RoadVitals

1997 Navistar 9100

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Nov 9, 1998
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 1997 Navistar 9100. 2 safety recalls have been issued covering this model year; and 1 manufacturer communication is on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
98V290000

POWER TRAIN:DRIVELINE

Nov 9, 1998
5,487 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH SPICER SPL170 55MM CENTER BERING PACKAGE. THE END YOKE RETAINING NUT CAN LOOSEN.
The risk: IF THIS CONDITION OCCURS, THE DRIVE LINE CAN VIBRATE AND SEPARATE FROM THE VEHICLE, CAUSING VEHICULAR DAMAGE, OR PERSONAL INJURY, OR BOTH.
The remedy: DEALERS WILL REMOVE THE 55MM CENTER BEARING PACKAGE AND COUPLER SHAFT, AND REPLACE IT WITH A NEW COUPLER SHAFT AND A 60MM CENTER BEARING PACKAGE. AN INTERIM REMEDY CAN BE IMPLEMENTED BY PLACING A SPOT WELD ON THE COUPLING SHAFT THREADS UNTIL PARTS ARE AVAILABLE.
INTERNATIONAL TRUCK AND ENGINEView on NHTSA.gov
98V068000

ENGINE AND ENGINE COOLING:ENGINE

Mar 25, 1998
1,190 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR C-10 OR C-12 ENGINES. A BRACKET OR P-CLAMP AT THE REAR OF THE ENGINE THAT SUPPORTS THE COMPRESSOR DISCHARGE LINE WAS OMITTED.
The risk: IF THE COMPRESSOR DISCHARGE LINE FAILS, THE AIR SYSTEM COULD BE DEPLETED AND CAUSE THE PARKING BRAKES TO APPLY. THIS CONDITION CAN CAUSE THE VEHICLE TO SLOW DOWN OR STOP UNEXPECTEDLY, CAUSING A VEHICLE CRASH WHICH COULD RESULT IN PROPERTY DAMAGE AND/OR PERSONAL INJURY.
The remedy: DEALERS WILL INSTALL P-CLAMPS AND A BRACKET AT THE REAR OF THE ENGINE.
INTERNATIONAL TRUCK AND ENGINEView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

IK-0500038

STEERING

NAVISTAR: STEERING GOES INTO A SHIMMY AFTER HITTING A BUMP. *RM UPDATED 3/20/12. *PE

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Navistar 9100 by model year
YearComplaintsRecallsInvestigationsIssue Index
1999040—
1998021—
1997Viewing020—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.