2023 Rivian R1S Interior & seats Problems

The driver seat has preset settings for seat adjustments but they do not have Obstruction Detection. We have a rear facing car seat that was placed behind the drivers seat that had to be replaced (by us) as the seat auto adjusted and did not detect the back of the car seat and snapped the car seat out of its base. We contact Rivian over phone and they did not have a remedy (over a year ago, cannot recall exact date). It happened several times where we had to force stop the adjustment to prevent damage to new car seat. Eventually we decided to place the new rear facing car seat behind the passenger car seat instead. The back of the drivers seat has permanent damage from it pushing against the car seat. I did not think about filing a complaint here until I read about the recent Hyundai incident.

NHTSA ID

11727927

Incident

Nov 1, 2024

the sensitivity of the airbag sensor on the passenger seat is not functioning properly in my opinion. there are times when there is a passenger present and seated, the car is showing that the passenger airbag is off. I took the car to Rivian service center. They indicated that they could not replicate the problem and that to make sure the passengers are over 110 lbs. They also noted that with future software update, they may make it better, which indicates to me that they know there is a problem. I know for a fact that my passengers have been over 110 lbs.

NHTSA ID

11638491

Incident

Jan 25, 2025

My right front passenger seat does not detect adult occupants reliably, and therefore does not enable the airbags. My wife is approximately 105 pounds and sits in the seat in a standard upright fashion without leaning back. Her legs are not crossed and are just resting on the floor. it is rare that the vehicle detects her presence and therefore she is rarely protected by the safety restraint system in the event of an accident. I brought the vehicle into Rivian Service and they inspected and said the sensor is working properly and is designed to detect occupants roughly 105 to 110 pounds. They said there is nothing that they can do about it. Every other vehicle I currently own and have owned in the past properly detects her presence for the SRS system.

NHTSA ID

11594215

Incident

Jun 1, 2024

The passenger side airbag shows that it is turned off about 50% of the time that my wife is riding in the passenger seat. She meets the minimum weight requirement for passenger airbag deployment. If she moves around in the seat the airbag off light will go out temporarily but usually comes back on within several miles of driving. This vehicle is available for inspection. When this happens my wife or any other passenger is at risk of not having an airbag if an accident was to occur. This issues has been looked at several times by the manufacturer and I was told that the vehicle is operating as intended. No resonable solution was offered. The only solution from the manufacturer was to have the passenger move around or adjust the seat until the airbag came on. Then have the passenger stay in that position for the duration of the ride. We’ve tried this and it doesn’t work the airbag still turns off.

NHTSA ID

11586504

Incident

Jan 8, 2024

Every time my wife gets into the front passenger seat the sensor in the seat doesn’t recognize her sitting down and doesn’t active the passenger side airbag also the climate control is inactive. Rivian claims that there is a seat weight limit but my wife weighs 145 lbs. this happens all the time until my wife moves around enough to activate it. Then sometimes it turns off in the middle of a drive as if there wasn’t a passenger in that seat. This has also occurred with some heavier passengers. Rivian claims nothing wrong with the vehicle. I took delivery at the end of October and the problem still continues.

NHTSA ID

11578998

Incident

Nov 1, 2023

The system does not turn on the airbags for driver or passenger under 140 pounds. This is a safety hazard.

NHTSA ID

11568926

Incident

Jan 30, 2024

Intermittently does not register a passenger in the passenger seat (even with a seatbelt on and seat upright in a normal position) such that the airbags are turned off and climate controls are not activated. Passenger weighs more than 120 lbs.

NHTSA ID

11562227

Incident

Dec 27, 2023

A passenger of lighter weight will not trigger the passenger seat’s weight sensor, rendering the passenger side airbag disabled. The passenger must sit up perfectly straight and center their weight on the center of the seat for them to be properly detected. A service center visit claimed the seats are working as designed, but there is clearly an issue.

NHTSA ID

11561935

Incident

Oct 4, 2023

Vehicle routinely (>90% of the time) fails to detect occupancy of front passenger seat resulting in disabled airbags and other related safety systems. Our particular vehicle experiences the issue with passengers ranging from 150-425lbs resulting in a significant safety concern. Searching online indicates this is a common issue and repair requests are routinely denied with claims that it is operating correctly. Others have been told it is due to posture or seating position…I’ve never had a vehicle whose safety features were disabled due to poor posture?!

NHTSA ID

11561045

Incident

Dec 20, 2023

Passenger seat does not detect my 5'4" 110lb wife, thus preventing the airbags from activating. This is the first car we've encountered with this problem. Is Rivian accounting for the fact that the weight occupancy sensor account for the weight of the legs placed on the floor? Please let us know if there will be a recall or a software update to address this.

NHTSA ID

11560954

Incident

Jul 9, 2023

Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.

NHTSA ID

11547649

Incident

Oct 1, 2023

When the passenger seat is occupied, we intermittently get a message that the airbag is off (and the heating/ac controls for the passenger side go away). This occurred when the seat was occupied by two of my sons (one 6'1", 145 lbs and the other 5'9" and 155 lbs). We took the car in to get checked and while Rivian noticed the same issue after testing, they said diagnostics found nothing wrong. They checked to see if this was related to the Feb 2023 recall and said it is not. Additionally, we have a loaner R1S and it has the exact same issue with the passenger seat not detecting a passenger is in the seat.

NHTSA ID

11533380

Incident

Jul 11, 2023