2011 Porsche Cayenne Turbo Problems

The contact owns a 2011 Porsche Cayenne Turbo. The contact stated that while starting the vehicle, the vehicle shuddered abnormally. Additionally, while driving, the vehicle experienced a loss of power steering assist, and the brake pedal was firm while depressed. The vehicle failed to come to a complete stop. The traction control, check engine, oil pressure, and several other unknown warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed that the passenger's side camshaft controller and bolts had failed. The dealer determined that both the driver's and passenger's side camshaft controllers and bolts needed to be replaced. The dealer replaced the camshaft adjusters and bolts under NHTSA Campaign Number: 17V368000 (Engine) associated with the VIN; however, the contact was not satisfied with the remedy for the recall. The contact stated that the dealer failed to recover all the failed bolts inside the engine. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 131,046.

2011 PORSCHE CAYENNE TURBO. CONSUMER WRITES IN REGARDS TO CAMSHAFT CONTROLLER SAFETY RECALL. CONSUMER HAD REPAIR DONE PRIOR TO RECALL AND IS SEEKING REIMBURSEMENT. *LD *JS

AT TIME OF PURCHASE, 11/5/18 MY WIFE GLENDA AND I TOOK IT INTO PORSCHE WOODLAND HILLS WHO PERFORMED CAMPAIGN AHO8 OR VERIFIED THAT THE WORK HAD BEEN DONE - REPLACING THE FAULTY FASTENING SCREWS IN CAMSHAFT CONTROLLER. ATTACHED INVOICE #C56285 DATED 11/5/18 SAYS "RECALL COMPLETED - NO CORRECTION NEEDED" UNDER CONCERN #24 (MIDDLE OF PAGE).

TRANSFER CASE FAILURE. THERE IS AN ACKNOWLEDGMENT BY PORSCHE OF AN ASSOCIATED DEFECT OF THE TRANSFER CASE DESIGN AND A RELATED WORKSHOP BULLETIN (WB) WHEN REPLACING THE TRANSFER CASE. PORSCHE MECHANICS ARE INSTRUCTED TO REPLACE A "VENT HOSE" FOR THE TRANSFER CASE. THIS NEWLY REVISED DESIGN PART NUMBER FOR THE REVISED VENT IS 958-301-047-10. THE REASON: THE ORIGINAL DESIGN FOR CAYENNE 958 PORSCHE TRANSFER CASES HAD THE HOSE ENDING ON THE LOWER (CLOSER TO THE GROUND) SIDE OF THE TRANSFER CASE. THE NEW HOSE ENDS ON THE UPPER (FURTHER FROM THE GROUND) SIDE OF THE TRANSFER CASE. PORSCHE DETERMINED THAT MOISTURE WAS GETTING SUCKED INTO THE CASES AND CAUSING FLUID CONTAMINATION. SINCE THE TRANSFER CASE USES A "MULTIPLATE WET CLUTCH", MOISTURE COULD PREMATURELY CORRODE OR ALLOW RUST TO FORM, WHICH COULD CAUSE THE CLUTCH TO BIND AND WORK ERRATICALLY. THESE ARE SYMPTOMS DESCRIBED BY MULTIPLE OWNERS OF 958 CAYENNES DISCUSSED IN PORSCHE FORUMS (E.G. RENNTECH.ORG, RENNSLIST.COM, ETC.). THIS REVISED VENT DEVELOPED BY PORSCHE TO REPLACE THE EXISTING DESIGN, SHOULD BE COVERED BY PORSCHE. MOREOVER, OWNERS OF 958 CAYENNES WHO HAVE EXPERIENCED FAILURES OF THE TRANSFER CASE AND SUBSEQUENT REPLACEMENT OF THE TRANSFER CASE AND THE NEWLY DESIGNED HOSE, SHOULD BE REIMBURSED FOR THE FULL COST OF THE REPLACEMENT TRANSFER CASE AND THE HOSE. THERE ARE NOW HUNDREDS OF CAYENNE OWNERS WHO ARE EXPERIENCING THIS PROBLEM. MOREOVER, THE MAINTENANCE SCHEDULE DOES NOT CALL FOR ANY PREVENTATIVE FLUID CHANGES OF THE TRANSMISSION OIL. THIS SHOULD BE REVISED AND RECOMMENDED SERVICING SHOULD BE PRESCRIBED (E.G., EVERY 10,000 MILES). THE FAILURE OF THE TRANSFER CASE COULD CAUSE VEHICLES TO LURCH OR REACT IN AN ERRATIC OR UNSAFE CAPACITY ACROSS THE SPECTRUM OF OPERATION, INCLUDING HIGHWAY SPEED DRIVING. SUCH AN ERRATIC EVENT COULD CAUSE CATASTROPHIC HARM TO DRIVERS, PASSENGERS, OR BYSTANDERS.