1999 Saab 9-3 Problems

FOR MY 1999 SAAB 9-3, BASE ENGINE, I REPLACED THE DIRECT IGNITION CASSETTE, AT 128,800 MILES ON THE ODOMETER. THE PART ALONE WAS $488 AND THE TOTAL INSTALLATION COST AND PARTS (INCLUDING A HOSE AND FOUR SPARK PLUGS) WAS $760. MODEL YEARS 2000 THROUGH 2002 WERE RECALLED FOR THIS PART. *TR

TL*THE CONTACT OWNS A 1999 SAAB 9-3. WHILE DRIVING APPROXIMATELY 55 MPH IN THE SNOW, THE DRIVER'S SIDE AIR BAG SUDDENLY DEPLOYED WITHOUT AN IMPACT OR CRASH OCCURRING. THERE WERE NO INJURIES. LATER THAT DAY, THE AIR BAG INDICATOR ILLUMINATED. HER MECHANIC STATED THAT THE AIR BAGS WOULD NOT FUNCTION PROPERLY AND ENSURE MAXIMUM PROTECTION IN THE EVENT OF A CRASH. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC FOR DIAGNOSTIC TESTING AND THE WIRING WAS DETERMINED TO BE THE CAUSE OF THE FAILURE. THE MANUFACTURER WOULD NOT ASSIST BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE CURRENT MILEAGE WAS APPROXIMATELY 141,000 AND FAILURE MILEAGE WAS APPROXIMATELY 138,000.

TODAY, SHORTLY AFTER STARTING THE CAR, AN AIRBAG DEPLOYED. THE CAR WAS PARKED IN MY DRIVEWAY AND NOT IN MOTION, AND THERE WAS NO IMPACT. THE AIRBAG DEPLOYED FROM THE OUTBOARD SIDE OF THE PASSENGER SEAT. I WAS SEATED IN THE DRIVER'S SEAT. THE PASSENGER SEAT WAS UNOCCUPIED AND ITS SEAT BELT WAS UNFASTENED, HOWEVER A LAPTOP AND SOME OTHER LIGHTWEIGHT OBJECTS WERE IN THE PASSENGER SEAT.

TL* THE CONTACT OWNS A 1999 SAAB 9-3. WHILE DRIVING APPROXIMATELY 25 MPH, THE DRIVER SIDE AIR BAG ERRONEOUSLY DEPLOYED WITHOUT WARNING OR IMPACT. THE CONTACT INDICATED THAT THE VEHICLE HAD NOT CRASHED OR DRIVEN OVER A ROAD BUMP WHEN THE DEPLOYMENT OCCURRED. THE DRIVER SUSTAINED AN INJURED RIGHT ARM, SHOULDER, AND TORSO, WHICH DID NOT REQUIRE MEDICAL ATTENTION. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 154,000. *TT

CRADLE BOLT HEAD (SAAB PART NUMBER 43-45-674) WAS FOUND UNDER LEFT SIDE OF CAR. IT APPEARED TO HAVE BEEN FRACTURED. CAUSE UNKNOWN, BUT DEALER STATED IT WAS DUE TO POT HOLE. IT COULD HAVE ALSO BEEN OVER TOQURED AT INSTALLATION/SERVICE, OR DEFETIVE BOLT.

RIGHT FRONT SHOCK ABSORBER FAILED. YH

PREMATURE DIC FAILURE. CONSISTANTLY BURNS OUT SPARK PLUGS. *TR

DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING 45-50 MPH ON A SNOW COVERED HIGHWAY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DETERMINED THE RECOGNITION CASSETTE MODULE FAILED. THE DEALERSHIP WAS NOT NOTIFIED. THERE WERE NO PRIOR PROBLEMS WITH THE VEHICLE. THE CHECK ENGINE LIGHT ILLUMINATED AT THE TIME OF THE INCIDENT. UPDATED 11/3/2006 - ON 11/24/05 THE VEHICLE'S DIRECT IGNITION CASSETTE FAILED WITHOUT WARNING WHICH CAUSED THE VEHICLE TO STALL WHILE BEING DRIVEN IN THE SNOW. AFTER REPLACEMENT OF THE DIRECT IGNITION CASSETTE THE REPAIR FACILITY ALSO HAD TO REPLACE TWO OXYGEN SENSORS AND THE CATALYTIC CONVERTER. THE TECHNICIAN SAID IT WAS POSSIBLE THAT RAW FUEL DAMAGED THE CATALYTIC CONVERTER DURING THE INITIAL FAILURE OF THE DIRECT IGNITION CASSETTE. *NM

I WANTED TO ALERT YOU TO A POTENTIALLY DANGEROUS SITUATION IN THE '99 SAAB 9-3. THEY HAVE A CLIMATE CONTROL SYSTEM PROBLEM THAT CAN CAUSE THE VENTILATION SYSTEM CONTROLS TO BECOME SO STIFF THAT IT CAUSES THE KNOB TO SNAP OFF RENDERING THE SYSTEM USELESS. SAAB IS FULLY AWARE OF THIS PROBLEM AND REQUIRES THE CONSUMER TO PAY FOR THE REPAIRS THAT IN THEIR TERMS "MAY" SOLVE THE PROBLEM FOR A SHORT TIME. THESE INCLUDE REPLACING THE KNOB ($10.00), THE SHAFT ($200.00), AND THE VENTILATION CONTROL BOX ($600.00). IT APPEARS THAT SAAB CONSIDERS THE ENVIRONMENTAL CONTROLS TO BE A LUXURY NOT A NECESSARY SAFETY SYSTEM. I THINK THAT YOUR AGENCY WOULD DISAGREE WITH SAAB ASSESSMENT AND SHOULD REQUIRE A MORE PROACTIVE CORRECTIVE PLAN FROM THE VEHICLE MANUFACTURER. *LA

THE CONTROL KNOB FOR THE DEFROSTER/AIR DIRECTION HAS BROKEN 7 TIMES. THE SAAB DEALER, SAAB NASHUA NORTH SAID IT IS A KNOWN PROBLEM FOR THAT YEAR AND MODEL. SAAB HAS REFUSED TO COVER THE REPAIR NOW THAT THE WARRENTY HAS RUN OUT.*AK

DASH INFORMATION DISPLAY PIXELS BURN OUT/DISAPPEAR. WHILE ANNOYING FOR TIME AND RADIO DISPLAY, THIS COULD BE A SAFETY ISSUE AS THIS DISPLAY REPORTS TEMPERATURE OUTSIDE (IN ICY CONDITIONS) AND MECHANICAL/FUNCTIONAL PROBLEMS WITH THE CAR. IF THE DISPLAY IS ILLEGIBLE A DRIVER COULD MISINTERPRET A PROBLEM.

THE DRIVER'S SIDE SEAT SKIRT HAS BROKEN 3 TIMES. THE SECOND 2 WERE REPLACEMENTS PROVIDED UNDER WARRANTEE. THERE MUST BE A DESIGN FLAW IN THIS COMPONENT

TURNED SWITCH TO ON POSITION, VEHICLE STARTED UP AND BACKED INTO A GARAGE. THE OWNER'S MANUAL STATES WHEN STARTING ENGINE, THE CLUTCH PEDAL HAS TO BE FULLY DEPRESSED. TOOK TO DEALER AND DEALER STATED CLUTCH DOES NOT HAVE TO BE DEPRESSED TO START VEHICLE. NLM *JB

THE VEHICLE EXPERIENCED TWO FLAT TIRES ON THE PASSENGER SIDE WHICH CAUSED THE VEHICLE TO PULL TO THE RIGHT, THE CONSUMER BELIEVES THE TIRES AND RIMS WERE DEFECTIVE (MICHELIN PILOT 225/50R16). NLM

TL* THE CONTACT OWNS A 1999 SAAB 9-3. WHILE BACKING OUT OF THE DRIVEWAY AT 5 MPH, THE DRIVER SIDE SEAT AIR BAG DEPLOYED WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE DRIVER SIDE SEAT BELT FRACTURED AS A RESULT OF THE AIR BAG DEPLOYMENT. THE CONTACT SUSTAINED BURNS ON THE LEFT ARM, BUT DID NOT SEEK MEDICAL ATTENTION. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.

DRIVERS SEAT BELT STUCK IN RETRACTED POSITION. UNABLE TO USE STUCK BELT. AIRBAG LIGHT IS ON AS A RESULT OF THIS. NO SEATBELT OR AIRBAG. THIS IS A CONVERTIBLE NOT COVERED IN THE CURRENT RECALL BUT HAS THE SAME PROBLEM. *TR

THE VEHICLE EXPERIENCED TWO FLAT TIRES ON THE PASSENGER SIDE WHICH CAUSED THE VEHICLE TO PULL TO THE RIGHT, THE CONSUMER BELIEVES THE TIRES AND RIMS WERE DEFECTIVE (MICHELIN PILOT 225/50R16). NLM

RIGHT FRONT SHOCK ABSORBER FAILED. YH

ENABLED DRIVER SIDE SEAT HEATER FOR FIRST TIME SINCE LAST WINTER/SPRING. WHILE DRIVING, LEFT SIDE OF MY LOWER BODY STARTED BURNING, AND I SMELLED SMOKE. PARKED CAR. DIME SIZED HOLE WITH SMOLDERING EDGES WAS PRESENT ON MY DRIVERS SEAT. UPON TOUCHING IT, MY FINGER TIP WAS BURNED. IMMEDIATELY DISABLED SEAT HEATER AND STOPPED CAR. CONTACTED SAAB USA. REFERRED ME TO DEALER WHERE I AM TAKING CAR TOMORROW. THEY WILL DIAGNOSE THE PROBLEM, AND DECIDE IF THIS IS A PRODUCT DEFECT. IN MY OPINION, AND BASED ON COMPLAINTS I'VE READ FROM OTHERS, IT IS. VERY SCARY SITUATION. *JB

WHEN DRIVING ON THE HIGHWAY IF TRAFFIC COMES TO A SUDDEN STOP, BRAKING IS HORRIBLE. THE CAR DOES NOT GRIP THE ROAD IT SLIDES. WHEN PUTTING CAR INTO DRIVE OR REVERSE, CAR HESITATES FOR ABOUT 30 SECONDS THEN JERKS INTO ACTION. THE AIR CONDITIONING SYSTEM STOPPED WORKING. THE CAR IS LITERALLY FALLING APART PIECE BY PIECE. *NLM

WHILE DRIVING 60 MPH STEERING WENT COMPLETELY OUT, AND CUSTOMER LOST CONTROL. BUT, WAS ABLE TO GET IT OFF ROAD. CONTACT DEALER, AND WAS TOLD THIS WAS A COMMON PROBLEM.*AK

ON TWO OCCASSIONS, IT WAS NECESSARY TO BRING THE SAAB TO A QUICK STOP ON THE FREEWAY. ON 3/25/00, I NEEDED TO MAKE AN EMERGENCY STOP, GOING 65 MPH AND THE CAR SEEMED TO ALMOST SLIDE, NOT GRIPPING THE ROAD. I HAVE BEEN DRIVING FOR 25 YEARS, AND HAD TO MAKE EMERGENCY STOPS IN THE PAST, AND HAVE NEVER HAD THIS EXPERIENCE. I BELIEVE THE SAAB 9-3'S SHOULD BE CHECKED FOR ABILITY TO STOP IN AN EMERGENCY. ALSO, MY AIRBAGS DID NOT DEPLOY IN THE ACCIDENT. *AK

DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING 45-50 MPH ON A SNOW COVERED HIGHWAY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DETERMINED THE RECOGNITION CASSETTE MODULE FAILED. THE DEALERSHIP WAS NOT NOTIFIED. THERE WERE NO PRIOR PROBLEMS WITH THE VEHICLE. THE CHECK ENGINE LIGHT ILLUMINATED AT THE TIME OF THE INCIDENT. UPDATED 11/3/2006 - ON 11/24/05 THE VEHICLE'S DIRECT IGNITION CASSETTE FAILED WITHOUT WARNING WHICH CAUSED THE VEHICLE TO STALL WHILE BEING DRIVEN IN THE SNOW. AFTER REPLACEMENT OF THE DIRECT IGNITION CASSETTE THE REPAIR FACILITY ALSO HAD TO REPLACE TWO OXYGEN SENSORS AND THE CATALYTIC CONVERTER. THE TECHNICIAN SAID IT WAS POSSIBLE THAT RAW FUEL DAMAGED THE CATALYTIC CONVERTER DURING THE INITIAL FAILURE OF THE DIRECT IGNITION CASSETTE. *NM

WHEN DRIVING ON THE HIGHWAY IF TRAFFIC COMES TO A SUDDEN STOP, BRAKING IS HORRIBLE. THE CAR DOES NOT GRIP THE ROAD IT SLIDES. WHEN PUTTING CAR INTO DRIVE OR REVERSE, CAR HESITATES FOR ABOUT 30 SECONDS THEN JERKS INTO ACTION. THE AIR CONDITIONING SYSTEM STOPPED WORKING. THE CAR IS LITERALLY FALLING APART PIECE BY PIECE. *NLM

TRANSMISSION FAILED. YH

CRUISE CONTROL WAS SET AT 68 MPH. WHEN DRIVER APPLIED BRAKES SEVERAL TIMES CRUISE WOULD NOT DISENGAGE, CAUSING A REAREND ACCIDENT. VEHICLE WAS A TOTAL LOSS. *AK

WHEN DRIVING ON THE HIGHWAY IF TRAFFIC COMES TO A SUDDEN STOP, BRAKING IS HORRIBLE. THE CAR DOES NOT GRIP THE ROAD IT SLIDES. WHEN PUTTING CAR INTO DRIVE OR REVERSE, CAR HESITATES FOR ABOUT 30 SECONDS THEN JERKS INTO ACTION. THE AIR CONDITIONING SYSTEM STOPPED WORKING. THE CAR IS LITERALLY FALLING APART PIECE BY PIECE. *NLM

VEHICLE SUDDENLY LOSES POWER WHEN THE FUSE TO THE FUEL PUMP BLOWS. *MR THE MECHANICS SUGGESTED THAT NOTHING WAS WRONG WITH THE VEHICLE. THEY DID NOT FIND ANYTHING WRONG WITH THE ELECTRICAL WIRING HARNESS. *SC *JB