Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 61 NHTSA owner-reported complaints for the 1996 Pontiac Trans Sport. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 61 · page 1 of 3
1996 PONTIAC TRANS SPORT, MOTOR SEIZED UP AND BEGAN TO SMOKE, MOTOR CAUGHT FIRE. *BF PRIOR TO THE FIRE, THE DRIVER NOTICED THE VEHICLE WAS LEAVING SOME TYPE OF FLUID BEHIND. ACCORDING TO THE POLICE REPORT, THE ENGINE WAS LEAKING OIL. (OHIO TRAFFIC CRASH REPORT # 10-0409-90)*JB UPDATED 08/05/10 *BF
1996 PONTIAC TRANSPORT VAN WITH LEAKING INTAKE MANIFOLD GASKETS. CONSUMER STATES THAT THE INTERNAL MANIFOLD LEAKED FILLING THE OIL PAN UP WITH WATER WHICH IN TURN FROZE THE MAIN BEARINGS TO THE CRANKSHAFT, CAUSING THE VEHICLE TO LOCK UP AT 50 MPH. HE SENT IN PREVIOUS LETTER ABOUT THE SAME PROBLEM ON ANOTHER VEHICLE. *KB THE CONSUMER NOTICED A SMELL OF ANTI-FREEZE, BUT COULD NOT LOCATE THE PROBLEM, BECAUSE IT WAS INTERNAL NOT EXTERNAL. *JB
WHILE CLOSING THE SIDE DOOR MY GRANDSON'S THUMB WAS CAUGHT IN IT. HE WAS SCREAMING AND THERE WAS NO EMERGENCY WAY TO STOP THE DOOR FROM CLOSING. THE DOOR HAD TO COMPLETE THE COURSE OF CLOSING BEFORE IT COULD BE OPENED TO GET HIS THUMB OUT. I THANK GOD IT WAS ONLY HIS THUMB!! *TR
COOLANT MIXING INTO ENGINE OIL DUE TO DEFECTIVE INTAKE MANIFOLD GASKET,WHY IS THERE NO RECALL ON THIS PROBLEM?*JB
DT: THE CONTACT STATED WINTER WEATHER CONDITIONS CORRODED THE CABLE THAT HELD THE SPARE TIRE ON THE VEHICLE. THE CABLE SNAPPED AND RELEASED THE SPARE TIRE IN THE MIDDLE OF THE DRIVEWAY. UPON INSPECTION BY THE CONTACT, THE CABLE SIMPLY CORRODED THEN RELEASED THE SPARE TIRE UNDER PRESSURE OF THE WEIGHT OF THE TIRE. *AK UPDATED 2/13/2006 - *NM
COMPLAINT #1- WINDSHIELD WIPERS WOULDN'T WORK IN THE RAIN. DEFECTIVE CIRCUIT BOARD HAD TO BE REPLACED. COMPLAINT # 2- TILT STEERING COLUMN CAME OFF. THE WHOLE COLUMN HAD TO BE REPLACED. COMPLAINT #3- BLACK PAINT OVER THE CAB FLAKED OFF. *NM
1996 PONTIAC TRANSPORT ACCELERATED TO 85 WHILE SET IN CRUISE CONTROL AT 65 MPH.*MR WHEN THE CONSUMER ATTEMPTED TO SLOW THE VEHICLE DOWN TO 65 MPH, IT WOULD ACCELERATE TO 85 MPH ON ITS OWN. *JB
VEHICLE STARTED EATING COOLANT, WITHIN 4 DAYS OF COOLANT LEAK HEAD GASKET HAD COMPLETE FAILURE DUMPING CONTENTS OF RADIATOR INTO OIL PAN. UPON EXAM FOUND THAT DEXTROL COOLANT HAD TURNED CORROSIVE AND EATEN THREW GASKET CAUSING FAILURE. REPLACE ALL TOP END GASKETS AND REBUILD TOP END. PRAY THAT LOWER END WILL BE OK ONCE FLUSHED COMPLETELY. HAVE KEPT OLD PARTS FOR FURTHER EXAM. *NM
THE OWNER RECEIVED A RECALL NOTICE FOR THE LOWER PINION BEARING AND POWER STEERING GEAR. THE CONSUMER TOOK THE VEHICLE IN FOR SERVICING AND THE WORK WAS COMPLETED. NOW THE VEHICLE IS PULLING TO THE RIGHT. THIS OCCURRED ONLY AFTER HAVING IT WORKED ON FOR THE ORIGINAL RECALL. NOW THE DEALERSHIP IS TELLING THE CONSUMER THAT THE DEFECT THAT IS CURRENTLY BEING EXPERIENCED IS NO FAULT OF THE WORK THAT WAS DONE FOR THE RECALL. THE DEALERSHIP IS NOT WILLING TO REPAIR THE CURRENT PROBLEM UNLESS THE OWNER PAYS OUT OF POCKET. PROVIDE FURTHER DETAILS. *JB
WINDSHIELD WIPERS EITHER QUIT OR DO NOT WORK AT TIMES, IF YOU TURN THEM TO HIGH SPEED THEN USE WASHER FLUID THEY MAY CONTINUE TO WORK. THE PROBLEM CAN NOT BE DUPLICATED BY DEALER. ONLY KNOWN REPAIR IS REPLACEMENT OF WIPER MOTOR BY DEALER, "THAT SHOULD FIX IT". DRIVER NEVER KNOWS IF WIPERS WILL WORK WHEN NEEDED. MANY SIMULAR COMPLAINTS HAVE BEEN MADE TO YOUR AGENCY! *AK
INTAKE MANIFOLD & GASKET FAILURE - OIL & COOLANT MIXING IN ENGINE COMPARTMENT - IMMINENT ENGINE FAILURE FRONT WIPER MOTOR/TRANSMISSION INTERMITENT FAILURE WHILE DRIVING - DIFFICULTY DIAGNOSING PROBLEM - MAJOR SAFETY ISSUE WHEN THE WIPERS SUDDENLY STOP/START WORKING WHILE DRIVING IN RAIN & SNOW OR SLOPPY HIGHWAY CONDITIONS COMPRESSOR CLUTCH HUB & PULLEY FAILURE
FAILURE OF THE INTAKE MANIFOLD GASKET.
AFTER THE 2ND VALVE SPRING BROKE, I WAS TOLD THAT THE VALVES WERE SEIZING UP AND A NEW ENGINE WOULD BE REQUIRED. ALL OF THIS WAS CAUSED BY THE BAD DESIGNED MANIFOLD GASKET THAT CAUSED COOLANT TO GO INTO THE OIL. AFTER SPENDING OVER $1,000 SINCE 4-29-03, I FINALLY HAD TO TRADE IN FOR ANOTHER VEHICLE. I DIDN'T HAVE BETWEEN $4,000 AND $5,000 FOR A NEW ENGINE, WHICH ON A '96 MODEL WOULD NOT HAVE BEEN WORTH IT. I COULD HAVE GOTTEN A USED ENGINE, BUT ALL OF THEM HAVE THE SAME MANIFOLD GASKET AND THIS WOULD HAVE COST APROXIMATELY $2,000. I'VE HAD NOTHING BUT PROBLEMS WITH THIS VAN. GENERAL MOTORS SHOULD HAVE TAKEN CARE OF THIS AS A RECALL, BUT I GUESS IT WAS TOO EXPENSIVE FOR THEM TOO.
INADVERTENT DRIVERS AIR BAG DEPLOYMENT CAUSING INJURIES. *MR WHILE DRIVING THE AIR BAG SUDDENLY DEPLOYED AND KNOCKED THE CONSUMER UNCONSCIOUS. THE CONSUMER HAD RUN OFF THE ROAD AND ENTERED A WOODED AREA AND STRUCK A TREE HEAD-ON. THE DRIVER COULD NOT REMEMBER ANYTHING ABOUT THE ACCIDENT. (LAWYER MICHAEL SHEPHERD ON BEHALF OF CLIENT KAREN WILSON (PER A. JIMENEZ, THIS DOCUMENT IS TO BE TREATED AS A MAILED IN VOQ) *SCC *JB
WHILE TURNING RIGHT, THE STEERING WHEEL FAILED WITH NO CONTROL. THE CONSUMER WAS ABLE TO STOP VEHICLE. THE DEALER WAS NOTIFIED. *AK THE CONSUMER STOPPED A STOP SIGN AT AN INTERSECTION WHEN THE STEERING WHEEL STARTED TO SPIN AROUND. IT WAS DISCOVERED THE INTERMEDIATE SHAFT AT THE BASE OF THE STEERING COLUMN HAD COME LOOSE. THE AIR BAG LIGHT WAS ON AND THE CLOCK SPRING HAD BROKEN. *SCC *JB
CONSUMER NOTICED WHILE USING THE WINDSHIELD WIPERS AND WITHOUT ANY INDICATION, THE WIPERS INTERMITTENTLY STOPPED WORKING. *AK *TS *JB
FRONT WINDSHIELD WIPERS STOPPED WORKING OR FAILED TO WORK . *AK
THE WINDSHIELD WIPERS FAILED TO WORK, THE CONSUMER HAD TO HIT THE CONTROL SEVERAL TIMES TO GET THEM TO WORK. *JB. THE COOLANT LIGHT ILLUMINATED, THE DEALER REPLACED THE UPPER AND LOWER INTAKE, THE FRONT PASSENGER WINDOW WENT UP AND DOWN SLOW, THE POWER SLIDING DOOR WAS INOPERATIVE, THE DEALER REPLACED THE BATTERY *PH *JB
EXCESSIVE CONSUMPTION OF COOLANT. REPAIR SHOP TOLD US COOLANT WAS BEING SUCKED INTO INTAKE MANIFOLD. REPLACED GASKET AND CONVERTED FROM ORANGE TO GREEN COOLANT. *NLM
COOLANT IN OIL DUE TO MANIFOLD INTAKE GASKET..HAD GASKET REPLACED AND IS BACK IN THE SHOP AGAIN FOR SAME PROBLEM. IN BETWEEN THESE TWO TOWINGS, I HAD TO HAVE THE VALVE SPRING REPLACED BECAUSE IT BROKE. *NLM
THE RACK AND PINION FAILED, PRIOR TO THE RECALL BEING PERFORMED. RECALL # 02 V 286 000. *JB
THE CONSUMER WAS CHARGED FOR THE REPLACEMENT OF THE STEERING RACK AND PINION, EVEN THOUGH A RECALLED WAS ISSUED. THE LOWER PINION BEARING, TIE ROD ENDS AND PRESSURE HOSES WERE REPLACED. MR *TS *JB
FAULTY INTAKE MANIFOLD GASKET ON 1996 PONTIAC TRANSPORT. *JB
THE VEHICLES SLIDING DOOR DIDN'T CLOSE PROPERLY WHICH CAUSED THE INDICATOR LIGHT ON THE INSTRUMENT PANEL TO ILLUMINATE INTERMITTENTLY. THE DEALER WAS NOTIFIED. *NLM
THE VEHICLE CONTINUED TO EXPERIENCE PROBLEMS WITH THE STEERING AFTER THE RECALL WAS PERFORMED ON THE RACK AND PINION, HOWEVER PRIOR TO THE RECALL THE OUTER TIE RODS WERE REPLACED, BUT THAT DID NOT RESOLVE THE STEERING PROBLEMS, ALSO THE FRONT ROTORS WERE RESURFACED. *TS *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .