Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 2 NHTSA owner-reported complaints for the 2008 Newmar Grand Star Ca. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–2 of 2
INNER FENDER WALLS ON THE NEWMAR 2008 GRANDSTAR 3750 ARE TOO CLOSE TO THE REAR INSIDE DUAL TIRE, CAUSING BOLT RUBBING ON SIDEWALL OF THE TIRE, CAUSING THE BOLT TO WEAR INTO TIRE SIDEWALL SHEARING OFF THE RUBBER, COMPROMISING THE TIRE. *TR
DURING A SERVICE AT A FREIGHTLINER CHASSIS CENTER, THEIR SAFETY INSPECTION REVEALED BOTH INNER TIRES ON THE REAR DUALS ARE COMING IN CONTACT WITH THE COACH FRAME. AT 5K MILES, ONE TIRE NEAR FAILURE, THE OTHER LESS SO. VISUAL INSPECTION SHOWS A TOO CLOSE GAP BETWEEN THE TIRE TREAD AND COACH BODY WHEN VEHICLE IS UNLOADED. APPROXIMATE 1/4" GAP ON LEFT, 1/2" ON RIGHT AT THE TREAD. AS THE SUSPENSION COMPRESSES OR THE VEHICLE IS LOADED, THE SIDEWALL , AS IT WIDENS TOWARDS THE WHEEL, IS IN CONSTANT, INCREASING CONTACT WITH A PIECE OF ANGLE IRON THAT IS BOLTED TO THE COACH FRAME ON BOTH SIDES. THE TIRE SIDEWALL IS THEN SLOWLY SHAVED OFF AND FRICTION CAUSES SIGNIFICANT HEAT INCREASES. DEFECT IS SO OBVIOUS IT IS DIFFICULT TO COMPREHEND IT PASSING SAFETY AND QUALITY CONTROL, AND ALLOWED TO LEAVE THE FACTORY. NEWMAR SAYS THE FIX IS TO RE-WORK THE COACH BODY TO ACCOMMODATE ROOM FOR THE TIRES. MAY INVOLVE REPLACEMENT OF A HOLDING TANK, CUTTING OF THE FLOOR, ECT. VEHICLE AT THIS TIME COULD NOT PASS A MN DOT INSPECTION. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .