RoadVitals

2005 Saab 9-3 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Jun 12, 2014
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

14V318000

SEAT BELTS:FRONT:RETRACTOR

Jun 12, 2014
28,789 units potentially affected
The defect: General Motors LLC (GM) is recalling certain model year 2004-2011 Saab 9-3 Convertible vehicles manufactured July 30, 2003, to February 15, 2011. In the affected vehicles, the driver's side front seat belt retractor may break, causing the seat belt webbing not to retract.
The risk: In the event of a crash, a seat belt that has not retracted may not properly restrain the seat occupant, increasing their risk of injury.
The remedy: GM will notify owners, and dealers will replace the driver's seat belt retractor, free of charge. The recall began on October 6, 2015. Owners may contact Saab customer service at 1-800-955-9007. GM's number for this recall is 14222. Note: Special Coverage 10086 will replace the passenger side seat belt retractor if it fails, free of charge, for the life of the vehicle.
General Motors LLCManufacturer number 14222, 15027View on NHTSA.gov
11E009000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Feb 28, 2011
4,887 units potentially affected
The defect: TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
The risk: A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
The remedy: TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
TI GROUP AUTOMOTIVE SYSTEMS, LLCView on NHTSA.gov
05V236000

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS

May 19, 2005
68,654 units potentially affected
The defect: CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
The risk: IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.
The remedy: DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
SAAB CARS USA, INC.Manufacturer number 15019 / 05057View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA08026ClosedEngineering Analysis

Front Suspension Coil Spring Fracture

Opened Dec 22, 2008
Closed Jun 4, 2010

To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front suspension coil spring fractures.ODI is not aware of any crashes or injuries related to the alleged defect.The engineering design and testing data supplied by GM, along with the frequency of consumer complaints and warranty claims related to the alleged defect, tends to support the position that, in general, the coil springs that fractured on many subject vehicles did not achieve the expected service life.However, in regard to the subject vehicles, a front suspension coil spring fracture itself has little safety consequence, as evidenced by the minimal impact on vehicle ride and handling and by the number of drivers who were unaware of the failure condition for some time until alerted by service personnel.The ratio of tire punctures to coil spring fractures appears low and there are no reports of crashes, deaths or injuries related to the alleged defect. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.See the EA08-026 Engineering Analysis Closing Report for more details.

SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
PE08051ClosedPreliminary Evaluation

FRONT SUSPENSION COIL SPRING FRACTURE

Opened Aug 28, 2008
Closed Dec 23, 2008

ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATION, THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).SUBSEQUENT ANALYSIS OF DATA PROVIDED BY GENERAL MOTORS CORP. (GM) HAS LED THE AGENCY TO EXPAND THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL MY 2003-2006 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES. TO DATE, ODI IS AWARE OF 53 NON-DUPLICATIVE COMPLAINTS AND/OR FIELD REPORTS THAT ALLEGE COIL SPRING FRACTURE IN THE SUBJECT VEHICLES, INCLUDING 23 ALLEGING THE FRACTURED SPRING DAMAGED A TIRE, WITH 16 OF THOSE INVOLVING A TIRE PUNCTURE.ANALYSIS OF WARRANTY DATA PROVIDED BY GM IDENTIFIED 1,218 CLAIMS PAID TO REPAIR SUBJECT VEHICLES THAT EXPERIENCED THE ALLEGED DEFECT, OF WHICH 138 VEHICLES ALSO SUFFERED DAMAGE TO THE ADJACENT TIRE AND OF THOSE, 79 VEHICLES EXPERIENCED A TIRE PUNCTURE.ODI IS NOT AWARE OF ANY CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT. GM MADE SEVERAL DESIGN CHANGES TO THE COIL SPRINGS AND/OR MCPHERSON STRUT ASSEMBLIES USED IN THE SUBJECT VEHICLES IN AN APPARENT EFFORT TO ADDRESS THE ALLEGED DEFECT CONDITION.HOWEVER, GM MAINTAINS THAT THE SUBJECT VEHICLES REMAIN WELL CONTROLLED IN THE EVENT OF TIRE PUNCTURE, THAT THE RATE OF TIRE PUNCTURE INCIDENTS RELATED TO COIL SPRING FRACTURES IS LOW, AND THAT THE ALLEGED DEFECT DOES NOT POSE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-026) TO FURTHER STUDY THE SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .