2004 Saab 9-5 Problems

I purchased my 2004 Saab 9-5 in 2023. I was under the impression that everything was running and that drivability was proper. When I attempted to drive the automobile it would start, idle 7 minutes and stall. It would not start again for about 35 minutes. I tried to use it, and this behavior continued. Often, in traffic it would stall while I was moving at low speed, and moderate speed: Without warning, it cuts out and won't start for 40 minutes. I have spent money with my mechanic, over $1,000. I personally bought many parts: MAF sensor, fuel pump relay, fuel filter, and fuel pump. I replaced the Coolant Sensor. After all this the vehicle still stalls 5 minutes after warmup. If it drives to warm up, it stalls and won't restart for 40 minutes. After I replaced the Crankshaft Position Sensor, (CPS), it has never restarted. I bought 3, one a Bosch branded model, and It has never restarted. Many other drivers complain in forums, like Saab Forums, that they are experiencing the same problems. As you know, stalling at highway speeds can cause death. Clearly the problems with the Saab motorcars, produced, owned, and sold through General Motors, are something that poses a hazard, and should be repaired at GM dealership's expense. P.S. The vehicle's immobilizer device has caused my vehicle to not start at all. The key fobs have stopped functioning at all. I replaced the batteries, and they won't connect to the engine. The vehicle will crank, but no start. Battery runs down, with crank, but no start behavior. Can General Motors either: 1. replace the entire engine, 2. repair the "stall, no restart" situation, 3. moreover repair my seeming to be, "anti-theft system, no start" situation, called DICE/TWICEsystem, 4. achieving an actual fix for these older, but cherished sporting cars? Please check these links for confirming information: saabforums.com/forum/saab9-5-12/engine-turns-over--but-wont-start-9066/ www.saabcentral.com/threads/cranks-but-wont-start.689898/

I HAVE OWNED A 2004 SAAB 9-5 SPORT COMBI WAGON SINCE 2006. TWICE, OVER THE LAST SEVERAL YEARS (2011, 2014), MY HUSBAND AND I HAVE BEEN ON THE HIGHWAY AND HAD AN IGNITION SWITCH INCIDENT WHERE HE WAS THE DRIVER AND I WAS THE PASSENGER. IN BOTH INCIDENTS, I TURNED AROUND TO TALK TO MY DAUGHTER (2011) AND THEN DAUGHTERS (2014) AND INADVERTENTLY BUMPED THE KEY IN THE IGNITION WITH MY KNEE. THE IGNITION SWITCH IS LOCATED IN THE CENTER OF THE CAR BY THE CONSOLE. IT ONLY TOOK A SLIGHT TAP OF MY KNEE AND MY CAR SHUT OFF WHILE GOING AT SPEEDS OF 75-80 MPH ON THE HIGHWAY. FORTUNATELY, BOTH TIMES MY HUSBAND WAS ABLE TO PUT THE CAR INTO NEUTRAL AND GET THE CAR OFF TO THE SIDE OF THE ROAD. *TR

2004 SAAB 95 LINEAR WAGON LIFTGATE HINGE FAILURE HINGE MAY OR MAY NOT HOLD THE LIFTGATE AT THE OPEN POSITION. IF ONE IS REACHING DEEP INTO THE TRUNK, LIFTGATE CAN CLOSE BY ITSELF, AND HIT ON THE BACK WITH SUBSTANTIAL FORCE. *TR

I HAVE A 2004 SAAB 9.5 THAT I BOUGHT NEW ON APRIL 1, 2004. I DISCOVERED TODAY FOR THE FIRST TIME THAT MY BACKUP LIGHTS ARE NOT WORKING. YESTERDAY, I FILED A COMPLAINT #10166145. THIS BACK UP LIGHT PROBLEM IS RELATED. THE HARD PLASTIC MOLDED ASSEMBLY ON THE DRIVERS SIDE OF THE TRUNK LID THAT IS SUPPOSED TO PROTECT THE WIRING HARNESS FROM DAMAGE IS ACTUALLY DAMAGING AND EVENTUALLY CUTTING THROUGH ALL OF THE WIRES THAT PASS THROUGH THE ASSEMBLY. WIRES IN MY CAR BEGAN GETTING CUT WITHIN 2 MONTHS OF PURCHASE AND HAVE CONTINUED. THIS ASSEMBLY APPEARS TO BE ABLE TO CUT THROUGH ABOUT 8 WIRES LEAVING EXPOSED WIRE IN CONTACT WITH EACH OTHER AND THEREBY DISABLING THE CRUISE CONTROL, BRAKE LIGHTS, REVERSE LIGHTS AND ELECTRIC TRUNK LOCK. THIS IS NOT NORMAL WEAR AND TEAR - ITS A DESIGN FAULT. THE WIRES SEEM TO CATCH ON THE SHARP EDGE OF THE PLASTIC PROTECTOR (!) THAT FITS INTO THE LID. THEY RUB AGAINST THIS AS THE LID IS OPEN AND CLOSED. I BELIEVE THIS SITUATION PRESENTS A POTENTIAL ELECTRICAL FIRE HAZARD AND SAFETY HAZARD AND THAT THE NHTSA SHOULD IMMEDIATELY ISSUE A RECALL ON THIS ITEM. *NM

I purchased my 2004 Saab 9-5 in 2023. I was under the impression that everything was running and that drivability was proper. When I attempted to drive the automobile it would start, idle 7 minutes and stall. It would not start again for about 35 minutes. I tried to use it, and this behavior continued. Often, in traffic it would stall while I was moving at low speed, and moderate speed: Without warning, it cuts out and won't start for 40 minutes. I have spent money with my mechanic, over $1,000. I personally bought many parts: MAF sensor, fuel pump relay, fuel filter, and fuel pump. I replaced the Coolant Sensor. After all this the vehicle still stalls 5 minutes after warmup. If it drives to warm up, it stalls and won't restart for 40 minutes. After I replaced the Crankshaft Position Sensor, (CPS), it has never restarted. I bought 3, one a Bosch branded model, and It has never restarted. Many other drivers complain in forums, like Saab Forums, that they are experiencing the same problems. As you know, stalling at highway speeds can cause death. Clearly the problems with the Saab motorcars, produced, owned, and sold through General Motors, are something that poses a hazard, and should be repaired at GM dealership's expense. P.S. The vehicle's immobilizer device has caused my vehicle to not start at all. The key fobs have stopped functioning at all. I replaced the batteries, and they won't connect to the engine. The vehicle will crank, but no start. Battery runs down, with crank, but no start behavior. Can General Motors either: 1. replace the entire engine, 2. repair the "stall, no restart" situation, 3. moreover repair my seeming to be, "anti-theft system, no start" situation, called DICE/TWICEsystem, 4. achieving an actual fix for these older, but cherished sporting cars? Please check these links for confirming information: saabforums.com/forum/saab9-5-12/engine-turns-over--but-wont-start-9066/ www.saabcentral.com/threads/cranks-but-wont-start.689898/

I HAVE OWNED A 2004 SAAB 9-5 SPORT COMBI WAGON SINCE 2006. TWICE, OVER THE LAST SEVERAL YEARS (2011, 2014), MY HUSBAND AND I HAVE BEEN ON THE HIGHWAY AND HAD AN IGNITION SWITCH INCIDENT WHERE HE WAS THE DRIVER AND I WAS THE PASSENGER. IN BOTH INCIDENTS, I TURNED AROUND TO TALK TO MY DAUGHTER (2011) AND THEN DAUGHTERS (2014) AND INADVERTENTLY BUMPED THE KEY IN THE IGNITION WITH MY KNEE. THE IGNITION SWITCH IS LOCATED IN THE CENTER OF THE CAR BY THE CONSOLE. IT ONLY TOOK A SLIGHT TAP OF MY KNEE AND MY CAR SHUT OFF WHILE GOING AT SPEEDS OF 75-80 MPH ON THE HIGHWAY. FORTUNATELY, BOTH TIMES MY HUSBAND WAS ABLE TO PUT THE CAR INTO NEUTRAL AND GET THE CAR OFF TO THE SIDE OF THE ROAD. *TR

KUMHO ECSTA LX PLATINUM 225/45ZR17 TIRE ON LEFT FRONT OF SAAB 9-5 WITH APPROXIMATELY 25,000 MILES USE BLEW OUT SUDDENLY (RAPID LOSS OF AIR) AND WITHOUT WARNING AT 35 MPH. APPEARS TO HAVE SEVERAL CRACKS IN SIDEWALL NEAR TREAD. PRIOR TO BLOWOUT, SLIGHT LEFT PULL IN CAR STEERING WAS NOTED DURING INTERSTATE DRIVING, BUT ASSUMED TO BE ALIGNMENT ISSUE SINCE ALL TIRES MAINTAINED NORMAL PRESSURE. TIRE WAS REPLACED; DEALER DETERMINED TIRE WAS DEFECTIVE (POSSIBLE INTERNAL BELT SLIP). FAILED TIRE IS AVAILABLE FROM OWNER. *TR

AFTER SIGNIFICANT VIBRATION UNDER FRONT END AT HIGHWAY SPEEDS APPEARING AT LESS THAN 10,000 MILES, CAR UNDERWENT ALIGNMENT AND 3 HIGH SPEED BALANCES. ACCORDING TO DEALERSHIP, "ALL 4 TIRES WERE WORN ON INSIDES AND COULD ONLY BE CAUSED BY DEFECT." DEALER STATED THAT "ROAD FORCING WILL NOT ALLOW TIRES TO BE WITHIN THE LIMIT. TIRES NEED TO BE REPLACED. SENT TIRES TO MANUFACTURER FOR WARRANTY." SERVICE COMPLETED ON 10.29.04, WITH PIRELLIS REPLACED BY SAME SIZE MICHELINS. WORK ORDER WAS COMPLETED ON 1.7.05, WHICH WAS THE FIRST TIME I SAW DETAILS AND CHARGES, DESPITE REPEATED REQUESTS SINCE 10.29.04. MY UNDERSTANDING, AND AUTHORIZATION AT THE TIME, WAS FOR THE PIRELLIS TO BE REPLACED BECAUSE OF THE DEFECTS, BUT WITH MICHELINS, TO AVOID POSSIBILITY OF DEFECTS WITH THE REPLACEMENT PIRELLIS, AT A COST OF UP TO $50 PER TIRE BECAUSE OF THE CHANGE. DEALER MAINTAINS I OWE $915. 82 FOR THE MICHELINS, LESS THE $212.80 CREDIT PIRELLI ISSUED ON 1.7.05. IRONICALLY, THE VIBRATION IN THE CAR CONTINUES WITH THE NEW MICHELINS. I DO NOT BELIEVE IT WAS THE INTENT OF THE DEALER TO MISLEAD ME, BUT THAT WAS THE RESULT. A WORK ORDER PROVIDED AT THE TIMES REQUESTED INSTEAD OF OVER TWO MONTHS LATER WOULD HAVE DEFINED THE AGREEMENT AND RESULTED IN A DIFFERENT COURSE OF ACTION. *NM

I purchased my 2004 Saab 9-5 in 2023. I was under the impression that everything was running and that drivability was proper. When I attempted to drive the automobile it would start, idle 7 minutes and stall. It would not start again for about 35 minutes. I tried to use it, and this behavior continued. Often, in traffic it would stall while I was moving at low speed, and moderate speed: Without warning, it cuts out and won't start for 40 minutes. I have spent money with my mechanic, over $1,000. I personally bought many parts: MAF sensor, fuel pump relay, fuel filter, and fuel pump. I replaced the Coolant Sensor. After all this the vehicle still stalls 5 minutes after warmup. If it drives to warm up, it stalls and won't restart for 40 minutes. After I replaced the Crankshaft Position Sensor, (CPS), it has never restarted. I bought 3, one a Bosch branded model, and It has never restarted. Many other drivers complain in forums, like Saab Forums, that they are experiencing the same problems. As you know, stalling at highway speeds can cause death. Clearly the problems with the Saab motorcars, produced, owned, and sold through General Motors, are something that poses a hazard, and should be repaired at GM dealership's expense. P.S. The vehicle's immobilizer device has caused my vehicle to not start at all. The key fobs have stopped functioning at all. I replaced the batteries, and they won't connect to the engine. The vehicle will crank, but no start. Battery runs down, with crank, but no start behavior. Can General Motors either: 1. replace the entire engine, 2. repair the "stall, no restart" situation, 3. moreover repair my seeming to be, "anti-theft system, no start" situation, called DICE/TWICEsystem, 4. achieving an actual fix for these older, but cherished sporting cars? Please check these links for confirming information: saabforums.com/forum/saab9-5-12/engine-turns-over--but-wont-start-9066/ www.saabcentral.com/threads/cranks-but-wont-start.689898/

