Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 3 NHTSA owner-reported complaints for the 2005 Porsche 911. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–3 of 3
DUE TO HIGHLIGHTED PROBLEMS WITH THE COOLING SYSTEM (NAMELY THE FITTINGS POPPING OFF) ON THE 2005 PORSCHE 911 GT3 IN VARIOUS FORUMS AND WEB SITES. I HAVE DECIDED TO PERFORM PREVENTATIVE MAINTENANCE AND TO ALLEVIATE SAFETY CONCERN WITH THE COOLING SYSTEM (FITTING AND HOSES) TO WELD THE COOLANT CUPLINGS. *TR
I WAS DRIVING ON A SATURDAY NIGHT ON INTERSTATE 79 NORTHBOUND AT APPROXIMATELY MILE MARKER 3 BETWEEN MINK SHOALS AND ELKVIEW, WV. I HAD JUST PICKED UP A PIZZA AND I WAS HEADED HOME A FEW MILES FROM MY HOUSE. I WAS GOING UPHILL WHEN I HEARD A POP AND SAW A HUGE PLUME OF STEAM SHOOT OUT FROM BEHIND MY CAR. I THEN TAPPED THE BRAKES AND THE REAR RIGHT TIRE GOT A LITTLE LOOSE AS IT HAD ANTIFREEZE COOLANT SPRAYING DIRECTLY ON IT. I MANAGED TO GET MY CAR HOME AS IT WAS QUICKLY STARTING TO GET HOT AND CLOSE TO OVERHEATING AS THERE WAS NO COOLANT LEFT. I GOOGLED "PORSCHE 911 COOLANT LINE FAILURE" AND QUICKLY LEARNED THAT MY ISSUE HAD HAPPENED TO MANY OTHERS.I LEARNED THAT FROM THE FACTORY PORSCHE GLUES/EPOXIES THE COOLANT FITTINGS INTO THE ENGINE BLOCK AND OVER TIME AND MANY HEAT CYCLES LATER THE GLUE/EPOXY FAILS AND THE COOLANT SPRAYS EVERYWHERE AND MANY TIMES DIRECTLY ON THE REAR TIRES. THIS CREATES AN UNSAFE ENVIRONMENT FOR THE DRIVER AND PASSENGER AND ANYONE IN THE IMMEDIATE VICINITY. I PERFORMED A QUICK FIX ON MY CAR AND PINNED THE FITTING BACK INTO THE BLOCK. I LATER LEARNED THAT THE ENTIRE ENGINE HAD TO BE DROPPED AND EACH OF THE 6 COOLANT LINES NEEDED TO BE WELDED TOGETHER TO TRULY PREVENT THIS FROM BEING A HAZARD. I PAID SEVERAL THOUSAND DOLLARS TO HAVE THE ENGINE DROPPED AND FIXED LIKE PORSCHE SHOULD HAVE DONE FROM THE FACTORY. THEY SHOULD HAVE ADDRESSED THE ISSUE AND OFFERED TO FIX THE FAILED COOLANT LINES UNDER A RECALL BUT TO MY KNOWLEDGE THIS HAS NOT BEEN DONE. PORSCHE CLAIMS NO FAULT OF THEIRS. MANY PERFORMANCE DRIVING EVENTS HAVE IDENTIFIED THE ISSUE AND WON'T LET YOU DRIVE YOUR CAR AT THEIR EVENT UNLESS THE ISSUE HAS BEEN PROPERLY ADDRESSED BY DROPPING THE ENGINE. WHEN YOU SPEND THAT MUCH MONEY ON A CAR OR ANY MONEY FOR THAT MANNER YOU EXPECT THE CAR MANUFACTURE TO DO EVERYTHING POSSIBLE TO KEEP YOUR SAFETY AND THE SAFETY OF OTHERS A HIGH PRIORITY. *TR
COOLANT PIPE FAILURE AT GLUED FITTINGS WITHIN ENGINE. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .