RoadVitals

1992 Pontiac Trans Sport Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Jan 23, 1996
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
6 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

96V015000

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

Jan 23, 1996
585,182 units potentially affected
The defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
The risk: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
The remedy: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
GENERAL MOTORS CORP.View on NHTSA.gov
94V027000

SEAT BELTS:REAR/OTHER

Jan 4, 1994
157,740 units potentially affected
The defect: VEHICLE FAILS TO CONFORM TO FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE SAFETY BELT OF THE LEFT THIRD ROW SEAT ON THE SIX PASSENGER VAN AND THE CENTER SECOND ROW SEAT OF THE SEVEN PASSENGER VAN MAY LOCK UP AND CANNOT BE WITHDRAWN FROM THE RETRACTOR.
The risk: CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANTS OF THESE SEATS WILL NOT BE ABLE TO USE THE AFFECTED BELT. IN THE EVENT OF A VEHICLE CRASH, UNBELTED OCCUPANTS ARE AT INCREASED RISK OF INJURY.
The remedy: OWNERS ARE BEING ASKED TO INSPECT THEIR VEHICLES TO DETERMINE IF THE SUSPECT RETRACTOR EXHIBITS A LOCKUP CONDITION. BASED ON THIS INSPECTION, DEALERS WILL REPLACE THE SAFETY BELTS IF THE BELT LOCKS UP. REPLACEMENT OF THE SUSPECT SAFETY BELT WILL BE AVAILABLE TO CONSUMERS FOR THE LIFE OF THE VEHICLE.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

RQ03003ClosedRecall Query

ENGINE CRADLE SEPARATION

Opened Jan 8, 2003
Closed Apr 10, 2003

IN APRIL 1997, GM NOTIFIED ODI OF A REAR ENGINE CRADLE BOLT DEFECT IN CERTAIN MODEL YEAR (MY) 1990-91 U VANS AND MY 1988-91 W CARS THAT COULD RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR.GM IDENTIFIED THE PROBLEM AS EXCESSIVE CREVICE CORROSION OF THE ENGINE CRADLE RETAINER AFTER YEARS OF EXPOSURE IN A SEVERE CORROSIVE ENVIRONMENT.THE RECALL COVERED APPROXIMATELY 680,000 VEHICLES REGISTERED IN 14 RUST BELT STATES; INCLUDING ALMOST 70,000 MY 1990-91 U VANS.THE RECALLED VEHICLES RECEIVED NEW REAR CRADLE BOLTS AND RETAINERS. GM CHANGED THE MATERIAL COMPOSITION OF THE RETAINERS IN THE MY 1992 U VANS TO PROVIDE IMPROVED CORROSION RESISTANCE.THE MY 1992 RETAINERS ARE ALUMINIZED STEEL WITH A 2.5 MM PROTECTIVE COATING OF ZINC/CHROMATE ORGANIC.THERE HAVE BEEN ONLY FIVE (5) FAILURES IDENTIFIED IN THE SUBJECT VEHICLES AFTER MORE THAN 10 YEARS OF EXPOSURE.BASED ON THE LOW FAILURE RATE AND THE AGE OF THE VEHICLES, THERE IS NO EVIDENCE OF A SAFETY DEFECT TREND IN THE SUBJECT VEHICLES. THIS RECALL QUERY IS CLOSED.

STRUCTURE:FRAME AND MEMBERS
PE96002ClosedPreliminary Evaluation

FRONT BRAKE HOSE FAILURE

Opened Jan 5, 1996
Closed Apr 16, 1996

There is no summary currently available

SERVICE BRAKES, HYDRAULIC
PE94070ClosedPreliminary Evaluation

TRNSAXL OIL HOSE SEPARATES

Opened Sep 15, 1994
Closed Jan 18, 1995

There is no summary currently available

POWER TRAIN
EA92035ClosedEngineering Analysis

APV FUEL LINE FIRES

Opened Oct 30, 1992
Closed Nov 30, 1993

There is no summary currently available

VEHICLE SPEED CONTROL:LINKAGES
DP92012ClosedDefect Petition

APV FIRES

Opened Jun 9, 1992
Closed Jun 25, 1992

APV FIRES

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
PE92052ClosedPreliminary Evaluation

APV FUEL LINE FIRES

Opened Jun 4, 1992
Closed Oct 30, 1992

There is no summary currently available

VEHICLE SPEED CONTROL:LINKAGES

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .