RoadVitals

2005 Nova Bus Nova Lfs Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Dec 18, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09V485000

INTERIOR LIGHTING

Dec 18, 2009
8 units potentially affected
The defect: NOVA BUS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 LFS TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
The risk: A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.
The remedy: NOVA BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON FEBRUARY 26, 2010. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR NOVA BUS AT 1-450-472-6410.
NOVA BUS INCORPORATEDView on NHTSA.gov
08V150000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Apr 1, 2008
19 units potentially affected
The defect: NOVA BUS IS RECALLING 19 MY 2003-2006 LFS TRANSIT BUSES BUILT WITH CUMMINS ISL ENGINES WHICH WERE EQUIPPED WITH CM850 FUEL SYSTEMS. THE ENGINE HIGH PRESSURE FUEL LINES FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL ARE PRONE TO FAILURE. FAILURE TYPICALLY OCCURS AT OR UNDER THE FUEL LINE FITTING ATTACHMENTS.
The risk: THE INTRODUCTION OF HIGH PRESSURE ATOMIZED FUEL INTO THE ENGINE COMPARTMENT CREATES A RISK OF FIRE DUE TO POSSIBLE IGNITION WHEN THE FUEL VAPOR COMES IN CONTACT WITH HOT SURFACES.
The remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY FUEL LINE FITTINGS AND BRACKETS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2008. OWNERS MAY CONTACT NOVA BUS AT 1-450-472-6410.
NOVA BUS INCORPORATEDManufacturer number CR1219AView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources