2004 Pontiac Aztek Owner Complaints

I HAVE BEEN SMELLING GAS FROM MY CAR FOR YEARS BUT JUST NEVER HAD THE MONEY TO GET IT LOOKED AT. I EVEN CALLED ABOUT RECALLS CONCERNING THE FUEL SYSTEM THAT I FOUND OUT ABOUT THROUGH RESEARCH IN 2015 BUT WAS TOLD THEY HAD BEEN CLOSED SO I WOULD BE CHARGED FOR THE REPAIRS EVEN IF IT WAS PREVIOUSLY COVERED UNDER RECALL. I NO LONGER FILL MY TANK WITH GAS BECAUSE THERE IS A LEAK. I JUST GOT MY CAR BACK FROM THE DEALERSHIP, THEY STATE THAT I NEED A NEW FUEL TANK, AND FUEL LEVER SENSOR AND SENDER. ALSO, HAVE OIL LEAKS IN 2 PLACES, THEY TELL ME I NEED UPPER & LOWER INTAKE GASKETS. AS WELL AS VALVE COVER GASKETS & OIL PUMP DRIVE O-RING REPLACED AND OIL PAN GASKET REPLACED. ALSO, NEEDS WATER PUMP AND DRIVE BELT REPLACED.I ALSO FOR THE PAST 3 OR SO YEARS HAVE TO KEEP A PEN OR PENCIL IN MY CAR TO INSERT UNDER THE STEERING WHEEL TO RELEASE MY KEY .

NHTSA ID

11322711

Incident

Apr 25, 2020

FUEL TANK IS LEAKING; THERE IS A HISTORY OF A RECALL THAT HAS NEVER BEEN REPAIRED ON THIS VEHICLE. IT IS A SAFETY ISSUE.

NHTSA ID

11319899

Incident

Mar 31, 2020

Mileage

117,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT WHILE DRIVING 20 MPH CRASHED INTO A GMC ENVOY AND FLIPPED OVER LANDING ON THE ROOF. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR TO THE FAILURE. A POLICE REPORT WAS FILED. THE SEAT BELT FAILED TO UNLOCK AS THE CONTACT WAS CUT FROM THE VEHICLE. THE CONTACT STRUCK THE STEERING WHEEL, WAS UNCONSCIOUS, AND SUSTAINED INJURIES TO THE EYE WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE OCCUPANT OF THE GMC HAD NO REPORTED INJURIES. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 171,000. *DT CONSUMER STATED SHE HAS LOST HER EYE SIGHT DUE TO AIRBAG FAILURE.*JB*DT*JB

NHTSA ID

11319417

Incident

Feb 21, 2020

Mileage

171,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 35 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE FINALLY STOPPED BEFORE REACHING AN INTERSECTION. THE CONTACT NOTICED THAT BRAKE FLUID WAS LEAKING AND THE BRAKE HOSES WERE FRACTURED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE BRAKE SYSTEM WAS FRACTURED. THE BRAKES AND HOSES WERE REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000.. *BF CONSUMER STATED POWERSTEERING HIGH PRESSURE RUPTURED DUE TO RUST. THE DAY THE BRAKE LINES WERE GETTING REPAIRED CONSUMER WAS TOLD FUEL LINE FROM THE PUMP TO THE INJECTORS WAS ALSO RUSTED AND WOULD LEAK ANYTIME. *JB

NHTSA ID

11170542

Incident

Jan 7, 2019

Mileage

95,000 mi

MY CAR TURN OFF ON MY CHILDREN AND I ON THE HIGHWAY THANK GOD WE WAS ABLE TO COAST ON THE SIDE OF THE ROAD. MY MECHANIC SAID THAT MY IGNITION CONTROL MODULE WENT OUT OUTTA NO WHERE NOT ONLY THAT CRANKSHAFT SENSOR AND FUEL LINE EXHAUSTED SYSTEM SOMETHING WRONG ENGINE LIGHT STILL ON. WITH THAT BEING SAID I'M GREAT MY CHILDREN WAS NOT HURT DOING THIS ORDEAL. I LEARNED THAT THESE CARS HAVE FEW COMPLAINTS. BUT DO HAVE SOME ISSUES WITH ELECTRICAL SYSTEM AND VACUUM HOW'S EXHAUSTED. JUST GOT THE CAR I MARCH AND FOUND OUT BOUT THIS RECALL I'M SO DISAPPOINTED SCARED TO DRIVE THIS CAR RIGHT NOW.

NHTSA ID

11104927

Incident

Jun 18, 2018

Mileage

10 mi

"TAKATA RECALL" ON MY CAR THE ELECTRONIC IS NOT WORKING AND HASN'T BEEN FOR A LONG TIME, THE LIGHTS KEEP COMING ON AND WON'T GO BACK OFF. AND THE GAS TANK IS NOT WORKING RIGHT, I CAN'T GET GAS INTO MY TANK , IT DOES GO IN BUT I HAVE TO KEEP TRYING BECAUSE IT POPS OUT AND DON'T LET ME PUT GAS IN IT.

NHTSA ID

11030407

Incident

Jan 1, 2012

Mileage

19,000 mi

I WAS DRIVING DOWN THE HIGHWAY FOR 45 MINUTES AND WHEN GOT HOME NOTICE THERE WAS GAS COMING FROM MY PONTIAC AZTEC. DID SOME RESEARCH AND NOTICE THERE'S A RECALL. CALL BUICK AND THEY TOLD ME MY VIN IS NOT COVER UNDER THE RECALL. REALLY?

NHTSA ID

10927918

Incident

Nov 25, 2016

LIGHTING GOES OUT AT NIGHT WHICH IS VERY DANGEROUS

NHTSA ID

10896214

Incident

May 16, 2016

I HAVE NOT DRIVEN MY VEHICLE FOR 2 MONTHS BECAUSE MY MECHANIC TOLD ME MY VALVE COVER GASKETS WERE LEAKING ON TO MY EXHAUST MANIFOLD AND THAT IT WHY IT WAS SMOKING WHEN WE STOPPED. I TALKED TO MY LOCAL GM DEALER AND THEY SAID IT IS NOT PART OF THE RECALL SO THEY COULD NOT HELP, SO I HAVE THREE CHOICES LET IT SIT IN MY DRIVEWAY, PAY SEVERAL HUNDRED DOLLARS TO GET IT FIXED OR DRIVE IT TILL IT STARTS ON FIRE. IT HAS THE 3800 MOTOR LIKE ALL THE OTHER CARS IN THE RECALL. I CAN GET A LETTER FROM MY MECHANIC IF NEEDED.

NHTSA ID

10788443

Incident

Sep 7, 2015

Mileage

204,000 mi

KEY STUCK IN IGNITION ONCE CAR TURNED OFF. THIS HAS HAPPENED INTERMITTENTLY SINCE FIRST OCCURRED IN 2010. THE ONLY WAY TO REMOVE KEY IS TO OVERRIDE PARK SHIFT INDICATOR, WHICH WOULD ALLOW KEY TO BE REMOVED WHILE VEHICLE IN MOTION, THEREBY DISABLING POWER STEERING AND BRAKING. THERE IS NO FIX THAT DOES NOT INVOLVE OVERRIDING PARK SHIFT INDICATOR PER DEALER.

NHTSA ID

10747944

Incident

Apr 1, 2010

Mileage

70,000 mi

KEY STUCK IN IGNITION ONCE CAR TURNED OFF. THIS HAS HAPPENED INTERMITTENTLY SINCE FIRST OCCURRED IN 2010. THE ONLY WAY TO REMOVE KEY IS TO OVERRIDE PARK SHIFT INDICATOR, WHICH WOULD ALLOW KEY TO BE REMOVED WHILE VEHICLE IN MOTION, THEREBY DISABLING POWER STEERING AND BRAKING. THERE IS NO FIX THAT DOES NOT INVOLVE OVERRIDING PARK SHIFT INDICATOR PER DEALER.

NHTSA ID

10747942

Incident

Apr 1, 2010

Mileage

70,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE REFUELING THE VEHICLE, THE CONTACT WAS NOTIFIED THAT FUEL WAS SPILLING ONTO THE GROUND. THE CONTACT NOTICED THAT THE WELD OF THE FUEL LINE WAS FRACTURED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE) AND NHTSA CAMPAIGN NUMBER: 03V454000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 104,000. UPDATED 09/14/15*LJ

NHTSA ID

10724672

Incident

Jun 10, 2015

Mileage

104,000 mi

I HAVE BEEN HAVIBG ISSUES WITH MY CALL STALLING AND FUEL LEAKAGE FPR AWHILE NOW AND WHILE CHECKING THE WEBSITE FOR RECALLS I NOTICED THERE WERE 4 RECALLS ON MY CAR. WHEN CALLED TO TRY AND HAVE THE RECALLS FIXED, I WAS TOLD THAT MY CARS VIN WASN'T ON THE LIST FOR ANY RECALLS. BUT THE ISSUES DESCRIBED IN THE RECALL IS THE EXACT ISSUE I HAVE BEEN EXPERIENCING FIR THE LAST YEAR OR SO. WHY NOT LET ME BRING THE CAR IN TO BE CHECKED AND IF THE ISSUE MY CAR IS HAVING IS THE PARTS ON THE RECALL LIST, JUST REPLACE THEM. BUT NO NOT GM, THEY REFUSED TO EVEN LOOK AT THE CAR. SO DISAPPOINTED IN GM, ESPECIALLY SINCE I JUST BOUGHT ANOTHER GM VEHICLE. LOOKING IN TO REPLACING IT NOW.

NHTSA ID

10721008

Incident

May 22, 2015

DRIVING CAR ON ROAD AND CAR QUIT RUNNING, ELECTRICAL STARTED FLASHING. PULLED OVER AND IGNITION SWITCH WOULD ONLY GO TO ACC. MODE, IT WOULD NOT TURN TO OFF POSITION. I HAD CAR TOWED TO MY HOUSE. THE IGNITION WILL ONLY GO TO ACC. MODE WILL NOT TURN TO OFF POSITION WHERE KEY CAN BE REMOVED..UNHOOKED BATTERY TERMINAL AND CAR IS STILL PARKED. *TR

NHTSA ID

10678243

Incident

May 9, 2014

Mileage

124,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE ACCELERATED INDEPENDENTLY AND THE CHECK ENGINE, FUEL TANK, AND FUEL PRESSURE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 158,000.

NHTSA ID

10676885

Incident

Jan 19, 2015

Mileage

158,000 mi

SEEMS LIKE THE VAN HAS BEEN LEAKING FUEL FOR SOMETIME NOW AS AN ODOR OF GAS COULD BE SMELLED WHEN DRIVING BUT NEVER REALIZED IT UNTIL THE VAN WAS PARKED ON THE CARPORT AND SAW A PUDDLE OF FUEL ON THE GROUND. *TR

NHTSA ID

10654959

Incident

Aug 1, 2014

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 15 MPH, THE ENGINE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10638500

Incident

Jun 2, 2008

ABS SYSTEM LIGHTS WENT ON AND ABS SYSTEM EXHIBITS CRUNCHING, GRINDING, NOISY AND ABNORMAL PULSING OPERATION. JUNE 2012 MESSAGE INDICATES RF HUB NEEDS REPLACEMENT. DONE. ABS SYSTEM ACTS UP AGAIN IN UNDER 30 DAYS SAME SYMPTOMS. REAR BRAKES/DRUM REPLACED 6/2013, ABS PROBLEMS STILL PRESENT. FRONT BRAKES REPLACED 8/2013, ABS PROBLEMS STILL PRESENT. 8/2013 TAKEN TO GM DEALER SERVICE FOR ANALYSIS. SPEED SENSOR REPLACED, ABS PROBLEM STILL PRESENT. DEALER ADVISES THAT LF HUB NEEDS REPLACING AND ABS HARNESSES ON BOTH SIDES. 8/2014 LF HUB REPLACED AND ERROR MESSAGE NOW READS THAT RF HUB IS BAD AGAIN. TAKING BACK TO GM DEALER THIS WEEK TO TRY AND FIND THE DEFINITIVE SOLUTION. CONTINUED ONE BY ONE REPAIRS THAT DO NOT FIX THE PROBLEM HAVE BEEN A CONSTANT STREAM. NOTE: RR HUB WAS ALSO REPLACED IN 2011. *TR

NHTSA ID

10619291

Incident

Jun 1, 2012

Mileage

129,219 mi

THE GAUGES MESSED UP FIRST NONE OF THE GAUGES WORK SOMETIMES THE SPEED ODOMETER WILL MOVE BUT DOES NOT WORK . THE CAR ALSO WHEN ACCELRATING THE GAS IT WONT GO THE WAY IT SHOULD IT TAKES ALONG TIME TO BUILD UP SPEED. I HAVE SPENT A LOT OF MONEY ON THIS CAR TRYING TO GET IT TO RUN PROPER I HAVE REPLACED THE TRANSMISSION AND I HAVE HAD IT IN THE SHOP AT G.M.C TO HAVE THE ISSUE WITH THE FUEL SYSTEM ISSUE THEY REPLACED A PART BUT IT DID NOT RESOLVE THE PROBLEM THEY HAD NO IDEA WHAT THE PROBLEM WAS AND THIS WAS TEAGUE CHEVROLET-BUICK INC MABANK, TX, 75147. AS OF MAY 2, 2014 THE CAR WANT STAY RUNNING THIS HAS SOMETHING TO DO WITH THE FUEL SYSTEM I JUST FOUND OUT ABOUT THE RECALL I WAS NEVER NOTIFIED ABOUT THIS I ONLY FOUND OUT CAUSE I WAS SERCHING ON WHAT COULD BE WRONG WITH MY AZTEK AND I FOUND THE RECALL THIS AXTEK IS A REAL LEMON. *TR

NHTSA ID

10604980

Incident

Apr 23, 2012

Mileage

122,948 mi

THE AIR BAGS DEPLOYED BURNING DRIVERS CLOTHES ON THE LEFT WRIST. THE DRIVERS RIGHT KNEECAP WAS FRACTURED BY HITTING THE DASH WHEN THE VEHICLE STRUCK A POWER POLE. *TR

NHTSA ID

10553571

Incident

Nov 12, 2013

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT WHEN THE BRAKE WAS ENGAGED WHILE DRIVING AT LOW SPEEDS, THE BRAKE GRABBED AND EXHIBITED A GRINDING NOISE. IN ADDITION, THE ANTI-LOCK BRAKING SYSTEM WARNING LIGHT ILLUMINATED. THE FAILURE WAS EXPERIENCED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPLACED THE FRONT BRAKE PADS AND CALIPERS HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO EXHIBIT THE SAME FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 49,000.

NHTSA ID

10477041

Incident

Jun 1, 2010

Mileage

38,000 mi

I WAS PULLING OUT OF A GAS STATION INTO TRAFFIC,AS I ENTERED TRAFFIC ALL POWER SHUT DOWN FORCING ME TO COAST TO THE SHOULDER OF THE HIGHWAY. *TR

NHTSA ID

10472577

Incident

Aug 17, 2012

MY 2004 PONTIAC AZTEC RALLY EDITION HAS A LEAK IN THE FUEL TANK. THE DEALERSHIP IS TELLING ME THAT IT IS NOT ON RECALL. I SEE RECALLS ON THE SYSTEM. NEED TO KNOW WHY MY MODEL HAS NOT BEEN RECALL. *TT

NHTSA ID

10462530

Incident

Jun 21, 2012

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT THE VEHICLE WOULD PROVIDE INACCURATE READINGS FOR VARIOUS COMPONENTS ON THE INSTRUMENT PANEL. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,070 AND THE CURRENT MILEAGE WAS 121,000.

NHTSA ID

10452505

Incident

Feb 28, 2012

Mileage

120,070 mi

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL, THE ALL WHEEL DRIVE WARNING LIGHT AND THE ANTILOCK BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT SHE FELT THE METAL WITHIN THE BRAKE PEDAL RUBBING TOGETHER WHILE APPLYING THE BRAKES. A LOCAL MECHANIC REPLACED THE BRAKES, BUT THE FAILURE RECURRED. THE MECHANIC THEN DETERMINED THAT THE ELECTRONIC CONTROL MODULE WAS DEFECTIVE. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 61,444. UPDATED 04/11/12*LJ UPDATED 04/17/12

NHTSA ID

10451698

Incident

Jun 1, 2011

Mileage

57,000 mi