2003 Nissan Xterra Engine Problems

Fuel pump power steering abs O2 sensors yes it's available for inspection upon requests car shut off while driving at 70 miles an hour on a highway due to fuel pump because my VIN number is not with all the other 2003 Nissan xterra's that have recalls on all of the same problems I have just for some reason my car has zero recalls which is ridiculous and not believable so yes my life was put at risk I took it to an independent service my mechanic because I can't take it to a dealer because all the parts that are broken and that need replacement that have been recalled on every other 2003 does not apply to my VIN so I've had to pay for labor and parts and the headache that I could have had this all replaced and fixed due to the recall and I would have taken it to the dealership immediately after purchasing the car in 2019 and since the previous owner didn't have any recalls why would he bother either I will not pass inspection if they do not fix this evap O2 sensor and now my fuel pump I would like to be reimbursed on that was purchased through Nissan dealership the gauge is no longer working just put in brand new part so I would like someone from the dealerships take a look at my car and replace everything that's wrong with it with every other 2003 Nissan Xterra regardless of my VIN number and I have check engine light on forever for evac leak replace catalytic converters exhaust system O2 sensors power steering fuel pump ABS sensors I would just like to take the best care of this vehicle that I can and that would be done through the dealership replacing all of the recalled parts on this make model of the Xterra 2003 3.3 l V6 non supercharged. The vehicle stalled while driving due to the fuel pump check engine light's been on for EVAP code for the fuel tank cap gas cap small leak and O2 sensors which I've been replaced but codes are still there no code has popped up pertaining to fuel pump car died at 70 miles an hour on a Thruway at midnight not fun.7Codes remaining

NHTSA ID

11428152

Incident

Jun 15, 2021

ENGINE OVERHEATING ALL COOLING PARTS HAVE BEEN REPLACED STILL OVERHEATING WITH NO KNOWN ISSUE FOUND VERY COMMON IN THE 2000 TO 2004 MODELS AND YET NO RECALLS TO FIX THE ISSUE AND KEEPS BLOWING RADIATOR HOSES

NHTSA ID

11363744

Incident

Jul 24, 2019

Mileage

200,000 mi

TL* THE CONTACT OWNS A 2003 NISSAN XTERRA. THE CONTACT STATED THAT THERE WAS A PREMATURE FAILURE OF COOLANT LEAKING INTO THE RADIATOR, WHICH IMPACTED THE TRANSMISSION. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE INDEPENDENT MECHANIC REPLACED THE RADIATOR AND FLUSHED THE TRANSMISSION. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL CAMPAIGN AND PROVIDED NO SOLUTION. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11066135

Incident

Oct 1, 2017

JUNE 12 2016 AT THE TRI-PAR IN SLINGER, WI I WAS FILLING UP THE GAS TANK, WHEN GAS BEGAN SPILLING OUT OF THE VEHICLE'S WHEEL WELL. I IMMEDIATELY STOPPED IT AFTER I NOTICED IT. THE STATION ALONG WITH THE SLINGER FIRE DEPARTMENT ESTIMATED A GALLON WAS SPILT. IT APPEARS THE VEHICLE'S GAS TANK NECK HAS RUSTED OUT. THEY DEEMED THE VEHICLE NOT SAFE TO DRIVE AND RECOMMEND WE HAVE IT TOWED HOME, WHICH WE DID.

NHTSA ID

10873775

Incident

Jun 12, 2016

Mileage

131,000 mi

NISSAN XTERRA FRAME RUSTED BEYOND ANY SAFETY JUSTIFICATION. OIL LEAKS FROM ENGINE UP TWO 2 QUART A DAY LEAD TO ENGINE SEIZED UP WITHOUT WARNING.

NHTSA ID

10820189

Incident

Jan 8, 2016

Mileage

98,000 mi

TL* THE CONTACT OWNS A 2003 NISSAN XTERRA. THE CONTACT STATED THAT THE REAR DRIVER AND PASSENGER SIDE CATALYTIC CONVERTERS FAILED. THE CONTACT ALSO MENTIONED THE EGR SYSTEM FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

NHTSA ID

10631151

Incident

Mar 4, 2013

Mileage

120,000 mi

WE WERE DRIVING ON VACATION AND THE CAR STOPPED. IT STARTED BACK UP AND THEN AFTER A COUPLE OF MILES STOPPED AGAIN. WE WERE STRANDED AND DIDN'T GET HOME FOR THREE DAYS.I HAVE TAKE CODES OFF THE ENGINE AND IT SHOWED A 0462 CODE. WENT BACK TO GET XTERRA WITH A CAR DOLLY AND DOLLY BROKE AND CAR CAME UNDONE. THIS UNFORTUNATE INCIDENT WAS A DIRECT RESULT OF A BAD SENDING UNIT. *TR

NHTSA ID

10608227

Incident

Jun 28, 2014

Mileage

108,000 mi

RADIATOR IS FALLING OUT OF TRUCK ,DUE TO SERIOUS RUST ON FRAMING, HOOD LATCH IS STARTING TO BREAK FREE HOOD COULD FLY UP ONTO WINDSHIELD . *TR

