2020 RAM 4500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 RAM 4500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system250.0%
- Visibility250.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact owns a 2020 Ram 4500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) and 22V035000 (Visibility) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Truck turned off while driving and died. Would not turn back on. Was towing a 40ft gooseneck trailer with a load on it. Truck was stopped blocking multiple lanes of traffic. Truck and trailer had to be towed to nearest dealership where they found the CP4 fuel pump had failed and the entire fuel system needed to be replaced.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
The contact owns a 2020 Ram 4500. The contact stated that while driving approximately 65 MPH during a rainstorm, the windshield wipers were activated; however, the windshield wipers failed to engage as needed. The contact attempted to activate the windshield wipers several times, but the windshield wipers stopped operating. The contact pulled over and waited out the rainstorm. The rain had not stopped, and the contact drove to a filling station, checked the electrical fuse for the windshield wipers, and then replaced the fuse. The contact stated that the wipers started to function, but only at the highest speed. The contact attempted to slow the windshield wipers, but when the wiper speed control was set to a slower speed, the wiper blades stopped working in the middle of the windshield. The contact drove to the residence with the windshield wipers functioning at high speed. The contact had taken the vehicle to a local dealer but had not yet received a diagnostic report. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact researched online and related the failure to NHTSA Campaign Number: 22V035000 (Visibility); however, the VIN was not included. The failure mileage was approximately 50,000.
The contact owns a 2020 Ram 4500. The contact received notification of NHTSA Campaign Number: 21V880000 (Fuel System, Diesel) and 22V035000 (Visibility) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .