RoadVitals

2005 Pierce Quantum Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Jan 2, 2019
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

19V022000

ELECTRICAL SYSTEM:SOFTWARE

Jan 2, 2019
994 units potentially affected
The defect: Pierce Manufacturing (Pierce) is recalling certain 2004-2018 Arrow XT, Dash, Enforcer, Impel, Quantum and Velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.
The risk: If the aerial device moves in an unexpected direction, the ladder may contact an object, such as a building or an electrical wire, increasing the risk of injury.
The remedy: Pierce will notify owners, and dealers will reprogram the aerial control module, free of charge. The recall began February 28, 2019. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B295.
Pierce ManufacturingManufacturer number 74B295View on NHTSA.gov
17V348000

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

May 30, 2017
225 units potentially affected
The defect: Pierce Manufacturing (Pierce) is recalling certain 1999-2013 Arrow XT, Dash, Enforcer, Quantum and Velocity fire trucks equipped with the electric All-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.
The risk: Axle shafts that are not properly heat treated may break and potentially disable the vehicle, increasing the risk of a crash.
The remedy: Pierce will notify owners, and dealers will replace the rear steer axle shafts, free of charge. An interim notice was mailed on July 24, 2017. The recall began June 3, 2020. Owners may contact Pierce customer service at 1-888-974-3723.
Pierce ManufacturingManufacturer number 74B283View on NHTSA.gov
11V551000

STRUCTURE:BODY:DOOR

Nov 10, 2011
59 units potentially affected
The defect: PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2005, 2008-2011 ARROW XT, CUSTOM CONTENDER, DASH, ENFORCER, IMPEL, QUANTUM, SABER, AND VELOCITY 75 FOOT HAL (HEAVY ALUMINUM LADDER) FIRE APPARATUS BODIES VEHICLES MANUFACTURED FROM MAY 17,2005, THROUGH OCTOBER 13, 2011, THAT MAY BE EQUIPPED WITH DUAL SCBA CYLINDER STORAGE COMPARTMENTS. THESE COMPARTMENTS EXTEND INBOARD HORIZONTALLY FROM THE SIDE OF THE REAR BODY. THE SCBA COMPARTMENT DOOR LATCH ORIENTATION MAY HAVE BEEN MANUFACTURED INCORRECTLY, ALLOWING THE DOOR TO ACCIDENTALLY OPEN WHILE THE VEHICLE IS IN MOTION. THE DOOR MAY OPEN WITHOUT WARNING AND WITHOUT KNOWLEDGE TO THE DRIVER.
The risk: IF THE DOOR OPENS, THE SCBA CYLINDERS MAY FALL OUT OF THE COMPARTMENT AND ONTO THE ROADWAY, INCREASING THE RISK OF A CRASH OR INJURY TO PEDESTRIANS.
The remedy: PIERCE DEALERS WILL NOTIFY OWNERS, AND WILL INSTALL A FLAT REINFORCEMENT PLATE THAT SPANS THE LENGTH OF THE SCBA DOOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 5, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
PIERCE MANUFACTURINGManufacturer number 74B186View on NHTSA.gov
05V355000

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Aug 10, 2005
150 units potentially affected
The defect: ON CERTAIN FIRE TRUCKS, INTERFERENCE MAY OCCUR BETWEEN THE AERIAL FRONT AXLE INTERLOCK SENSOR BRACKET AND THE FRONT AIR BRAKE HOSE. THIS CONDITION OCCURS DURING FULL TURN STEERING AND FULL SUSPENSION JOUNCE COMPRESSION.
The risk: THIS INTERFERENCE MAY CAUSE CHAFING LEADING TO A POTENTIAL FRONT AIR BRAKE HOSE FAILURE. IN THE EVENT OF A FRONT BRAKE HOSE FAILURE, LOSS OF FRONT BRAKING WILL OCCUR, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REMOVE THE EXISTING FRONT AXLE INTERLOCK SENSOR BRACKET AND INSTALL A NEW BRACKET IN A NEW LOCATION AVOIDING THE FRONT AXLE BRAKE HOSE. THE RECALL BEGAN ON OCTOBER 13, 2005. OWNERS MAY CONTACT PIERCE AT 920-832-3249.
PIERCE MANUFACTURINGView on NHTSA.gov
05V220000

SUSPENSION

May 12, 2005
49 units potentially affected
The defect: CERTAIN FIRE TRUCKS EQUIPPED WITH HOLLAND/NEWAY AIR SUSPENSION SYSTEMS, A TRANSVERSE BEAM CASTINGS MAY FRACTURE UNDER NORMAL LOADS. IF A CASTING BREAKS WHEN THE VEHICLE IS TRAVELING ON A ROADWAY THERE IS THE POTENTIAL FOR PIECES OF THE CASTING TO BECOME PROJECTILES AND THE SUSPENSION?S TRANSVERSE BEAM MAY DROP DOWN LOW ENOUGH TO CONTACT THE ROAD SURFACE.
The risk: THIS WILL CAUSE SPARKS THAT COULD POTENTIALLY IGNITE AND CAUSE A FIRE.
The remedy: HOLLAND IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE DEFECTIVE TRANSVERSE BEAM ASSEMBLIES FREE OF CHARGE. OWNERS MAY CONTACT HOLLAND AT 616-396-6501 OR PIERCE AT 1-888-974-3723.
PIERCE MANUFACTURINGView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .