1991 Pontiac Lemans Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Pontiac Lemans, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Seat belts1236.4%
- Brakes412.1%
- Powertrain (other)39.1%
- Driver assistance26.1%
- Suspension26.1%
- Engine26.1%
- Interior & seats26.1%
- Visibility13.0%
- Electrical13.0%
- Other / unspecified13.0%
- Steering13.0%
- Transmission13.0%
- Body & structure13.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
RECALL 94V248000/ MOTORIZED SHOULDER BELTS. INTERMITTENTLY, SHOULDER BELT GETS STUCK IN THE RAIL. DEALER DID PERFORM RECALL REPAIRS, BUT PROBLEM HAS REOCCURRED. *AK DURING RECALL REPAIR, THE BELT WAS GREASED BUT SHORTLY AFTER WARDS IT CONTINUED TO EITHER STOP HALF WAY OR NOT AT ALL. *YH
MOTORIZED SEAT BELT STICKS ON TRACK AT TEMPERATURES OF 30 DEGREES OR LESS, RELEASES ONCE TEMP WARMS UP AND VEHICLE IS TURN ON/OFF.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
VEHICLE IS EXPERIENCING FRONT END PROBLEMS. *YD *DT
EXPERINECED BRAKE FAILURE A NUMBER OF TIMES. WHILE DRIVING APPROXIMATELY 40-50MPH CONSUMER APPLIES BRAKES AND VEHICLE DID NOT STOP. CONSUMER TURNED THE IGNITION SWITCH OFF, AND LET VEHICLE DRIFT TO SIDE OF ROAD. VEHICLE HAD TO BE TOWED. PLEASE ADD VIN#. DEALERS HAVE SPRAYED THE LINKAGES A NUMBER OF TIMES BECAUSE TEY WERE NO ABLE TO FIND A PROBLEM. IN FEBRUARY, 1999, DEALER REPLACED BOTH FRONT AXLES, AND THE VERY NEXT DAY THE SAME THING HAPPENED. THERE WERE NO BRAKES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
EXPERINECED BRAKE FAILURE A NUMBER OF TIMES. WHILE DRIVING APPROXIMATELY 40-50MPH CONSUMER APPLIES BRAKES AND VEHICLE DID NOT STOP. CONSUMER TURNED THE IGNITION SWITCH OFF, AND LET VEHICLE DRIFT TO SIDE OF ROAD. VEHICLE HAD TO BE TOWED. PLEASE ADD VIN#. DEALERS HAVE SPRAYED THE LINKAGES A NUMBER OF TIMES BECAUSE TEY WERE NO ABLE TO FIND A PROBLEM. IN FEBRUARY, 1999, DEALER REPLACED BOTH FRONT AXLES, AND THE VERY NEXT DAY THE SAME THING HAPPENED. THERE WERE NO BRAKES. *AK
RIGHT REAR AXLE BROKE, CAUSING LOSS OF CONTROL/ACCIDENT. *AW
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
VEHICLE EXPERIENCED UNWANTED ACCELERATION WHEN RELEASING ACCELERATOR PEDAL AND BRAKING, VEHICLE WOULD NOT SLOW DOWN.
VEHICLE EXPERIENCED SUDDEN ACCELERATION, RESULTING IN A COLLISION.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
VEHICLE IS EXPERIENCING FRONT END PROBLEMS. *YD *DT
BRAKES SQUEAL WHEN BRAKE PEDAL IS APPLIED. *SKD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
VEHICLE IS EXPERIENCING FRONT END PROBLEMS. *YD *DT
ENGINE FIRE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
DOOR ON DRIVER'S SIDE DID NOT STAY CLOSED BECAUSE THE LATCHING MECHANISM BROKE. A ROPE HAD TO BE TIED AROUND THE DOOR TO KEEP IT FROM OPENING. GMC WAS NOTIFIED ABOUT THE PROBLEM. OWNER WAS TOLD THAT PART WAS NO LONGER MADE, AND TO TRY A JUNK YARD. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
RIGHT AFTER TURNING OFF THE IGNTION VEHICLE CAUGHT ON FIRE IN THE DASH AREA. OWNER WAS ABLE TO PUT OUT THE FIRE. THE PROBLEM WAS REPORTED TO THE DEALERSHIP. VEHICLE IS BEING REPAIRED. ALSO, WINDSHIELD WIPER MOTOR/TRANSMISSION AND WIRES ARE BEING REPLACED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
RIGHT AFTER TURNING OFF THE IGNTION VEHICLE CAUGHT ON FIRE IN THE DASH AREA. OWNER WAS ABLE TO PUT OUT THE FIRE. THE PROBLEM WAS REPORTED TO THE DEALERSHIP. VEHICLE IS BEING REPAIRED. ALSO, WINDSHIELD WIPER MOTOR/TRANSMISSION AND WIRES ARE BEING REPLACED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
VEHICLE IS EXPERIENCING FRONT END PROBLEMS. *YD *DT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
WHILE DRIVING THE BACK WHEEL JUST FELL OFF. PLEASE DESCRIBE. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
VEHICLE IS EXPERIENCING FRONT END PROBLEMS. *YD *DT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
RIGHT AFTER TURNING OFF THE IGNTION VEHICLE CAUGHT ON FIRE IN THE DASH AREA. OWNER WAS ABLE TO PUT OUT THE FIRE. THE PROBLEM WAS REPORTED TO THE DEALERSHIP. VEHICLE IS BEING REPAIRED. ALSO, WINDSHIELD WIPER MOTOR/TRANSMISSION AND WIRES ARE BEING REPLACED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
FRONT EXTERIOR DOOR LOCKS, DRIVER AND PASSENGER SIDE WILL NOT OPERATE NORMALLY.ALSO, MOTORIZED DRIVER'S SIDE SHOULDER BELT OPERATES ERRATICALLY SOMETIMES WILL NOT FUNCTION AT ALL. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .