1990 Nissan 240SX Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1990 Nissan 240SX, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system2144.7%
- Seat belts510.6%
- Interior & seats48.5%
- Engine48.5%
- Brakes36.4%
- Body & structure24.3%
- Driver assistance24.3%
- Steering24.3%
- Transmission12.1%
- Suspension12.1%
- Tires & wheels12.1%
- Electrical12.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
I HAVE PURCHASED THIS AUTO APRIL 20, 2005. I DROVE IT FOR APPROXIMATELY TWO WEEKS. THEN AN OVERPOWERING ODOR OF GASOLINE EMITTED IN THE PASSENGER COMPARTMENT. UPON INSPECTION OF THE ENGINE COMPARTMENT, THERE WAS GASOLINE LEAKING FROM THE FUEL RAIL. I HAVE HAD THE O-RINGS AND INSULATORS REPLACED ON ALL FOUR FUEL INJECTORS AND THE LEAK IS STILL PRESENT. IT SEEMS THAT I MUST NOW REPLACE THE INJECTORS. IN CHECKING FOR POSSIBLE RECALLS, I HAVE NOTICED THERE WERE SEVERAL OTHER COMPLAINTS MADE REFERRING TO THE FUEL SYSTEM ON THESE MODELS, AND THAT NISSAN WOULD NOT RECALL THE 240 SX EVEN THOUGH THE EXACT SAME DESIGN IS USED IN THE FOUR CYLINDER ENGINE AS THE SIX CYLINDER MODELS THAT THEY DID RECALL. !!! WHY NOT THE 240 SX, NISSAN????? I INTEND TO KEEP ALL OLD PARTS THAT ARE REPLACED.
SMELLED BAD GAS ODOR. TOOK TO REPAIR SHOP AND SAID 3 OUT OF 4 INJECTORS WERE LEAKING, VERY DANGEROUS. REPLACED IMMEDIATELY. NOW I AM READING ABOUT RECALL # 95I006000--NEVER NOTIFIED. WILL NISSAN REFUND OR CREDIT ME FOR COST SINCE THIS WAS IMMEDIATE DANGER PROBLEM. WILL PROVIDE PROOF OF SERVICE AND COST.*AK
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1990 NISSAN 240SX. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 95V103002 (SEAT BELTS). THE CONTACT WAS EXPERIENCING A FAILURE; HOWEVER, THE DEALER WOULD NOT HONOR THE RECALL AND WANTED TO CHARGE THE CONTACT FOR THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
WHEN GETTING INTO THE VEHICLE AND TRYING TO USE THE AUTOMATIC SEAT BELT, THE SEAT BELT WILL KEEP GETTING JAMMED AND THE CONSUMER IS UNABLE TO USE THE SEAT BELT. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE METAL BACKING IN THE DRIVERS SEAT IS STARTING TO PROTRUDE THROUGH THE SEAT MATERIAL AND INTO THE DRIVERS BACK.
BOLT HOLDING SEATBACK TO SEAT BOTTOM BROKE LOOSE, CAUSING SEATBACK TO RECLINE IN AN UNSAFE POSITION. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE DRIVING AND WITHOUT WARNING THERE IS A NOISE COMING FROM ENGINE. TIMING CHAIN HAS MALFUNCTIONED AND NEEDED TO BE REPLACED.
WAS COMING TO A LIGHT, TOOK FOOT OFF GAS, AND RPMS DROPPED TO 1800. WHEN TAKEN VEHICLE OUT OF GEAR, RPMS WOULD JUMP UP OVER 1800 & THEN SLOWLY DECREASE. TOOK TO DEALERSHIP 5 OR 6 TIMES FOR PROBLEM. MECHANIC NOT ABLE TO RESOLVE PROBLEM. FRONT TIRES WOULD HAVE NO GRIP. CAR WOULD KEEP ROLLING DUE TO BACK WHEEL PUSHING. *AK *ML
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
MASTER CYLINDER LEAKING. *ET
BRAKE FLUID CAUSED THE SEALS TO FAIL, RESULTING IN LOSS OF BRAKE POWER. THE DEALER HAS BEEN NOTIFIED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE FACTORY BREAK BOOSTERS ON NISSAN 240SX MODEL YEARS 1989-1998 LEAK AND DRIP BREAK FLUID ONTO THE FRAME RAIL, EATING AWAY THE RUST PREVENTIVE COATING. THIS ALLOWS THE ELEMENTS TO CONTACT BARE METAL, OXIDIZING IT AND BOTH WEAKENING THE STRUCTURE OF THE VEHICLE AND POTENTIALLY CAUSING THE BREAKS TO FAIL.
DESIGN OF REAR SPOILER CAUSES WATER TO STAY UNDERNEATH, CAUSING BOLTS TO RUST/BREAK. *DH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
THE ENGINE IDLE CONTROL FAILS WHILE ON THE ROAD, NOT ABLE TO DETERMINE CAUSE OF IDLE PROBLEMS. YH
ENGINE HIGH IDLE, APPROXIMATELY4000 RPMS. BOTH INCIDENTS OCCURRED DURING INCLEMENT WEATHER, DIAGNOSTIC SCREENING DIDNT IDENTIFY PROBLEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
POWER STEERING SYSTEM FAILED.
STRUCK ON PASSENGER SIDE; VEHICLE SLIDES SIDEWAYS STRIKING TREE, FLIPPED OVER ON DRIVER SIDE, DRIVER THROWN HALF WAY OUT OF WINDOW; VEHICLE CRUSHED DRIVER
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
POWER STEERING SYSTEM FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
LEFT FRONT SHOCK TOWER FAILED. *DH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
WAS COMING TO A LIGHT, TOOK FOOT OFF GAS, AND RPMS DROPPED TO 1800. WHEN TAKEN VEHICLE OUT OF GEAR, RPMS WOULD JUMP UP OVER 1800 & THEN SLOWLY DECREASE. TOOK TO DEALERSHIP 5 OR 6 TIMES FOR PROBLEM. MECHANIC NOT ABLE TO RESOLVE PROBLEM. FRONT TIRES WOULD HAVE NO GRIP. CAR WOULD KEEP ROLLING DUE TO BACK WHEEL PUSHING. *AK *ML
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE SAFTEY BUTTON ON THE IGNITION THAT YOU USUALLY HAS TO BE PUSHED IN TO GET THE KEY OUT KEEPS GETTING STUCK. THEREFORE I'M NOT ABLE TO GET MY KEY OUT. THE PROBLEM HAS HAPPENED ABOUT 5 OR 6 TIMES ALREADY AND TO RESOLVE IT, I HAVE TO REMOVE THE PLATE THAT COVERS THE IGNITION AND BUTTON AND PRESS IT A CERTAIN WAY. I HAVE BEEN STUCK AT VARIOUS LOCATIONS, NOT BEING ABLE TO LEAVE MY CAR, DUE TO THE FACT THAT I CAN'T GET MY KEY OUT. I BELIEVE THIS SHOULD FALL UNDER THE MANUFACTURERS RESPONSIBILITY AND NOT THE CUSTOMERS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .