE HIS DAUGHTER WAS AT A COMPLETE STOP, A VEHICLE DRIVING AT 50 MPH FAILED TO STOP AND CRASHED INTO THE CONTACT REAR REMOVING THE VEHICLE REAR BUMPER, AND TAIL LIGHTS, THE DRIVER PROCEEDED TO SPIN THE CONTACT VEHICLE IN A CIRCLE, AND PUSHED THE CONTACT VEHICLE INTO THE VEHICLE IN FRONT. THE DRIVER AIR BAG, PASSENGER FRONT AIR BAG, THE STEERING AIR BAG, THE SIDE AIR BAGS FAILED TO DEPLOY. THE DRIVER HEAD HIT THE STEERING WHEEL, DRIVER SUSTAINED DISK, INJURY, HEAD TRAUMA, CONCUSSION, EARS RINGING, MEMORY LOST, NECK, BACK INJURY, CAN NOT LOOK INTO BRIGHT LIGHT. THE PASSENGER SUSTAINED HEAD TRAUMA, NECK, BACK, KNEES INJURIES. THE READ OAK POLICE DEPARTMENT WAS PRESENT, THE VEHICLE WAS TOWED TO A COLLISION SHOP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. *LN*DT*JB CONSUMER STATED THERE WAS NO DEPLOYMENT OF THE AIRBAGS.*JB

NHTSA ID

11327258

Incident

May 6, 2020

Mileage

53,000 mi

ON MARCH 11 TH, MY OUTLANDER WAS UNABLE TO STOP AND HAD MINIMAL TRACTION IN ABOUT A QUARTER OF AN INCH OF SNOW CAUSING MY VEHICLE TO HIT A TREE HEAD ON. I WAS DRIVING UNDER 30 MILES AN HOUR WHEN THE ACCIDENT OCCURRED. AFTER HITTING THE TREE, THE STEERING WHEEL BEGAN TO SMOKE. I WAS ABLE TO EXIT THE VEHICLE AND TURNED AROUND TO SEE THE AIRBAG ONLY PARTIALLY DEPLOYED. FROM THERE, MY VEHICLE WAS DECLARED A TOTAL LOSS. NOW, AFTER REQUESTING MY INSURANCE COMPANY TO DEMAND A SAFETY INSPECTION FROM THE MITSUBISHI DEALERSHIP TO NO AVAIL, I'VE CONTACTED MITSUBISHI CORPORATE AND GAVE THEM MY ACCIDENT REPORT WITH HIGH CONCERN IN REGARDS TO THE RECALL #18V621. I HAVE OFFERED TO TOW MY OUTLANDER TO THE DEALERSHIP AND THEY HAVE RESPONDED TO MY CONCERN BY REFUSING TO EVALUATE AND INSPECT THIS VEHICLE. WHEN I LAST SPOKE TO MY CASE MANAGER AT MITSUBISHI CORPORATE, SHE LET ME KNOW THERE IS NOTHING THEY WILL DO. I HAVE CALLED THE NASHUA NH DEALERSHIP TO MAKE AN APPOINTMENT FOR SAFETY INSPECTION OF THIS RECALL AND THEY HAVE REFUSED TO HAVE THE SERVICE DEPARTMENT INVESTIGATE. TODAY, I HAVE BEEN TOLD UPON TOWING MY VEHICLE THERE THAT THEY REFUSED DELIVERY OF THE OUTLANDER. I HAVE NOT AGREED TO THE SETTLEMENT OFFERED BY MY INSURANCE AND CONTINUE TO SEEK MEANS OF HAVING THIS VEHICLE INSPECTED FOR THE RECALL WHICH I'M CERTAIN CAUSED MY ACCIDENT. CORPORATE DID STATE THAT IF I SUBROGATE THAN THEY MAY BE ABLE TO DIAGNOSE MY DEFECTIVE VEHICLE. AS OF TODAY, I'M IN THE PROCESS OF GATHERING DOCUMENTS.

NHTSA ID

11202533

Incident

Mar 11, 2019

Mileage

14,000 mi

CITY STREET DRIVING AND A NOTIFICATION OF AIRBAG SYSTEM SERVICE REQUIRED APPEARED ON THE SCREEN.

NHTSA ID

11163712

Incident

Dec 15, 2018

Mileage

20,085 mi

TAKATA RECALL.. I WAS INVOLVED IN A FRONT END COLLISION AND THE AIR BAGS DID NOT DEPLOY. *TR

NHTSA ID

11113921

Incident

May 21, 2018

Mileage

2,700 mi