NHTSA ID

10606088

Incident

Jun 11, 2012

DURING A DRIVE HOME FROM A WEEKEND IN THE COUNTRY, MY XTERRA BEGAN TO OVERHEAT. A FAINT POP, LIKE A BACKFIRE, HAPPENED. AFTER I HEARD THE NOISE, A CONSISTENT TICKING OR PINGING SOUND STARTED COMING FROM THE RIGHT FRONT SIDE OF MY XTERRA. THE SOUND IS CONSISTENT WITH THE ACCELERATION. ONCE I GOT HOME, I STARTED TO RESEARCH THE ISSUE ONLINE. FOUND THAT 2000-2004 XTERRAS HAVE A VERY COMMON PROBLEM WITH THE EXHAUST MANIFOLD CRACKING DUE TO WEAK MATERIAL. I AM AN ACTIVE MEMBER ON WWW.CLUBXTERRA.ORG AND MANY OTHER MEMBERS REPORT THE SAME ISSUE. THIS IS QUITE A SET BACK FOR MOST PEOPLE AND CAN CAUSE SERIOUS DAMAGE TO THE ENGINE IF IT IS NOT TAKEN CARE OF IN A TIMELY MANNER. NISSAN SHOULD RECOGNIZE THAT THIS IS A MANUFACTURING FAULT AND ISSUE A RECALL. EVERYONE I KNOW THAT OWNS AN XTERRA HAS OR HAD THIS ISSUE. *TR

NHTSA ID

10584612

Incident

Apr 20, 2014

Mileage

118,000 mi

ENGINE LIGHT CAME ON IN 09. VEHICLE FAILED EMISSIONS DUE TO PROBLEM WITH EVAC SYSTEM. GASKET AT FUEL TANK WAS REPLACED. WITHIN A YEAR, ENGINE LIGHT CAME BACK ON. THERE WAS ANOTHER PROBLEM WITH THE EVAC SYSTEM. AFTER $ 862.00 DOLLARS THAT WERE SPENT ON VEHICLE FOR O RING AND GASKET REPAIRS, VEHICLE PASSED EMISSIONS. WITHIN 8 MONTHS, ENGINE LIGHT WAS BACK ON DUE TO EVAC SYSTEM. MECHANIC STATES THAT THERE IS MAJOR CORROSION OF THE FUEL TANK AND THAT HE HAS SEEN THE SAME THING ON MANY NISSAN VEHICLES OF THIS AGE DUE TO THE MATERIAL USED TO CONSTRUCT THE FUEL TANK AND BELIEVES THAT IT IS A WIDESPREAD PROBLEM THAT SHOULD HAVE BEEN RECALLED AND THAT NISSAN STARTED USING A DIFFERENT MATERIAL ONCE THE PROBLEM WAS KNOWN. THE ENTIRE INTERIOR OF THE VEHICLE SMELLS OF GASOLINE AND MECHANIC STATES THAT ANYONE IN CLOSE PROXIMITY OF VEHICLE COULD CAUSE AN EXPLOSION IF A SPARK WAS CREATED. *TR

NHTSA ID

10490307

Incident

Aug 26, 2009

Mileage

78,000 mi

I OWN A 2003 NISSAN XTERRA 4WD. IT HAS 55,000 MILES AND ONLY BEEN SERVICED AT NISSAN DEALERSHIP. I NOTICED A SWEET SMELL COMING FROM THE ENGINE WHEN THE CAR WAS WARM SO WHEN I TOOK IN FOR OIL CHANGE ASKED THEM TO CHECK IT OUT. TOLD ME THE HEADS WERE WARPED AND NEEDED TO BE GROUND DOWN, NEW GASKET, BELTS AND SPARKPLUGS D/T THE HEAD LEAKING. THIS IS THE SECOND HEAD GASKET PROBLEM I'VE HAD WITH A NISSAN I'VE OWNED. THE OTHER ONE WAS UNDER WARRANTY AND WAS TOLD IT WAS A FREAK THING. I BELIEVED THEM, AND HAD NO PROBLEM BUYING ANOTHER NISSAN. NOW SAME PROBLEM AND I HAVE TO PAY $2,250.00 FOR REPLACEMENT. NO ONE CAN TELL ME WHY. I CONTACTED NISSAN CORP FOR REIMBURSEMENT ON THIS. IM STILL WAITING FOR A REPLY, BUT AFTER SEARCHING THE NET I SEE THAT THIS IS A FAMILIAR PROBLEM WITH NISSAN. I WILL NOT BE BUYING ANOTHER NISSAN PRODUCT. *TR

NHTSA ID

10266229

Incident

Apr 8, 2009

Mileage

55,000 mi

SINCE 2006, SENSOR LIGHT WAS COMING ON AND OFF. IN 2008 FAILED EMISSION INSPECTION DUE TO SENSOR LIGHT. HAD REPAIRED BY A STATE CERTIFIED REPAIR FACILITY, AS REQUIRED BY STATE OF MASS, FOR SENSOR AND CAT CONVERTER IN MAY 2008. IN AUG 2008 SENSOR LIGHT CAME BACK ON. HAD RESET - WAS SAME ISSUE THAT WAS REPAIRED IN MAY 2008. *TR

NHTSA ID

10239739

Incident

May 23, 2008

Mileage

10,800 mi

FUEL INJECTION SYSTEM WAS REPLACED FOUR TIMES. AFTER THE LAST REPAIR, WHILE DRIVING THE VEHICLE, IT CAUGHT ON FIRE IN THE ENGINE. *AK

NHTSA ID

10101778

Incident

Oct 31, 2004

Mileage

24,000 mi