2008 Mitsubishi Raider

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

WHEN I GET THE TRUCK WE HAD A DEALER IN LITTLE ROCK AR. THEY CLOSED ABOUT 3 YEARS AGO. I CAN NOT UNDERSTAND WHY THEY CAN NOT MAKE ARMAMENTS TO FIX THE AIR BAG IN LITTLE ROCK AR AND NOT HAVE TO DRIVE TO A DIFFERENT STATE.

NHTSA ID

10991619

Incident

May 25, 2017

TL* THE CONTACT OWNS A 2008 MITSUBISHI RAIDER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V352000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER COULD NOT CONFIRM WHEN THE PARTS WOULD BE AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10990623

Incident

Jul 18, 2016

TAKATA RECALL: RECEIVED SAFETY RECALL NOTICE DATED JULY 2016 RE: FRONT PASSENGER AIR BAG INFLATOR, AND, AS INSTRUCTED, CONTACTED MITSUBISHI CUSTOMER RELATIONS DEPT. TO CONFIRM MY CONTACT INFORMATION AND TO FIND OUT WHEN REPLACEMENT PART WOULD BE AVAILABLE. IN SEPTEMBER, CALLED AGAIN AND MMNA HAD NO PROJECTION AS TO TIME FRAME FOR PARTS AVAILABILITY. SINCE I AM THE PRIMARY DRIVER, AND RARELY HAVE PASSENGERS, THE DELAYS WERE TOLERABLE. BUT SINCE MY WIFE AND I ARE PLANNING AN APPROX.,1,500 MILE TRIP TO FLORIDA THANKSGIVING WEEK, 11/19 TO 11/26, I ASKED IF THE AIR BAG IN QUESTION COULD BE DISABLED UNTIL PARTS ARE AVAILABLE, SO THAT, IF WE ENCOUNTERED AN ACCIDENT, THE FRONT PASSENGER WOULD NOT BE INJURED. AFTER THE CUSTOMER RELATIONS REPRESENTATIVE PUT ME ON AN ALMOST INTERMINABLE HOLD, THE REP. SAID NO AND SUGGESTED THAT I TALK TO A LOCAL MITSUBISHI DEALER'S SERVICE DEPARTMENT, WHO SAID THAT, BY NHTSA RULES, IT COULD NOT BE DISCONNECTED. TODAY, 11/10, I AGAIN SPOKE TO MMNA, AND, AGAIN, NO IDEA OF PARTS AVAILABILITY. AS I RELATED MY PREVIOUS CONVERSATIONS, THE REP SAID THAT THE RECALL NOTICE SAID THAT NO ONE SHOULD SIT IN THE FRONT PASSENGER SEAT UNTIL THE INFLATOR WAS REPLACED, I REPLIED THAT NO SUCH WARNING WAS INCLUDED IN THE RECALL NOTICE, AND, AFTER A LONG HOLD, HE CONFIRMED THAT IT WAS NOT INCLUDED. I ASKED FOR A WRITTEN CONFIRMATION, TO WHICH HE REFUSED.

NHTSA ID

10925454

Incident

Nov 10, 2016

Mileage

82,000 mi

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 MITSUBISHI RAIDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V313000 (AIR BAGS) AND 16V352000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 12/23/16*LJ UPDATED 01/04/17.*JB

NHTSA ID

10920467

Incident

Mar 25, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 MITSUBISHI RAIDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V313000 AND 16V352000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ID

10917521

Incident

Oct 20, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 MITSUBISHI RAIDER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V352000 (AIR BAGS); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10907271

Incident

Jul 11, 2016

I WAS DRIVING DOWN THE ROAD WHEN ALL OF A SUDDEN I HAD NO CONTROL OF MY STEERING. I STOPPED AND CHECKED THE RESERVOIR AND NOTICE NO FLUID. I WAS ABLE TO MAKE IT ANOTHER BLOCK AND PUT MORE FLUID IN THE STEERING PUMP. I MADE IT HOME BY ADDING MORE FLUID. I LOOKED UNDER THE VEHICLE AND NOTICE A STEAL LINE WAS LEAKING THE FLUID. I TOOK THE LINE OFF AND NOTICE THAT THEY HAD INSTALLED IT AT A VERY BAD LOCATION WHICH HAD CAUSE THE LEAK THE LINE HAD RUBBED AGAINST ANOTHER LINE AND HAD A HOLE IN IT. IT APPEARS IT HAD BEEN IMPROPERLY PLACED ON THE VEHICLE., THE LINE CANNOT BE PURCHASE REPLACED THIS MODEL WAS DISCONTINUED IN 2009. THEIR ARE NO PARTS FOR THIS THE MODEL VEHICLE. I TALKED TO DEALER AND HE SAID THEY WILL HAFT TO REPLACED IT WITH A NEW DODGE STEERING UNIT. THIS WILL COST AND THOUSANDS OF DOLLARS. THIS IS A FAULTY PRODUCT AND THE DEALER SHOULD REPLACE THIS BECAUSE OF THE SAFETY ISSUED AND FAULTY PRODUCT.

NHTSA ID

10747203

Incident

Aug 6, 2015

Mileage

119,760 mi

TL* THE CONTACT OWNS A 2008 MITSUBISHI RAIDER. THE CONTACT STATED THAT WHEN HE SIGNALED LEFT, THE RIGHT TURN SIGNAL ERRONEOUSLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE MULTI-FUNCTION SWITCH FAILED. THE MULTI-FUNCTION SWITCH WAS REPLACED BUT THE FAILURE RECURRED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 48,566.

NHTSA ID

10584016

Incident

Oct 17, 2012

Mileage

38,000 mi

This Technical Information Notice informs dealers that with permission from the Puerto Rico Traffic Safety Commission, notification letters are being sent to vehicle owners with Puerto Rico addresses to inform them of open Takata recalls.

This Technical Information Notice informs dealers that with permission from the Texas Department of Motor Vehicles (DMV), notification letters are being sent to vehicle owners with Texas addresses to inform them of open Takata recalls.

This Technical Information Notice informs dealers that with permission from the Ohio Bureau of Motor Vehicle, notification letters are being sent to vehicle owners with Ohio addresses to inform them of open Takata recalls.

This Technical Information Notice informs dealers that with permission from the Louisiana Motor Vehicle Division, notification letters are being sent to vehicle owners with Louisiana addresses to inform them of open Takata recalls.

This is a Technical Information Notice informing dealers that MMNA is launching a social media campaign targeting vehicle owners with open Takata recalls.

This Technical Information Notice informs dealers that with permission from the Arizona Motor Vehicle Division, notification letters are being sent to vehicle owners with Arizona addresses to inform them of open Takata recalls.