2020 Newmar Kountry Star Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Newmar Kountry Star, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Electrical150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
5 windows were replaced under the Lippert 21E-047 recall. The replacement windows were no better than the original recalled windows. One of the new replacement windows suddenly fell off the vehicle in traffic after only 4 months. The glue bond holding the window to the hinge failed. I sent pictures to Lippert showing the failed joint. Lippert refuses to have the defective replacement window repaired and shows no interest in evaluating the quality of the other replacement windows. This is a very dangerous situation as another one of the replacement windows could fall off and hit another vehicle causing severe damage and injury.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The cable supplying 12V power to the RV generator (the house generator in the front of the coach) shorted out while driving causing failure of 12V chassis control systems and accessories including: Transmission control (i.e. could not shift gears) Instrument panel Turn signals Horn Rear view camera Engine brake control. The vehicle air brakes were operating and I was able to pull over to a safe location. While the vehicle engine could be restarted, none of the 12V accessories at the drivers station were functional particularly the gear shift control, rendering the vehicle inoperable. The Freightliner repair facility found the shorted cable inside the generator enclosure. Their opinion was that the cable was too long, so that when it moved due to vehicle motion (potholes) it rubbed against a stud used to hold insulation in place. The shorted cable in turn caused the failure of the Freightliner "PDMs" creating the numerous failed systems.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .