2004 Newmar Kountry Star Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Newmar Kountry Star, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Steering330.0%
- Suspension330.0%
- Other / unspecified220.0%
- Engine110.0%
- Interior & seats110.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
BALL JOINTS ON THE SPARTAN CHASSIS SUPPLIED BY TUTHILL ARE DEFECTIVE. THESE COMPANIES ARE AWARE OF THIS. I HAVE APPROXIMATELY 30K MILES ON MY 2004 KOUNTRY STAR DIESEL MOTOR HOME AND ALL UPPER AND LOWER BALL JOINTS(RUBBER CUPS) ARE DEFECTIVE AND SPLITTING. I CONTACTED BOTH SPARTAN AND TUTHILL AND WAS TOLD, THERE ARE ONLY A "HAND" FULL OF COMPLAINTS ABOUT THIS ISSUE AND THAT I AM NO LONGER UNDER WARRANTY. DEFECTIVE BALL JOINTS ARE SAFETY ISSUE THAT THESE COMPANIES ARE FULLY AWARE OF THIS ISSUE AND HAVE ELECTED TO DISREGARD IT. THE DEFECTS ARE NOT NOTICED UNTIL THE WARRANTIES ARE NO LONGER IN EFFECT. MANY RV OWNERS DON'T KNOW OF THIS PROBLEM. *TR
2004 NEWMAR KOUNTRY STAR IS NOT LISTED UNDER THE NHSTA RECALL #03V-488. I HAVE TRIED TO OBTAIN THE RECALL RECORDS FROM NEWMAR, AND THE DEALER SINCE THE MH WAS ALREADY AT A DEALERSHIP WHEN NOTIFICATION WERE SUPPOSED TO BE SENT OUT. BUT I AM GETTING CONFLICTING INFO CONCERNING THE RECALL RECORDS, SINCE THERE IS NO RECORD THAT THE NOTICES WERE SENT OUT. FINALLY AN INDEPENDENT MECHANIC CORRECTED THE RECALL AT NO COST TO ME ON 02/06. BUT I AM HAVING ADDITONAL PROBLEMS WHICH I BELIEVE IS A DIRECT RESULT OF THE RECALL AND THEREFORE MY MH REMAINS IN THE SAME UNSAFE CONDITION AS WHEN THE RECALL WAS MADE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
BALL JOINTS ON THE SPARTAN CHASSIS SUPPLIED BY TUTHILL ARE DEFECTIVE. THESE COMPANIES ARE AWARE OF THIS. I HAVE APPROXIMATELY 30K MILES ON MY 2004 KOUNTRY STAR DIESEL MOTOR HOME AND ALL UPPER AND LOWER BALL JOINTS(RUBBER CUPS) ARE DEFECTIVE AND SPLITTING. I CONTACTED BOTH SPARTAN AND TUTHILL AND WAS TOLD, THERE ARE ONLY A "HAND" FULL OF COMPLAINTS ABOUT THIS ISSUE AND THAT I AM NO LONGER UNDER WARRANTY. DEFECTIVE BALL JOINTS ARE SAFETY ISSUE THAT THESE COMPANIES ARE FULLY AWARE OF THIS ISSUE AND HAVE ELECTED TO DISREGARD IT. THE DEFECTS ARE NOT NOTICED UNTIL THE WARRANTIES ARE NO LONGER IN EFFECT. MANY RV OWNERS DON'T KNOW OF THIS PROBLEM. *TR
2004 NEWMAR KOUNTRY STAR IS NOT LISTED UNDER THE NHSTA RECALL #03V-488. I HAVE TRIED TO OBTAIN THE RECALL RECORDS FROM NEWMAR, AND THE DEALER SINCE THE MH WAS ALREADY AT A DEALERSHIP WHEN NOTIFICATION WERE SUPPOSED TO BE SENT OUT. BUT I AM GETTING CONFLICTING INFO CONCERNING THE RECALL RECORDS, SINCE THERE IS NO RECORD THAT THE NOTICES WERE SENT OUT. FINALLY AN INDEPENDENT MECHANIC CORRECTED THE RECALL AT NO COST TO ME ON 02/06. BUT I AM HAVING ADDITONAL PROBLEMS WHICH I BELIEVE IS A DIRECT RESULT OF THE RECALL AND THEREFORE MY MH REMAINS IN THE SAME UNSAFE CONDITION AS WHEN THE RECALL WAS MADE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
MY 2004 KOUNTRY STAR HAS A DOMETIC REF RECALL ACCORDING TO MODEL AND SERIAL #. NEWMAR SAID MY 04 WAS NOT AFFECTED. THE NEWMAR RECALL NHSTA ID 07V075000 IS ONLY FOR 1997-2003. I HAVE NOT RECEIVED A RECALL NOTICE BECAUSE MY MODEL IS A 2004.
RECREATIONAL VEHICLE'S REAR SEATS ARE NOT PROPERLY ATTACHED TO THE CHASSIS. CONSUMER IS CONCERNED THAT IN AN EVENT OF A COLLISION OR ROLL OVER THE SEATS WOULD NOT STAY IN POSITION. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2004 NEWMAR KOUNTRY STAR RV. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, SMOKE APPEARED FROM THE REAR OF THE VEHICLE. THE CONTACT PULLED OVER TO INSPECT THE VEHICLE AND NOTICED SMOKE AND FLAMES IN THE ENGINE COMPARTMENT. THE FIRE ENGULFED THE ENTIRE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS COMPLETELY DESTROYED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE INSURANCE COMPANY'S STORAGE FACILITY. THE CAUSE OF THE FAILURE HAS NOT BEEN DETERMINED. THE FAILURE AND CURRENT MILEAGES WERE 38,000. UPDATED 12/02/08. *LJ UPDATED 12/03/08. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
RECREATIONAL VEHICLE'S REAR SEATS ARE NOT PROPERLY ATTACHED TO THE CHASSIS. CONSUMER IS CONCERNED THAT IN AN EVENT OF A COLLISION OR ROLL OVER THE SEATS WOULD NOT STAY IN POSITION. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .