1998 Pontiac Bonneville Owner Complaints

ENGINE COMPARTMENT FIRE APPROXIMATELY 30 MINS AFTER SHUTDOWN. INCIDENT 2015-00001363

NHTSA ID

10764467

Incident

Mar 8, 2015

THE BACK TWO CRADLE MOUNTS ON BOTH SIDES RUSTED OUT AND MOUNTS PULLED THROUGH THE CRADLE CAUSING THE STEERING TO BECOME LOOSE FILLING AND CAUSING STEERING TO BE OUT OF ALIGNMENT AND WHEN HIT BRAKES FRONT WOULD DART ONE WAY OR THE OTHER AND LOTS OF NOISE COMING FROM UNDER VEHICLE FROM CRADLE BOUNCING WHEN HITTING BUMPS TRIED THE FIND ONE IN JUNK YARDS AND ALL ARE THAT WAY. *TR

NHTSA ID

10713247

Incident

Apr 3, 2015

Mileage

105,673 mi

MY CAR HAS BEEN STOLEN FROM SIOUX FALLS RESIDENTS HOME JULY 10 TH BUT HAVE A POLICE REPORT [XXX] BEEN SPOTTED IN MITCHELL OFF INTERSTATE 90 FIRST PARKING LOT RIGHT AFTER EXIT 90 INTO MITCHELL TANISH COLOR TRUNK HAS BUNNGIE CORD ON TRUNK SILVER SMALL SPOT ON PASSENGER SIDE PONTIAC 1998. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10622608

Incident

Jul 10, 2014

I WAS DRIVING ON THE NEW YORK THRUWAY AND ALL OF A SUDDEN, MY CAR SHUT OFF. I HAD TO POWER STEER, NO POWER BRAKES, THE FUEL GAUGE READ NO FUEL AND THE BELLS WENT OFF. I HAD TO TRY TO GET TO A SAFE PLACE AND RESTART MY CAR. THIS HAS HAPPENED MANY MORE TIMES. I CAN BE GOING 25MPH OR 70MPH; I CAN HAVE THE CRUISE ON OR OFF; I CAN HAVE THE HEAT OR A/C ON OR OFF, IT DOES NOT MATTER; IN ALL CASES, THE ENGINE SHUTS OFF WHEN I AM NOT EXPECTING IT. *JS

NHTSA ID

10608590

Incident

Apr 14, 2004

Mileage

50,000 mi

ON MULTIPLE OCCASIONS I HAVE PULLED TO A DEAD STOP AT A LIGHT AND DURING THE IDLING TIME THE ENGINE SHUTS OFF AND IT WILL NOT START AGAIN. VERY EMBARRASSING SET OF TRIPS TO NEARBY GROCER. .. *TR

NHTSA ID

10595871

Incident

Apr 24, 2013

TL* THE CONTACT OWNS A 1998 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE POWER STEERING SUDDENLY FAILED CAUSING THE STEERING WHEEL VERY DIFFICULT TO TURN. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CONCRETE ROAD DIVIDER. THE CONTACT SUSTAINED A BACK INJURY THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 164,000. DR

NHTSA ID

10593415

Incident

Apr 11, 2013

Mileage

164,000 mi

AS I WAS DRIVING ALONG THE ENGINE, POWER STEERING, AND BRAKES FAILED. I HAD TO RESTART THE CAR AND HOPEFULLY RESUME DRIVING SO THE CAR COMING BEHIND ME DID NOT CRASH INTO ME. THIS HAS HAPPENED NUMEROUS TIMES SINCE INCLUDING TIMES WHILE ON I-95, I-81, RURAL MOUNTAINOUS ROADS (WHICH RESULTED IN MY CAR ROLLING BACKWARDS), AND CITY TRAFFIC. I HAVE TAKEN IT IN NUMEROUS TIMES TO MY MECHANIC AND HE HAS NOT COME UP WITH A REASON AS TO WHY THIS IS HAPPENING. I AM GIVEN NO WARNING BY MY CAR THAT THIS IS ABOUT TO HAPPEN. THE WARNING BELL CHIMES AND THE CAR FAILS AT THE SAME TIME. THIS HAPPENED LAST EVENING AND THE CAR BEHIND ME HAD TO SWERVE TO AVOID A CRASH. PLEASE ADD MY CAR TO YOUR RECALL OR GIVE ME SOME KIND OF ANSWER TO TAKE TO MY MECHANIC. *TR

NHTSA ID

10574017

Incident

Sep 23, 2002

Mileage

52,000 mi

TL* THE CONTACT OWNS A 1998 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND IT WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 53,506.

NHTSA ID

10557467

Incident

Aug 8, 2002

Mileage

53,506 mi

TL* THE CONTACT OWNS A 1998 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE OVERHEATED. THE CONTACT THEN ATTEMPTED TO PARK THE VEHICLE HOWEVER, THE VEHICLE THEN STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE INTAKE MANIFOLD WAS MELTED AND THE HEAD GASKET WAS BLOWN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 62,000.

NHTSA ID

10507450

Incident

Mar 30, 2013

Mileage

62,000 mi

ABOUT A WEEK PRIOR TO INCIDENT, I GOT A WHIFF OF A BURNING SMELL, 2 DAYS IN A ROW, SHORT QUICK SCENT. NEXT 4 DAYS, SMELLED NOTHING (EVEN DROVE CAR 80 MILES ONE WAY AND BACK). DAY OF INCIDENT, I WAS TRAVELING ABOUT 10 MPH WHEN WHITE SMOKE CAME FROM THE HEATER VENT. I INCREASED SPEED TO ABOUT 30 MPH TO GET TO A SAFE SPOT, AND BLACK SMOKE BILLOWED OUT OF HEAT VENT ON TOP OF DASHBOARD, AND FRONT OF DASHBOARD. TURNED CORNER TO GET OUT OF TRAFFIC, CAME TO A STOP AND FLAMES SHOT OUT OF CIGARETTE LIGHTER, AND AIR VENT IN FRONT OF DASH. HEATER WAS OFF, RADIO WAS OFF, AND CIGARETTE LIGHTER WAS NOT BEING USED. CAR FULLY ENGULFED IN APPROXIMATELY 2-3 MINUTES. CAR TOTALED. *TR

NHTSA ID

10502559

Incident

Mar 8, 2013

Mileage

258,000 mi

TL* THE CONTACT OWNS A 1998 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH THE VEHICLE SUDDENLY STALLED. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT IT HESITATED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE PLASTIC GASKET FROM THE INTAKE MANIFOLD FAILED AND CAUSED ENGINE COOLANT TO LEAK INTO THE ENGINE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR DIAGNOSTICS.THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIANS REPLACED THE INTAKE MANIFOLD AND THE INTAKE MANIFOLD GASKET. AFTER THE REPAIRS, THE CONTACT HEARD A KNOCKING NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TOWED BACK TO THE DEALER FOR DIAGNOSTICS, BUT WAS NOT REPAIRED A SECOND TIME. THE APPROXIMATE FAILURE MILEAGE WAS 80,433.

NHTSA ID

10413890

Incident

Jun 22, 2011

Mileage

80,433 mi

98 PONTIAC 86,000 MILES INTAKE MANIFOLD FAILED FOR THE SECOND TIME... PARTS REPLACED...SPARK PLUGS (FOULED)..STARTER ASSEMBLY.. MOTOR WAS WATERLOCKED BROKE STARTER...INTAKE MANIFOLD GASKET REPLACED.....OIL CHANGED DUE TO COOLANT CONTAMINATION...REPLACE ANTIFREEZE...TOTAL BILL LABOR AND PARTS... $1387.99..GM HAS NUMEROUS SERVICE BULLETINS ON THIS ISSUE...WHY HAS A RECALL NOT BE ISSUED FOR THIS PROBLEM ?? *TR

NHTSA ID

10409152

Incident

Feb 1, 2011

Mileage

84,222 mi

THE AIR INTAKE GASKET HAS FAILED FOR 2 REASONS. 1 FACTORY TIGHTLY PUT THE BOLTS ON TO TIGHT. 2 PLASTIC GASKET AND PLASTIC MANIFOLD PARTS DO NOT MEET GOVERNMENT SAFETY STANDARDS FOR, FAILURE AVOIDANCE, BECAUSE OF MATERIALS USED TO CONNECT THE PLASTIC TO METTLE CREATING A DANGEROUS SITUATION. *TR

NHTSA ID

10409124

Incident

Jun 23, 2011

Mileage

80,268 mi

MY UPPER INTAKE MANIFOLD LEAKS ENGINE COOLANT INTO THE COMBUSTION CHAMBERS AND INTO THE CRANKCASE. THE EGR TUBE MELTS THE UPPER PLASTIC MANIFOLD I HAVE HAD THE UPPER AND LOWER INTAKE REPLACED FOR THIS ISSUE ONCE BEFORE WITH GM PARTS AND IT HAPPENING AGAIN. IF IT NOT FIXED THE COOLANT CAN CONTAMINATE MY OIL AND LOCK UP MY ENGINE WHEN TRAVELING DOWN THE ROAD AND POSSIBLY CAUSE ME TO CRASH. IF THE ENGINE LOCKS UP I WILL LOSE POWER STEERING AND BRAKING ABILITY. *TR

NHTSA ID

10351151

Incident

Aug 22, 2010

Mileage

129,000 mi

I OWN A 1998 PONTIAC BONNEVILLE SE. I SAW RECENTLY THAT GM WAS RECALLING 1.5 MILLION VEHICLES WITH THE 3800 3.8 LTR V6. WAS WONDERING HOW THEY COULD RECALL THOSE VEHICLES AND NOT MINE, MY CAR IS IN THE SAME YEAR RANGE "1998" AND HAS THE EXACT MOTOR "3800 3.8 V6" AND OIL DRIPS ON MANIFOLD ON MY CAR AS WELL. WHAT KIND OF INFO CAN I GET ON THIS? THANK YOU *TR

NHTSA ID

10265380

Incident

Jan 1, 2006

98 BONNEVILLE WITH 3800 SERIES ENGINE. NOTICED COOLANT WAS LOW SO I ADDED COOLANT, THEN REPLACED THERMOSTAT BECAUSE HEATER WAS PUTTING OUT COLD AIR. SAW BIG CLOUD OF WHITE SMOKE. TOOK TO THE DEALER AND THEY SAID THAT DUE TO A KNOWN DEFECT INVOLVING A PLASTIC MANIFOLD AND EGR VALVE THAT THE COOLANT HAD MIXED WITH THE OIL DUE TO HOLES CAUSED BY THE DEFECT IN THE UPPER AND LOWER MANIFOLDS. CALLED PONTIAC DIRECTLY AND THEY SAID SORRY ABOUT YOUR SITUATION BUT NO RECALL. CONTACTED PREVIOUS OWNER AND HE SAID THE SAME THING HAPPENED 3 YEARS AGO AND HE HAD THE SAME THING FIXED. LONG STORY SHORT, I'M SPENDING $1400 FOR A PROBLEM THAT THE ENGINEERS OF THIS ENGINE KNEW WAS A PROBLEM FROM THE BEGINNING OF PRODUCTION. *TR

NHTSA ID

10252086

Incident

Dec 14, 2008

Mileage

131,000 mi

6 MONTHS AFTER PURCHASING THIS PROFESSIONAL CARED FOR CAR (GM GARAGE 8YRS) FROM MY MOTHER WITH ONLY 62,000 MILES ON IT I BEGAN SEEING COOLANT ON THE ENGINE WHICH LED ME TO HAVE MY MECHANIC AT PRECISION TUNE AUTO CARE TAKE A LOOK. HE SAID IT IS LIKELY A LEAK FROM EITHER THE PLENUM OR THE GASKET. AFTER DIGGING INTO IT THEY ENDED UP REPLACING UPPER PLENUM AND LOWER INTAKE GASKET AND COOLANT AND OIL. COST WAS 739.71. MILEAGE ON CAR AT THAT TIME WAS 78540. I HAVE RECEIPT FROM PRECISION. *TR

NHTSA ID

10240624

Incident

Dec 27, 2007

Mileage

78,540 mi

TL*THE CONTACT OWNS A 1998 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE REAR BRAKE LINE, FROM LEFT TO RIGHT, FAILED IN THE REAR PASSENGER SIDE WHEEL AND LEAKED BRAKE FLUID. SUBSEQUENTLY, THE FAILURE CAUSED BRAKE FAILURE. WHILE DRIVING 15 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE SALES DEALER ADVISED THE CONTACT TO CONSULT THE MANUFACTURER. THE MANUFACTURER STATED THAT IF HE ONLY HAD 100,000 MILES ON THE VEHICLE, THEY WOULD HAVE REPLACED THE BRAKE LINE. THE CURRENT MILEAGE WAS 111,526 AND FAILURE MILEAGE WAS 111,520. UPDATED 10/14/08. *LJ THE CONSUMER STATED THE BRAKE LINES WERE RUSTED AND PITTED. UPDATED 10/16/08. *JB

NHTSA ID

10232690

Incident

Jun 28, 2008

Mileage

111,520 mi

TL*THE CONTACT OWNS A 1998 PONTIAC BONNEVILLE. WHEN THE ENGINE WAS TURNED OFF, FLUID LEAKED ONTO THE GROUND FROM BENEATH THE ENGINE COMPARTMENT. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR A MECHANIC. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V090000 (FUEL SYSTEM, GASOLINE:DELIVERY). THE FAILURE MILEAGE WAS 154,000 AND CURRENT MILEAGE WAS 154,735. UPDATED

NHTSA ID

10215788

Incident

Dec 20, 2007

Mileage

154,000 mi

DRIVERS SIDE AND PASSENGERS SIDE AIRBAGS DID NOT DEPLOY IN AUTO ACCIDENT. FRONT DRIVERS SIDE IMPACT THEN ROLLED 3 TIMES.*CN

NHTSA ID

10213492

Incident

Dec 31, 2007

1998 PONTIAC BONNEVILLE POOR PRODUCTION MANIFOLD/GASKETS. CUSTOMER STATES THAT THE MANIFOLD/GASKETS AND DEX. COOL WERE IN POOR PRODUCTION ON HER VEHICLE. *KB THE UPPER INTAKE MANIFOLD NEEDED TO BE REPLACED. THE THERMOSTAT AND GASKET HAD COOLANT IN THEM. THE MASS AIR FLOW SENSOR WAS BAD. METAL FRAGMENTS WERE FOUND IN THE OIL WHICH WAS COMING FROM, THE ROD BEARING THAT FAILED DUE TO THE VEHICLE OVER HEATING AND COOLANT IN THE OIL. THE CATALYTIC CONVERTER NEEDED TO BE REPLACED BECAUSE THE VEHICLE WAS RIDING ROUGH AND THE ENGINE WAS SHAKING. THE CONSUMER STATED THERE WAS A RECALL ON THE VEHICLE TO PREVENT THE MANIFOLD FROM CRACKING. AFTER THE RECALL WAS PERFORMED IN JULY 2004, THE MANIFOLD CRACKED ONE MONTH LATER. THE CONSUMER STATED EVER SINCE THE RECALL WAS PERFORMED SHE HAS ENGINE PROBLEMS. THE CONSUMER STATED WHEN THE UPPER INTAKE MANIFOLD WAS REPLACED IN AUGUST 2004 THE LOWER MANIFOLD SHOULD HAVE BEEN REPLACED AS WELL TO PREVENT FUTURE DAMAGE, HOWEVER SINCE IT WAS NOT REPLACED, STOP LEAK PELLETS MIXED WITH THE DEX-COOL AND THE LOWER INTAKE MANIFOLD LEAKED.

NHTSA ID

10201569

Incident

Aug 27, 2004

I AM THE OWNER OF A 1998 PONTIAC BONNEVILLE WITH A 3800 ENGINE. I AM THE ORIGINAL OWNER AND THE CAR HAS LESS THEN 42,000 MILES ON IT. THE UPPER INTAKE (PLENUM) AND SEALS HAVE FAILED RESULTING IN COOLANT LEAKING INTO THE ENGINE. I PHONED AN ACQUAINTANCE WHO WORKED AS A TECHNICIAN AT THE GM POWER TRAIN ENGINEERING FACILITY IN FLINT, MICHIGAN WHERE THE 3800 ENGINE WAS ENGINEERED. HE SAID IT WAS COMMON KNOWLEDGE BY THE ENGINEERING SKILLED TRADES EMPLOYEES THAT THE UPPER INTAKE DESIGN WAS FLAWED. THERE WERE MANY INTAKE FAILURES OBSERVED DURING DYNAMOMETER TESTING. SOME EVEN EXPLODED. I WAS TOLD THAT THE ENGINEERS AND MANAGEMENT WAS WELL AWARE OF THE DEFECTIVE DESIGN, BUT FOR SOME REASON, CHANGES WERE NOT MADE. I CAN DIRECT INVESTIGATORS TO EMPLOYEES WHO WITNESSED INTAKE DESIGN FAILURES IN THE TESTING FACILITIES. *NM

NHTSA ID

10182135

Incident

Feb 5, 2007

Mileage

41,500 mi

THE 3800 ENGINE IN MY PONTIAC HAS IN THE PAST TWO YEARS FOR SOME REASON HAS HAD TO HAVE THE INTAKE MANIFOLD REPLACED TWICE BECAUSE IT HAS CRACKED. I AM TRYING TO OUT IF THERE IS A RECALL OR SOME SORT OF REIMBURSEMENT FOR THIS PROBLEM ON THE 1998 PONTIAC BONNEVILLE OR OTHER 3800 SERIES ENGINES? *NM

NHTSA ID

10170734

Incident

Sep 27, 2006

Mileage

137,950 mi

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS STOPPED AT AN IDLE, THE ENGINE RPMS ELEVATED, AND THE OIL GAUGE INDICATED LOW PRESSURE, FOLLOWED BY ENGINE HESITATION. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED NO OIL LEAK WAS PRESENT, BUT A PLUG WIRE TO THE ENGINE CYLINDER NEEDED TO BE REPLACED. THE PROBLEM PERSISTED AFTER THE REPAIRS WERE PERFORMED. THE MANUFACTURER WAS CONTACTED.

NHTSA ID

10165120

Incident

Aug 10, 2006

Mileage

84,000 mi

DT*: THE CONTACT STATED, THERE WAS AN INTERMITTENT PROBLEM STARTING THE VEHICLE, A SEVERE HESITATION WHEN ACCELERATING FROM A STOP, AS WELL AS BACKFIRING OF THE ENGINE. AN INDEPENDENT SERVICE MECHANIC DISCOVERED LOW FLUID LEVELS IN THE RADIATOR, WET AND RUSTED SPARK PLUGS, CRACKED HEAD GASKETS AND THE PISTON HAD TORN THROUGH THE OIL PAN. THE MANUFACTURER THE RECALLED (04V090000) ITEM WAS REPLACED IN JULY OF 2004 BY THE PREVIOUS OWNER OF THE VEHICLE AND THE RECALL WAS CLOSED OUT. THE VEHICLE WAS TAKEN TO THE DEALER SERVICE MECHANIC FOR COMPUTER DIAGNOSTICS.*AK

NHTSA ID

10163487

Incident

May 31, 2006