2005 Porsche Cayenne Owner Complaints

The contact owns a 2005 Porsche Cayenne. The contact stated that fuel was leaking from the vehicle. There was an abnormal fuel odor. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline). The contact replaced the fuel filter and repaired the vehicle. The contact called the local dealer and was informed that parts were on back order. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 157,290.

NHTSA ID

11695787

Incident

Oct 15, 2025

Mileage

157,290 mi

headlamp wiring and turn signal failures. Big hazard!! Why is in the headlight assembly including the headlight wire harness is corroding due to the heat this is a common issue that I see that’s online. Everyone is having the same issue with the same type of vehicle this needs attention immediately and recalled before the media gets wind of this. The group chats that I am in is starting to do a petition because this was reported to you guys numerous amount of times as I can see in our group chats so please call this recall because it is a safety hazard to the roads. Headlights are going off as we’re driving due to that Issue please give me a email at [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11603601

Incident

Jul 9, 2024

The transmission has quite a bit of slop or play when placing it in park. I do not believe it could be parked safely in a residential driveway. Tranny knocks a little in low gears.

NHTSA ID

11601645

Incident

Sep 13, 2023

We purchased the 2005 Porsche Cayenne from my brother-in-law in August of 2022. He had owned the vehicle for at least a year before I purchased it from him. Shortly after the purchase, I noticed the engine light came on. On 09/12/22 a strong smell of fuel was emitting from the vehicle in a Walmart parking lot in Denton, Texas at approximately 1030pm. I noticed a large puddle of gasoline on the ground under the vehicle and it was steady stream of fuel while the vehicle was running. The vehicle was completely unsafe to drive for fear of ignition and fire. Due to the time and location, I had the vehicle towed to my mechanic approximately 3 miles away for diagnosis and/or repair. The closest Porsche dealership was approximately 25 miles away and the tow bill would have been excessive. Mechanic identified the problem as a cracked fuel filter flange/housing that sat on top of the fuel pump. The cracked fuel housing was replaced and the total for parts and labor was $462.48. No leaking fuel since repair. A few weeks later my brother-in -law contacted me and advised he had just received a recall (OCTOBER 2022) in the mail from Porsche for the exact part I had repaired (17V-576 / AH10). He mailed me the recall and I contacted Porsche for a reimbursement. They stated they only refund for repairs done at a Porsche dealership. I believe Porsche should cover the repair cost for their faulty equipment even after the recall was received. A Porsche Service Center would charge Porsche Corporate much more for this repair than what I paid. Please assist me in getting a refund for my expense of ($462.48) for the repair of Porsche's recall. Thanks [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11497792

Incident

Sep 12, 2022

The contact owns a 2005 Porsche Cayenne. The contact stated that while refueling the vehicle with the engine running, the vehicle shut off. The vehicle hesitated while restarting. The contact detected fuel leaking from the vehicle. The check engine and oil light warning lights were illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.

NHTSA ID

11491876

Incident

Jan 1, 2021

The contact owns a 2005 Porsche Cayenne. The contact received notification of the NHTSA Campaign Number: 17V576000 (Fuel System, Gasoline) however, the contact stated that while driving, he smelled a fuel odor throughout the vehicle. The contact stated that he started to feel dizzy and pulled the vehicle off the roadway. The contact then stated that upon inspecting the vehicle, he noticed that fuel had leaked under the hood of the vehicle onto the ground. The vehicle was driven to the destination. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was informed to have the vehicle towed to the dealer. The failure mileage was approximately 150,000.

NHTSA ID

11488239

Incident

Oct 3, 2022

Mileage

150,000 mi

PORSCHE RECALLED THIS FUEL PUMP (17V-576) AFTER I REPLACED FOR THE SAME REASON IT WAS RECALLED. I'VE CONTACTED PORSCHE SEVERAL TIMES AND THEY STILL HAVE NOT ADDRESSED REPLACING THE FUEL PUMP FILTER FLANGE. IT'S BEEN MORE THAN 2 YEARS NOW? WHAT CAN I DO?

NHTSA ID

11302892

Incident

Oct 14, 2017

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT ALL FOUR DOOR LATCHES FAILED TO OPEN FROM OUTSIDE AND INSIDE THE VEHICLE. THE CONTACT CALLED PORSCHE ORLANDO (9590 US-17, MAITLAND, FL 32751, (407) 680-0785) AND WAS INFORMED THAT THERE WOULD BE A FEE TO REPAIR EACH DOOR. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: 5557958. THE APPROXIMATE FAILURE MILEAGE WAS 162,160.

NHTSA ID

11267395

Incident

Sep 9, 2019

Mileage

162,160 mi

GOOGLE: CAYENNE WET FLOOR. ALL CAYENNE HAVE ISSUE WITH POOR WATER DRAINAGE SYSTEM ACCORDING TO THE WEBSITES. MY CAR WAS DRIVING FINE BEFORE I PARKED IT, THEN WHEN I TRY TO START IT, I GOT AN ERROR ON THE INFO DISPLAY IN RED: IGNITION LOCK FAULT, ABS BRAKE PROPORTIONING. NO CRANK FROM THE BATTERY, TRANSMISSION LOCKED IN PARK. SO I GOOGLED IT AND FOUND MANY OWNERS FROM AROUND THE WORLD REPORTING THIS ISSUE. THE DRAINAGE UNDER THE WINDSHIELD CAN GET BLOCKED EASILY WITH DEBRIS, AND CAUSE WATER TO OVERFLOW INSIDE THE CABIN AND OR ELECTRICAL MODULES LOCATED IN THE WINDSHIELD COWL AREA. ON THE DRIVER SIDE AS PER VIDEO, I REMOVED THE RUBBER CARPET AND FORCED LIFTED THE PERMANENT CARPET, AND FOUND POOL OF WATER UNDERNEATH, ON THE METAL FLOOR WAS A BUNCH OF WIRES CONNECTING TO THE CAR BATTERY UNDER THE DRIVER SEAT WERE ALL UNDER WATER. I STARTED EMPTYING BUT MORE WATER KEPT COMING, FOAMS, RUBBERS WERE ALL SOAKED. ACCORDING TO THE FORUMS AFTER REMOVING ALL WATER, I NEEDED TO LOCATE 3 SET OF WIRES AMONGST THE BUNCH, THESE 3 ARE JOINED BY TWISTING AND WRAPPED WITH ELECTRICAL TAPE/GAUGE FROM THE FACTORY. THESE WIRES SINCE EXPOSED ARE SUSCEPTIBLE TO CORROSION. 1 SET OF WIRE COMPLETELY SNAPPED, APPARENTLY 1 WIRE IS FOR ABS BRAKE, AND THE OTHER IS FOR IGNITION KEY LOCK THAT RENDERS THE CAR IMMOBILIZED. I FOLLOWED THE VIDEO DESCRIBING THE STEPS TO FIX THIS ISSUE MYSELF, AND BIG BOLD LETTERS ON VIDEOS TO DO NOT BRING THE CAR TO THE DEALER AS THEY WILL CHARGE THOUSANDS, IF MODULES NEED REPLACING, RUST AN OWNER RECORDED A VIDEO ONLINE OF HIS CAYENNE DASH STOP WORKING, ALL LIGHTS BLINKING WHILE THE CAR WAS IN MOTION. LUCKILY MINE MALFUNCTIONED WHILE PARKED AT HOME, NOT DRIVING WITH MY FAMILY. I HAVE 2 CAYENNE, A 2005 AND 2008 THAT MY WIFE DRIVES. I NEED TO FOLLOW FORUM INSTRUCTION IN CLEANING THE DRAINAGE AND REMOVING THE GROMMET THAT CAN BE BLOCKED AND CAUSE WATER NOT TO DRAIN.

NHTSA ID

11210362

Incident

May 25, 2019

Mileage

168,000 mi

I CALLED 3 TIMES TO HAVE MY RECALL REMEDIED AND PORSCHE DENIED ME EACH TIME BUT YOUR WEBSITE SAYS I HAVE AN OPEN RECALL, THEY TOLD ME IT IS BECAUSE THE RECALL WASN'T THAT IMPORTANT

NHTSA ID

11174386

Incident

Feb 3, 2019

Mileage

45,000 mi

I NOTICED A RECALL ON YOUR SITE FOR MY VIN # BUT I HAVE NOT BEEN REACHED BY PORSCHE TO FIX. I'M UNSURE IF THIS HAS BEEN THE CULPRIT OF MY CHECK ENGINE LIGHT AND AIRBAG LIGHT BEING ILLUMINATED ON MY DASH.

NHTSA ID

11157001

Incident

Dec 3, 2018

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, THE AIR BAG DEPLOYED WITHOUT WARNING OR A CRASH. THE PASSENGER SIDE WINDOW SHATTERED. THERE WERE NO INJURIES. THE CONTACT CALLED PORSCHE OF TAMPA AT 813-936-2222 (LOCATED AT 103 E FOWLER AVE, TAMPA, FL 33612) AND WAS INFORMED TO CALL THE MANUFACTURER. THE MANUFACTURER WAS CALLED AND THE CONTACT WAS REQUESTED TO PROVIDE PROOF OF OWNERSHIP AND INSURANCE. THE INFORMATION WAS PROVIDED TO THE MANUFACTURER AND AN EMAIL WAS SENT TO THE CONTACT, REQUESTING A PICTURE OF THE VEHICLE. THE CONTACT EMAILED THE PICTURE AND DID NOT RECEIVE A RESPONSE. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT A CARFAX REPORT REVEALED THAT THE VEHICLE WAS PREVIOUSLY INVOLVED IN A CRASH. THE MANUFACTURER DECLINED FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 150,482.

NHTSA ID

11153097

Incident

Oct 15, 2018

Mileage

150,482 mi

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN ABNORMAL CLANKING NOISE UNDERNEATH THE VEHICLE. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVESHAFT WAS DETACHED AND SPLIT IN HALF AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. *DT DRIVESHAFT FAILED AND REPLACED TWICE 11/05/12 AT 69,400 MILES AND 9/3/18 AT 109,800 MILES. UPDATED 10/5/18*JB

NHTSA ID

11124415

Incident

Sep 3, 2018

Mileage

110,000 mi

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN NOVEMBER OF 2017. THE CONTACT SPOKE WITH NEWPORT BEACH PORSCHE (445 EAST PACIFIC COAST HIGHWAY, NEWPORT BEACH, CA 92600, 877-891-0824) AND WAS INFORMED THAT THEY WERE NOT AWARE OF THE RECALL AND DID NOT HAVE PARTS. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS PROVIDED WITH CLAIM NUMBER: 01020600. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11111666

Incident

Nov 1, 2013

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PORSCHE OF HILTON HEAD, 107 DRIVERS WAY, HARDEEVILLE, SC 29927, (843) 208-3300) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11099994

Incident

Jun 5, 2018

2005 PORSCHE CAYENNE. CONSUMER WRITES IN REGARDS TO FILTER FLANGE OF FUEL PUMP. *LD THE CONSUMER STATED THE VEHICLE FAILED WITH THE SAME DEFECT AS DESCRIBED IN THE RECALL, PRIOR TO RECALL BEING IN EFFECT. THE MANUFACTURER WAS NOTIFIED AND HAD NOT RESPONDED TO THE CONSUMER'S REQUEST FOR REIMBURSEMENT. *JS

NHTSA ID

11096251

Incident

Jan 1, 2009

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT SMELLED A FUEL ODOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVER'S SIDE FUEL TANK FLANGE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. ONE MONTH AND THREE WEEKS LATER, THE CONTACT RECEIVED A RECALL NOTIFICATION IN THE MAIL FOR NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE). THE RECALL WAS FOR THE SAME FAILURE THAT THE CONTACT HAD GOTTEN REPAIRED PRIOR TO RECEIVING THE RECALL NOTICE. THE MANUFACTURER WAS INFORMED THAT THE FAILURE HAD BEEN REPAIRED PRIOR TO HAVING ANY KNOWLEDGE OF THE RECALL. THE MANUFACTURER STATED THAT THEY USUALLY USE A THIRD PARTY FOR REIMBURSEMENT; HOWEVER, THAT WAS NOT THE CASE FOR THIS RECALL SO REIMBURSEMENT WAS NOT POSSIBLE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 59,626. *TT UPDATED 9/20/18*JB

NHTSA ID

11093250

Incident

Sep 15, 2017

Mileage

59,626 mi

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (STEVINSON IMPORTS PORSCHE IN LITTLETON, COLORADO) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11075222

Incident

Nov 14, 2017

I GOT THE LETTER FOR RECALL OF REPLACE FILTER OF FUEL PUMP, CALL LOCAL DEALER MANY TIME AND GOT THE ANSWER WITH OUT THE PART , THIS UNSAFE UNDER DRIVING ? KEEP CONTINUES OR STOP DRIVING ? WE HAVE 2 KIDS , PLEASE ADVIDE ..THANKS

NHTSA ID

11066432

Incident

Nov 15, 2017

I PAID FOR THIS RECALL 17V-576 AND NEVER RECEIVED MY REIMBURSEMENT FOR THIS ISSUE FROM PORSCHE. THEY OWE ME $1800.00 I WANT TO BE REIMBURSED IMMEDIATELY. I SPENT A LOT OF MONEY REPAIRING THIS VEHICLE CONSTANTLY. VERY POORLY MADE.

NHTSA ID

11056292

Incident

Oct 18, 2016

Mileage

78,000 mi

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED THAT WHEN DRIVING 90 MPH THE VEHICLE WOULD SHAKE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THE CONTACT WAS TOLD THAT THERE WAS NOT ENOUGH FUEL TRAVELING THROUGH THE FUEL LINES AND THE ACCELERATOR PEDAL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 113,000.

NHTSA ID

10505497

Incident

Oct 17, 2012

Mileage

113,000 mi

SINCE I HAVE HAD THE VEHICLE I HAVE HAD TO REPLACE THE DRIVE SHAFT 3 TIMES. PORSCHE REPLACED IT ONCE UNDER WARRANTY AND THE OTHER TWO TIMES I HAD TO PAY IN EXCESS OF $900.00 TO HAVE IT REPLACED. I HAVE BEEN TOLD BY PORSCHE THAT IT HAS A DEFIECTIVE RUBBER SEAL AND WHEN THE SEAL FAILS SO DOES HE DRIVE SHAFT. THIS IS A COMMON DEFECT AND IS KNOW BY PORSCHE AT THE DEALERS AND THE MANUFACTURER. THEY HAVE ACKNOWLEDGED THE DEFECT TO ME. MY CONCERN IS IF THE DRIVE SHAFT TOTALLY FAILS AND BREAKS, NOT JUST FLEXING AND HITTING THE FLOOR, IT COULD CAUSE AN ACCIDENT BY MAKING THE VEHICLE GO OUT OF CONTROL. *TR

NHTSA ID

10466627

Incident

Mar 15, 2005

Mileage

30,000 mi

TL* THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT WAS DRIVING 35-40 MPH WHEN THE VEHICLE LUNGED FORWARD WHILE SHIFTING HARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE VALVE BODY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 68,000 .

NHTSA ID

10439788

Incident

Nov 2, 2011

Mileage

60,000 mi

COOLANT PIPE FAILURE. *TR

NHTSA ID

10420958

Incident

Aug 21, 2011

Mileage

85,000 mi

TL*THE CONTACT OWNS A 2005 PORSCHE CAYENNE. THE CONTACT STATED WHILE DRIVING AT LOW AND HIGH SPEEDS THE VEHICLE LUNGED FORWARD. HE ALSO HEARD A LOUD NOISE IN THE ENGINE. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HIM THAT THE IGNITION COIL AND CYLINDER NUMBER 5 NEEDED TO BE REPLACED. THE IGNITION COIL WAS REPAIRED; HOWEVER, IMMEDIATELY AFTER LEAVING THE DEALER THE FAILURE RECURRED. THE DEALER WAS CONTACTED AND ADVISED HIM TO BRING THE VEHICLE BACK. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10402881

Incident

May 22, 2011

Mileage

66,000 mi