RoadVitals

2006 Newmar Kountry Star Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Oct 25, 2020
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Newmar Kountry Star, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Steering1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

AFTER FEELING AND LEAVING FLYJ THE STEERING LOCKED UP IN A SLIGHT TURN. AFTER SOME EFFORT I MANAGED TO UNLOCK AND MAINTAIN DIRECTION. I EXPERIENCED THE SAME THING A FEW MORE TIMES AS I WAS ONLY 10 MIN FROM HOME. AFTER I INVESTIGATED AND FOUND THE UPPER TAPERED BEARING IN THE 90DEGREE GEAR BOX HAD FAILED DUE TO LACK OF LUBRICATIN. UPON DISASSEMBLE I FOUND THERE HAD BEEN MOISTURE IN THE UPPER BEARING RACE CAUSING THE ROLLERS TO FAIL A SUSUQUENTLY THE CAGE CAUSING THE LOCKUP. I FOUND THE GEARBOX WAS FULL OF FLUID TO THE UPPER FILLER PLUG. HOWEVER THE DESIGN IS SUCH THAT THE FLUID WILL NEVER REACH THE UPPER BEARING TO LUBRICANT IT. THERE WAS NO EXTERNAL LEAKAGE EVIDENT AND I CHECK THE FLUID LEVEL ANNUALLY. I CALLED THE MANUFACTURER WITH NO RESULTS I CALLED NEWMAR WITH NO HELP FROM THEM. I REBUILT THE BOX AND INSTALLED A GREASE FITTING AND PURGED IT WITH GREASE. I AM CONCERNED THAT THIS MAY HAPPEN TO SOMEONE ELSE.

NHTSA ID 11366338 · filed Oct 25, 2020

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .