RoadVitals

2002 Orion Vi Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Jan 21, 2010
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

10V015000

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

Jan 21, 2010
426 units potentially affected
The defect: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.
The risk: THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.
The remedy: DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
DAIMLER BUSES NORTH AMERICA, INC.View on NHTSA.gov
06V211000

ENGINE AND ENGINE COOLING:ENGINE

Jun 14, 2006
405 units potentially affected
The defect: ON CERTAIN BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50G ENGINES, HIGHER THAN EXPECTED TEMPERATURES WILL ALLOW THE LOW PRESSURE NATURAL GAS REGULATOR GASKET TO LEAK COOLANT AND DRIP ONTO THE TERMINALS OF THE BATTERY CHARGING ALTERNATOR.
The risk: THIS CAN RESULT IN A SHORT IN THE ELECTRICAL CIRCUIT AND THE POTENTIAL FOR AN ENGINE COMPARTMENT FIRE.
The remedy: DETROIT DIESEL IS CONDUCTING THE RECALL (PLEASE SEE 06E028000) AND WILL REPAIR THE ENGINES BY REPLACING THE LOW PRESSURE REGULATOR GASKET FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 1-313-592-3708 OR ORION BUS AT 905-403-7832.
ORION BUS INDUSTRIES LTD.Manufacturer number DDC#06C03View on NHTSA.gov
03V063000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

Feb 24, 2003
416 units potentially affected
The defect: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINE CONFIGURATIONS, A HYDRAULIC MOTOR USED TO DRIVE THE ENGINE COOLING FAN MOTOR HAS TWO HOSES CONNECTED TO IT, INCLUDING A HIGH PRESSURE INPUT HOSE. THE HIGH PRESSURE HOSE IS CONSTRUCTED WITH REUSABLE OR CRIMP ENDS. THE HYDRAULIC MOTOR IS LOCATED AT THE REAR OF THE BUS, INSIDE THE ENGINE COMPARTMENT. THE END OF THE HOSE THAT IS CONNECTED TO THE FAN MOTOR HAS DISCONNECTED FROM THE HOSE CONNECTOR.
The remedy: DEALERS WILL REPLACE THE HYDRAULIC HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN APRIL 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-905-403-1111.
ORION BUS INDUSTRIES, INC.Manufacturer number ORB-03-01View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources