RoadVitals

1995 Navistar School Bus Chassis Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 16, 2004
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1995 Navistar School Bus Chassis, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Interior & seats150.0%
  • Exterior lighting150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

VEHICULAR FIRE IN A 1995 THOMAS/NAVISTAR VISTA SCHOOL BUS. ELECTRICAL FIRE OCCURRED IN THE DORAN MFG. EXTERIOR LIGHT MONITOR PANEL ON A SPECIAL NEEDS SCHOOL BUS. FIRE WAS LIMITED TO THE PANEL ITSELF, NO WIRING WAS DIRECTLY INVOLVED. DRIVER WAS OPERATING LIGHTS AS PART OF PRE-TRIP INSPECTION PRECEDING FIRE. FIRE INVOLVED OPEN FLAME IN DORAN ELECTRICAL PANEL, NO INJURIES, NO CHILDREN ON BUS AT THE TIME. THE PANEL WAS REPLACED AS WAS AN IN-LINE FUSE HOLDER CARRYING POWER TO THE PANEL. THE FUSE HOLDER WAS NOT DAMAGED, BUT TEMPERATURE OF THE WIRING APPEARED TO BE ELEVATED. PARTS WHICH WERE REPLACED WERE RETAINED.*AK

NHTSA ID 10078325 · filed Jun 16, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Exterior lighting

Reports naming headlights, tail lights, turn signals and other exterior lighting.

1
report

From owner reports, verbatim

NAVISTAR FBC 1980-1989 S-SERIES, 1990-1996 NO-3800 SCHOOL BUSES. FIFTY NAVISTAR SCHOOLS BUSES, EXPERIENCED MECHANICAL PROBLEMS IN THE TURN SIGNAL SWITCH. THE TURN SIGNAL WILL NOT SELF CANCEL, OR WILL NOT HOLD THE SIGNAL. *AK

NHTSA ID 805031 · filed Nov 14, 1996

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .