2017 RAM Promaster Problems

COMPONENT FAILED: Left transmission mount bracket and its fasteners on a 2017 RAM ProMaster with 3.6L V6 Pentastar (sales code ERB) and 62TE 6-speed automatic (sales code DG2). At least one bracket-to-transaxle bolt sheared. The bracket separated from the transmission, the powertrain dropped on the driver side, the left front CV axle pulled out of the transaxle, and transmission fluid loss occurred. The transmission case casting also appears cracked at the bracket mounting boss. All failed components are preserved and available for inspection. SAFETY RISK: Failure occurred during LOW-SPEED MANEUVERING. Had it occurred at highway speed, the dropped powertrain and separated front drive axle could have caused loss of vehicle control, sudden disabling of the vehicle in traffic, and roadway debris from dragging components. Industry-published cases describe identical failures at 40+ mph (Certified Transmission, May 2019). Multiple owner reports of the same failure exist for 2015-2021 ProMasters. CONFIRMED BY: Failure confirmed by visual inspection at an independent service facility. The failure mode matches FCA Service Bulletin 23-022-19 (8/27/2019), which warns the bracket fasteners are torque-to-yield, single-stage, one-time use, and that reuse can lead to bracket bolt failure. The TSB is classified Information Only — no recall has been issued. INSPECTED BY: Inspected by the owner and an independent repair technician. Not yet inspected by the manufacturer, police, or insurance. The vehicle had recent service in the transmission area; whether the one-time-use fasteners specified by the TSB were replaced during that service is under investigation. WARNING SIGNS: None. No warning lamps, messages, or symptoms preceded the failure. Given the documented failure mode, manufacturer service bulletin, and multiple owner reports of identical failures across model years, a formal investigation into a potential safety recall is requested.

The contact owns a 2017 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 19V818000 (Equipment, Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Odometer Fraud. The contact purchased a 2017 Ram Promaster 1500. The vehicle was purchased on February 16, 2024. The contact stated that at the time of purchase, the mileage was 84,000. The vehicle was taken to Valvoline, where the odometer was reported in 2018 February 2023 at 346,000. The contact purchased a Carfax report, which indicated that the mileage was 346,544 in January 2023. In addition, the dealer was made aware of the discrepancy, and the contact was informed that the vehicle would be collected, and the sale would be voided; however, the down payment would not be returned.

The windshield cowl on this vehicle is poorly designed, allowing water intrusion from multiple points. This is not a minor leak but a severe design flaw that creates immediate and dangerous safety hazards while driving, particularly at highway speeds. The most critical issue is water pouring directly onto the serpentine belt and pulley system. While driving at highway speeds in heavy rain, I lost power steering after water intrusion caused the belt to slip. This sudden loss of steering assist made the vehicle extremely difficult to control, especially in traffic and during turns. Another major safety risk is water intrusion onto the engine fuse box. While driving at highway speeds, water poured into the fuse box, causing electrical shorting. This led to severe overheating that burned my windshield wiper wiring, making the wipers inoperable and drastically reducing visibility. Surrounding wires also melted, posing a significant fire hazard. The sudden electrical failure and loss of visibility created an extremely dangerous situation. Additionally, water pooling on the transmission can drain into the breather hole, allowing significant water intrusion into the transmission fluid. This can cause erratic shifting, transmission failure, or complete power loss. At highway speeds, this can lead to sudden deceleration or loss of acceleration, putting drivers and others at serious risk. This issue has been experienced by multiple owners and confirmed by independent service centers. It is not a DIY repair—the defective cowl design allows excessive water ingress. There are no warning lights or messages before failure, only sudden and dangerous symptoms once water intrudes. This is a major safety concern, particularly at highway speeds, where sudden power steering loss, electrical failure, or transmission issues can lead to catastrophic consequences. Immediate investigation and corrective action are necessary to prevent accidents, injuries, or fatalities.

I am the original owner of a 2017 Dodge ProMaster made by Chrysler. My vehicle is currently at a dealership waiting for a complete transmission. I had to have it towed there as this issue happened while I was driving. Luckily, I was not far from home. The van is no longer under warranty at 5 years or100,000 miles. I purchased it new in May 2018. It has only 37000 miles on the odometer. There was a recall unrelated to this problem and fixed. In the beginning I had to Contact Chrysler Customer Service per my dealer who gave me their Customer Care number. I was given a case number by a lower Chrysler representative, who then had me talk to her supervisor. This representative said that there was no forwarding phone contact number for their complaint department and she gave me an address with a US mail PO Box for Chrysler in Auburn Hills, MI. No transmission should go out at 37,000 miles. My dealer is charging me $9000 USD for the transmission repair! A review of social media (Facebook) by various ProMaster owners has lead me to contact you. Groups on Facebook such as ProMaster Owners and Roadtrek ProMaster Class B RV owners have complained about transmissions going out. From what I understand, Chrysler has recalled vehicles from 2019 model years up through maybe 2023, for transmission issues. Why the 2018 model year was not included is beyond me. It is also my understanding that Chrysler is now building a completely new transmission for vehicles built since the current model year. Previous owners like me will have to settle fro re-manufactured transmissions from Chrysler. I am sure the NHTSB has been contacted by people like me. There are hundreds of us with transmission issues which can be considered driving safety issues.

Was not notified that my Ram Promaster 2017 needed two recalls when purchasing it from an official Ram dealership in 2020 with 35k miles on it. Now, at 90k miles I'm having to replace a radiator and cables that failed as a result of the coolant fan being replaced. Took it to two separate shops (first shop couldn't lift it) which both confirmed that my radiator experienced failure and caused electrical faults including blowing a 60amp fuse because this part was not replaced. I never was notified by Ram over the phone regarding this issue or from the dealership I purchased it from. Now, I'm having to pay a lot out of pocket to repair these parts (because I can't get my vehicle into any Ram dealership in the area for over a month) and having a third party, high quality mechanic do the repairs instead. I had to also pay to have the vehicle towed to the shop at my own expense as the vehicle had the check engine light on and was deemed by the first mechanic to not be safe to drive. I will upload files of the repair costs once the repairs are complete. $315 tow, $300 in diagnosing fees that won't be covered, and $1600 out of pocket for repairs is what I'm looking at. If I didn't have a 3rd party extended warranty, it would cost me close to $5k for repairs.

We purchased 4 of these Dodge promasters about 4 years ago. During the first year we were replacing headlights about every 2 months. Dodge told us that we needed to use their "heavy duty" bulbs. These bulbs seem to last about 1 year. They have a 2 year warranty on original purchase, so after 2 years we have to pay again. This last time the bulb blew it also melted the housing the bulbs sits in. We were required to replace the assembly and the bulbs. I believe Dodge has a voltage issue causing premature bulb failure and now creating a fire hazard. Headlights should not burn out in a year!

THE HEADLAMPS HAVE BEEN REPLACED MULTIPLE TIMES, WAY MORE THAN THEY SHOULD NEED. WE REPLACED THE DRIVERS SIDE LOW BEAM IN DECEMBER 2019, APRIL 2020 AND NOW IT IS IT OUT AGAIN - NOVEMBER 2020. IN ADDITION, THERE ARE NO WARNING LIGHTS TO LET THE DRIVER KNOW THE LOW BEAM LIGHT IS OUT. OUR VEHICLE ONLY HAS 44800 MILES ON IT. PLEASE INVESTIGATE AS HEAD LANPS ARE EXPENSIVE.

Went to use the brakes and they would not work. Had to swerve into a ditch to stop. ABS and Traction issue.

parking brake did not fully release (with no apparent signs). drove 20 miles, brake warning lights went on about 18 miles in to the drive. Pulled up to gas pump with rear wheels (unknowingly) glowing red. $6000 damage incurred, could have easily been an explosion at the pumps. Dealer purchased extended warrantee says nothing that fails due to "rust" is covered. Manufacturer has changed the design of the failed part but takes no responsibility, or issued advisory statements or recall. I purchased this vehicle brand new, am meticulous on upkeep and keeping it clean. All scheduled maintenance has been with the dealer. There were 3 other Promasters in the dealer lot who had the same issues.

The contact owns a 2017 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 19V818000 (Equipment, Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owned a 2017 Ram 2500. The contact stated that after parking the vehicle in the parking lot of a residential building and turning the engine off, approximately 36 hours later the contact was alerted by the property manager that the vehicle was on fire. The fire department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A fire report was taken at the scene and the vehicle was towed to a local holding yard. The fire department indicated that the fire originated in the center dashboard of the vehicle. The exact cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact referred to the NHTSA campaign number 19V818000 (Equipment, Engine, Engine Cooling) and indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 85,000.

The contact owned a 2017 Ram Promaster 3500. The contact stated that after parking the vehicle on the side of his house, he received an alert from a sensor camera attached to his home. When the contact checked the alert, he saw that the vehicle had caught fire. The contact immediately called the fire department and they were able to extinguish the fire once they arrived. No injuries were reported. The contact sustained property damage side of his garage and the siding of the garage had become warped due to the fire. The vehicle had yet to be removed from the property and had been deemed a total loss. The contact posted pictures of his damaged vehicle to an online forum and the manufacturer reached out to him for assistance. The contact was asked if he would like a team to come to his home to investigate the cause of the failure; the contact had yet to make arraignments for the finding. The contact stated that the rear passenger side of the trailer; however, the cause of the failure had yet to be determined. The failure mileage was approximately 70,000.

TL* THE CONTACT OWNS A 2017 RAM PROMASTER 1500. THE CONTACT STATED THAT THE DRIVER'S DOOR HINGE WAS DETACHED AND THE REAR DOOR LATCH WAS FRACTURED AND FAILED TO OPEN OR CLOSE. IN ADDITION, THE PASSENGER SIDE SLIDING DOOR WAS FRACTURED. FURTHERMORE, WHILE DRIVING, THE DRIVER'S SIDE HEADLIGHT BECAME INOPERABLE WITHOUT WARNING AND A "LIGHT OUT" MESSAGE WAS DISPLAYED. THE VEHICLE WAS TAKEN TO FERMAN CHRYSLER JEEP DODGE RAM TAMPA (24314 FL-54, LUTZ, FL 33559, (813) 929-2400) WHERE IT WAS DIAGNOSED THAT THE DOOR'S A FRAME WAS DETACHED FROM THE HINGE AND THE HEADLIGHTS WERE OUT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 59674601. THE CONTACT WAS REFERRED TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS 1,000.

The windshield cowl on this vehicle is poorly designed, allowing water intrusion from multiple points. This is not a minor leak but a severe design flaw that creates immediate and dangerous safety hazards while driving, particularly at highway speeds. The most critical issue is water pouring directly onto the serpentine belt and pulley system. While driving at highway speeds in heavy rain, I lost power steering after water intrusion caused the belt to slip. This sudden loss of steering assist made the vehicle extremely difficult to control, especially in traffic and during turns. Another major safety risk is water intrusion onto the engine fuse box. While driving at highway speeds, water poured into the fuse box, causing electrical shorting. This led to severe overheating that burned my windshield wiper wiring, making the wipers inoperable and drastically reducing visibility. Surrounding wires also melted, posing a significant fire hazard. The sudden electrical failure and loss of visibility created an extremely dangerous situation. Additionally, water pooling on the transmission can drain into the breather hole, allowing significant water intrusion into the transmission fluid. This can cause erratic shifting, transmission failure, or complete power loss. At highway speeds, this can lead to sudden deceleration or loss of acceleration, putting drivers and others at serious risk. This issue has been experienced by multiple owners and confirmed by independent service centers. It is not a DIY repair—the defective cowl design allows excessive water ingress. There are no warning lights or messages before failure, only sudden and dangerous symptoms once water intrudes. This is a major safety concern, particularly at highway speeds, where sudden power steering loss, electrical failure, or transmission issues can lead to catastrophic consequences. Immediate investigation and corrective action are necessary to prevent accidents, injuries, or fatalities.

FRONT DRIVER SIDE CV AXEL FAILING. MAJOR STEERING JIGGLE AND TIRE WOBBLE ANYWHERE FROM 30-65MPH ON STRAIGHT AWAYS AND ESPECIALLY ON CORNERS. HAVE STOPPED OPERATING THE VEHICLE UNTIL PART IS REPLACEABLE, UNFORTUNATELY NATION WIDE BACKORDER HAPPENING NOW, APPARENTLY BECAUSE THIS IS HAPPENING TO LOTS OF THESE MODELS.

NHTSA SAFETY RECALL 17V-108 CAMPAIGN 144 LP HOSE! PURCHASED THE TRAVATO ON APRIL 28TH WHEN RECALL WAS ALREADY IN AFFECT THE REPAIR RECALL WAS NOT FIXED BUT THEY DELIVERED THE VEHICLE TO ME KNOWING THIS! GOT A RECALL NOTICE FROM THEM ON MAY 8TH (CERT MAIL) TELLING ME OF THE RECALL. I HAVE MADE ARRANGEMENTS FOR REPAIRS ON MAY 19TH MUST DRIVE IT TO TAMPA FL FROM JACKSONVILLE FL AT MY TIME NO EXPENSE . WILL IT BE SAFE TO DRIVE AND DO I HAVE ANY GROUNDS FOR COMPENSATION IN THIS MATTER! LAZY DAY SERVICE MANAGER SAID THEY DID NOT HAVE TIME TO FIX IT BEFORE IT WAS DELIVERED TO ME? THANK YOU FOR LISTING! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY 2017 DODGE RAM PROMASTER'S ACCELERATOR STUCK WHEN MY VEHICLE WAS PLACED IN REVERSE CAUSING THE VEHICLE TO ACCELERATOR AT FULL THROTTLE AND HIT A STEEL GUARD POLE CAUSE MAJOR DAMAGE TO THE REAR END. WHEN IT WAS PLACED IN DRIVE TO MOVE FORWARD OFF THE GUARD POLE IT ACCELERATED AT FULL THROTTLE AGAIN CRASHING INTO A STEEL FENCE AND GATE POLE CAUSING MAJOR DAMAGE TO THE FRONT OF VEHICLE. THE VEHICLE HAS LESS THAN 4000 MILES. WE WERE NOT TURNING. THE MOVEMENT WAS STRAIT FORWARD AND BACKWARD IN A STRAIT LINE MOTION. FORTUNATELY WE WERE IN A PARKING LOT AT OUR OFFICE WHEN THIS HAPPENED. THE VEHICLE HAS NOT BEEN REPAIRED AND IS STILL IN THE DEFECTIVE CONDITION BECAUSE AS OF YET WE HAVE NOT FILED AN INSURANCE CLAIM. THIS OCCURED AT APPROXIMATELY 4:30 P.M. ON 2/17/17. THE ACCIDENT WAS ALSO CAUGHT ON VIDEO.

NHTSA SAFETY RECALL 17V-108 CAMPAIGN 144 LP HOSE! PURCHASED THE TRAVATO ON APRIL 28TH WHEN RECALL WAS ALREADY IN AFFECT THE REPAIR RECALL WAS NOT FIXED BUT THEY DELIVERED THE VEHICLE TO ME KNOWING THIS! GOT A RECALL NOTICE FROM THEM ON MAY 8TH (CERT MAIL) TELLING ME OF THE RECALL. I HAVE MADE ARRANGEMENTS FOR REPAIRS ON MAY 19TH MUST DRIVE IT TO TAMPA FL FROM JACKSONVILLE FL AT MY TIME NO EXPENSE . WILL IT BE SAFE TO DRIVE AND DO I HAVE ANY GROUNDS FOR COMPENSATION IN THIS MATTER! LAZY DAY SERVICE MANAGER SAID THEY DID NOT HAVE TIME TO FIX IT BEFORE IT WAS DELIVERED TO ME? THANK YOU FOR LISTING! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY 2017 DODGE RAM PROMASTER'S ACCELERATOR STUCK WHEN MY VEHICLE WAS PLACED IN REVERSE CAUSING THE VEHICLE TO ACCELERATOR AT FULL THROTTLE AND HIT A STEEL GUARD POLE CAUSE MAJOR DAMAGE TO THE REAR END. WHEN IT WAS PLACED IN DRIVE TO MOVE FORWARD OFF THE GUARD POLE IT ACCELERATED AT FULL THROTTLE AGAIN CRASHING INTO A STEEL FENCE AND GATE POLE CAUSING MAJOR DAMAGE TO THE FRONT OF VEHICLE. THE VEHICLE HAS LESS THAN 4000 MILES. WE WERE NOT TURNING. THE MOVEMENT WAS STRAIT FORWARD AND BACKWARD IN A STRAIT LINE MOTION. FORTUNATELY WE WERE IN A PARKING LOT AT OUR OFFICE WHEN THIS HAPPENED. THE VEHICLE HAS NOT BEEN REPAIRED AND IS STILL IN THE DEFECTIVE CONDITION BECAUSE AS OF YET WE HAVE NOT FILED AN INSURANCE CLAIM. THIS OCCURED AT APPROXIMATELY 4:30 P.M. ON 2/17/17. THE ACCIDENT WAS ALSO CAUGHT ON VIDEO.

The windshield cowl on this vehicle is poorly designed, allowing water intrusion from multiple points. This is not a minor leak but a severe design flaw that creates immediate and dangerous safety hazards while driving, particularly at highway speeds. The most critical issue is water pouring directly onto the serpentine belt and pulley system. While driving at highway speeds in heavy rain, I lost power steering after water intrusion caused the belt to slip. This sudden loss of steering assist made the vehicle extremely difficult to control, especially in traffic and during turns. Another major safety risk is water intrusion onto the engine fuse box. While driving at highway speeds, water poured into the fuse box, causing electrical shorting. This led to severe overheating that burned my windshield wiper wiring, making the wipers inoperable and drastically reducing visibility. Surrounding wires also melted, posing a significant fire hazard. The sudden electrical failure and loss of visibility created an extremely dangerous situation. Additionally, water pooling on the transmission can drain into the breather hole, allowing significant water intrusion into the transmission fluid. This can cause erratic shifting, transmission failure, or complete power loss. At highway speeds, this can lead to sudden deceleration or loss of acceleration, putting drivers and others at serious risk. This issue has been experienced by multiple owners and confirmed by independent service centers. It is not a DIY repair—the defective cowl design allows excessive water ingress. There are no warning lights or messages before failure, only sudden and dangerous symptoms once water intrudes. This is a major safety concern, particularly at highway speeds, where sudden power steering loss, electrical failure, or transmission issues can lead to catastrophic consequences. Immediate investigation and corrective action are necessary to prevent accidents, injuries, or fatalities.

MY PASSENGER SIDE WINDOW RANDOMLY FELL DOWN HALFWAY. AT THE TIME THE VEHICLE HAD NOT BEEN DRIVEN OR OPENED FOR 3 DAYS. WE HAPPEN TO BE OUTSIDE WHEN IT OCCURRED.

2017 RAM PROMASTER 2500. CONSUMER WRITES IN REGARD TO DEFECTIVE SEATBELT. THE CONSUMER STATED THE RECALL WAS ON BACKORDER AND NOT ABLE TO REPAIRED.

UPPER BEARING PLATES RUSTED OUT AT LOW MILEAGE,MAKING VAN UNEXPECTEDLY PULL IN WHICHEVER DIRECTION IT WAS STEERED LAST AS SUSPENSION SPRINGS DID NOT RETURN TO CENTER. COST $1500.00 TO REPAIR. MECHANIC STATED THAT DEALER HAD PLENTY OF THESE PARTS ON HAND WHICH HE FOUND SUSPICIOUS AS TRUCK IS ONLY THREE YEARS OLD, INDICATING THAT THIS IS PROBABLY A COMMON PROBLEM.

TL* THE CONTACT OWNS A 2017 RAM PROMASTER 1500. THE CONTACT STATED THAT THE DRIVER'S DOOR HINGE WAS DETACHED AND THE REAR DOOR LATCH WAS FRACTURED AND FAILED TO OPEN OR CLOSE. IN ADDITION, THE PASSENGER SIDE SLIDING DOOR WAS FRACTURED. FURTHERMORE, WHILE DRIVING, THE DRIVER'S SIDE HEADLIGHT BECAME INOPERABLE WITHOUT WARNING AND A "LIGHT OUT" MESSAGE WAS DISPLAYED. THE VEHICLE WAS TAKEN TO FERMAN CHRYSLER JEEP DODGE RAM TAMPA (24314 FL-54, LUTZ, FL 33559, (813) 929-2400) WHERE IT WAS DIAGNOSED THAT THE DOOR'S A FRAME WAS DETACHED FROM THE HINGE AND THE HEADLIGHTS WERE OUT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 59674601. THE CONTACT WAS REFERRED TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS 1,000.