2006 Pontiac Grand Prix Recalls

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.

GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.