2008 Pontiac G5 Suspension Problems

HI! I NOTICED VERY STRONG GAS FUMES AFTER FILLING MY CAR WITH GAS. I TOOK THE CAR TO THE DEALER ON FRIDAY, SEPTEMBER 22, 2017 AND HAD THE FUEL PUMP REPLACED, AFTER FILLING MY CAR WITH A TANK OF GAS, I NOTICED STRONG FUMES IN THE CAR. I NOTICED THE FUEL NEEDLE WENT FROM 401 MILES TO 388. I DROVE HOME PARKED MY CAR IN THE GARAGE MOMENTS LATER MY DAUGHTER ARRIVED HOME AND BEGAN COMPLAINING ABOUT THE STRONG GAS FUMES IN THE GARAGE AND GAS LEAKING UNDERNEATH MY CAR. I GOT OUT OF BED WENT INTO THE GARAGE, THEN I SMELT HEAVY GAS FUMES AND SAW THE GAS ON MY GARAGE FLOOR. I BACKED THE CAR OUT OF THE GARAGE AND LEFT THE GARAGE DOOR OPEN.

NHTSA ID

11025297

Incident

Sep 22, 2017

Mileage

158,000 mi

FRONT SUSPENSION BUSHINGS ON THE PONTIAC G5 AND PROBABLY CHEVROLET COBALT WEAR OUT RAPIDLY. ON MY VEHICLE THE DRIVER'S SIDE BUSHING FAILED AT 31,350 MILES AND THE PASSENGER SIDE AT 42,850 MILES. THE FACTORY REPLACEMENT ON THE DRIVERS SIDE IS STARTING TO FAIL AGAIN AT 44,500 MILES. FAILURE IS DEFINED AS A CLUNKING NOISE WHILE GOING OVER ROAD IMPERFECTIONS. THE DESIGN IS EITHER FAULTY OR THE PART IS PRODUCED BADLY AS NEITHER PART SHOWED EFFECTS OF THE RUBBER BEING BONDED TO THE METAL. ALL SUSPENSION BUSHINGS SHOULD HAVE THE RUBBER BONDED TO BOTH THE OUTER AND INNER METAL SLEEVE. WITHOUT BONDING, THE SUSPENSION BUSHING WILL MAKE NOISE IN THE SHORT TERM, BUT OVER TIME AS THE RUBBER DEGRADES, LARGE AMOUNTS OF SUSPENSION MOVEMENT THEN CAN CAUSE THE BOLT TO FAIL AND CAN LEAD TO LOSS OF VEHICLE CONTROL. GM SHOULD CORRECT THE DESIGN AND THEN PROVIDE REPLACEMENT PARTS AS NEEDED. *TR

NHTSA ID

10468415

Incident

Jun 15, 2011

Mileage

31,350 mi

THERE IS SOMETHING WRONG WITH THE STEERING IN THESE CARS. STEERING WILL STILL LOCK UP, AT LOW VEHICLE SPEEDS. THE RECALL TWO YEARS AGO HAS NOT HELPED THE SITUATION. THERE IS SOMETHING WRONG WITH THE STEERING COLUMN AND STEERING RACK WITH THESE CARS. SUSPENSION/STEERING CLUNKS AND RATTLES LIKE IT IS ABOUT TO FALL OFF! VERY UNSAFE! *JS

NHTSA ID

10462249

Incident

Jun 4, 2012

Mileage

85,500 mi

VEHICLE WAS BEING DRIVIN ON A TWO LANE HIGHWAY AND ALL OF THE SUDDEN THE FRONT RIGHT FELL TO THE GROUND AND THE CAR SPUN OUT AND SLID INTO A DITCH. THE FRONT RIGHT BALL JOINT FAILED AND BROKE APART. MY MECHANIC SAYS HE REPLACES BALL JOINTS ON THESE CARS AT THE RATE OF FIVE CARS PER MONTH. WHILE BEING REPAIRED, I HAD THE CONTROL ARM BUSHINGS, TIE RODS, AND SWAY BAR ENDLINKS REPLACED AGAIN BECAUSE THERE WERE RATTLING AND CLUNKING AGAIN. MY BROTHER WORKS AT A CHEVY DEALER AND HE SAYS THAT COBALT'S/G5'S/HHR'S COME IN ALL THE TIME FOR FRONT SUSPENSION PROBLEMS. GM KNOWS OF THESE ISSUES BUT DOES NOT WANT TO DO ANYTHING FOR IT'S CUSTOMERS WHEN THE WARRANTY RUNS OUT. A CRASH CAN VERY WELL HAPPEN IF ONE OF THESE COMPONENTS FAILS WHEN DRIVING AND THAT IS WHAT HAPPENED TO ME. EVERY SUSPENSION PART ON THESE CARS IS FAULTY. PLEASE LOOK INTO THE SUSPENSION PROBLEMS ON THESE CARS FURTHER. THANK YOU. *TR

NHTSA ID

10428387

Incident

Sep 20, 2011

Mileage

77,000 mi

VEHICLE STARTING MAKING CLUNKING AND RATTLING SOUNDS IN FRONT SUSPENSION. HAD TO HAVE LOWER CONTROL ARM BUSHINGS REPLACED, NEW TIE RODS, AND SWAY BAR LINKS INSTALLED. BEFORE THE REPAIRS, THE STEERING HAD BECOME EXTREMELY LOOSE AND WAS HARD TO HANDLE ON THE HIGHWAY. *TR

NHTSA ID

10428386

Incident

Jun 15, 2010

Mileage

40,000 mi

ON 2008 PONTIAC G5 THE LOWER CONTROL ARM BUSHINGS ARE WEARING OUT AT OR NEAR 18000 MI/ 30000 KM'S, MANY OWNERS OF THESE CARS HAVE NO IDEA OF THIS FAULT.

NHTSA ID

10393547

Incident

Apr 29, 2010

LEFT AND RIGHT REAR AXLE BUSHINGS NEEDED TO BE REPLACED IN A 2008 PONTIAC G5 WITH 34,000 MILES. VEHICLE WOULD MAKE A LOUD METAL TO METAL SOUND WHEN GOING OVER SPEED BUMPS. REAR SHOCKS WERE ALSO REPLACED DUE TO RUBBER MOUNTING BUSHINGS THAT HAD CRACKED AND FALLEN APART. *TR

NHTSA ID

10323908

Incident

Apr 5, 2010

Mileage

34,000 mi

CONTROL ARM BUSHINGS IN A 2008 PONTIAC G5 (CHEVY COBALT TWIN) NEEDED REPLACING AT 34,000 MILES. STEERING WOULD MAKE LOUD NOISES WHEN HITTING BUMPS AND WAS TOLD THAT THE STEERING CAN FALL APART IF NOT REPAIRED. *TR

NHTSA ID

10323907

Incident

Apr 5, 2010

Mileage

34,000 mi