TL* THE CONTACT OWNS A 2004 SAAB 9-5. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE CRANK SHAFT POSITION SENSOR, FUEL PUMP, AND THE TWICE UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 51,108.

PURCHASED THE CAR USED 5/23/08 WITH 42,700 MILES FROM SAAB DEALERSHIP. WITHIN A MONTH THE HEADLIGHTS WORKED RANDOMLY, CHECK ENGINE LIGHT WOULD COME ON RANDOMLY. CALLED THE DEALERSHIP AND WAS TOLD THAT IT WOULDN'T HURT ANYTHING AND SHOULD IT BECOME MORE FREQUENT, BRING THE CAR IN. 8/18 TOOK THE CAR IN TO DEALERSHIP WHEN THE LIGHT WAS COMING ON MORE FREQUENTLY. HEADLIGHT RELAY REPLACED, ENGINE LIGHT WAS DUE TO A DIRECT IGNITION CASSETTE FAILURE. SAAB DEALERSHIP ORDERED THE PART WHICH WAS ON NATIONAL BACK ORDER, PART CAME IN 10/9. VEHICLE WAS TAKEN IN 10/6 DUE TO STEAM COMING FROM UNDER THE HOOD, TEMPERATURE GAUGE NEVER MOVED ABOVE THE MIDDLE. BYPASS VALVE REPLACED ($450 PARTS/LABOR). VEHICLE HAS APPROX. 48,500 MILES AND IS OUT OF MANUFACTURER WARRANTY AND REPAIR IS NOT COVERED UNDER DEALERSHIPS LIMITED WARRANTY. AFTER AN INTERNET SEARCH FOR INFORMATION RELATING TO THE DI CASSETTE FAILURE I FOUND THAT THERE WAS A RECALL FOR 2000-2002 MODELS FOR THE SAME ISSUE. MY VEHICLE IS A 2004 SAAB 9.5 AERO SEDAN. *TR

7/26/22 10:23pm on interstate 25 North of Denver mile 249 I was not able to stop and rear ended another vehicle. My air bags did not deploy there were no dash lights indicating any problem with the airbags prior to the accident. My vehicle was not drivable and was towed to H&R Towing in Johnstown, CO. The only inspection so far has been by an Amica Insurance adjuster. My set belt pretensioner held me fast but the crown of my head went forward into the visor area I was dazed. I went by ambulance to MCR hospital in Loveland diagnosed with a concussion. I had other bruises from the seatbelt and hitting my left knee on the dash. The damage to my car begins at the driver’s side headlamp area and radiates across the font of the car to the headlights on the passenger side. The hood was folded back and there is significant damage to all the components in the front part of the engine compartment. I’ve tried to contact Saab cars but no response, they stopped building cars in 2011. I tried GM as well, no response.

PURCHASED THE CAR USED 5/23/08 WITH 42,700 MILES FROM SAAB DEALERSHIP. WITHIN A MONTH THE HEADLIGHTS WORKED RANDOMLY, CHECK ENGINE LIGHT WOULD COME ON RANDOMLY. CALLED THE DEALERSHIP AND WAS TOLD THAT IT WOULDN'T HURT ANYTHING AND SHOULD IT BECOME MORE FREQUENT, BRING THE CAR IN. 8/18 TOOK THE CAR IN TO DEALERSHIP WHEN THE LIGHT WAS COMING ON MORE FREQUENTLY. HEADLIGHT RELAY REPLACED, ENGINE LIGHT WAS DUE TO A DIRECT IGNITION CASSETTE FAILURE. SAAB DEALERSHIP ORDERED THE PART WHICH WAS ON NATIONAL BACK ORDER, PART CAME IN 10/9. VEHICLE WAS TAKEN IN 10/6 DUE TO STEAM COMING FROM UNDER THE HOOD, TEMPERATURE GAUGE NEVER MOVED ABOVE THE MIDDLE. BYPASS VALVE REPLACED ($450 PARTS/LABOR). VEHICLE HAS APPROX. 48,500 MILES AND IS OUT OF MANUFACTURER WARRANTY AND REPAIR IS NOT COVERED UNDER DEALERSHIPS LIMITED WARRANTY. AFTER AN INTERNET SEARCH FOR INFORMATION RELATING TO THE DI CASSETTE FAILURE I FOUND THAT THERE WAS A RECALL FOR 2000-2002 MODELS FOR THE SAME ISSUE. MY VEHICLE IS A 2004 SAAB 9.5 AERO SEDAN. *TR

TL* THE CONTACT OWNS A 2004 SAAB 9-5. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE CRANK SHAFT POSITION SENSOR, FUEL PUMP, AND THE TWICE UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 51,108.

I HAVE OWNED A 2004 SAAB 9-5 SPORT COMBI WAGON SINCE 2006. TWICE, OVER THE LAST SEVERAL YEARS (2011, 2014), MY HUSBAND AND I HAVE BEEN ON THE HIGHWAY AND HAD AN IGNITION SWITCH INCIDENT WHERE HE WAS THE DRIVER AND I WAS THE PASSENGER. IN BOTH INCIDENTS, I TURNED AROUND TO TALK TO MY DAUGHTER (2011) AND THEN DAUGHTERS (2014) AND INADVERTENTLY BUMPED THE KEY IN THE IGNITION WITH MY KNEE. THE IGNITION SWITCH IS LOCATED IN THE CENTER OF THE CAR BY THE CONSOLE. IT ONLY TOOK A SLIGHT TAP OF MY KNEE AND MY CAR SHUT OFF WHILE GOING AT SPEEDS OF 75-80 MPH ON THE HIGHWAY. FORTUNATELY, BOTH TIMES MY HUSBAND WAS ABLE TO PUT THE CAR INTO NEUTRAL AND GET THE CAR OFF TO THE SIDE OF THE ROAD. *TR

I HAVE A 2004 SAAB 9.5 THAT I BOUGHT NEW ON APRIL 1, 2004. FROM DAY 1 THE CRUISE CONTROL WAS WORKING ERRATICALLY. DEALER SAID HE COULD NOT REPLICATE PROBLEM. THEN CRUISE CONTROL STOPPED WORKING. THEN THE ELECTRIC TRUNK LOCK STOPPED WORKING. I CONTACTED THE DEALER TELLING IT THAT EVEN THOUGH I WAS NOW BEYOND THE 50,000 MILE PORTION OF THE 4 YEAR WARRANTY (OF WHICH ONLY 28 MONTHS HAD ELAPSED) I WANTED THE TRUNK AND CRUISE ISSUES FIXED ALONG WITH A LAUNDRY LIST OF ITEMS THAT WERE NOT ADDRESSED PREVIOUSLY THE LAST TIME I BROUGHT THE CAR IN UNDER WARRANTY. THEY HAVE REFUSED TO ADDRESS ANY OF THE ISSUES. I FOUND A SITE ON THE INTERNET CALLED SAABNET. A PARTICULAR POST HIT THE PROBLEM ON THE HEAD. HTTP://WWW.SAABNET.COM/TSN/BB/9-5/INDEX.HTML?BID=125557 IT SAID: TURNS OUT TO BE A BADLY WORN WIRING LOOM WERE THE CABLES RUN FROM THE CAR TRUNK INTO THE TRUNK LID. 6 WIRES HAD BROKEN THROUGH THE INSULATION AND TWO HAD COMPLETELY SNAPPED. THIS CAR IS LESS THAN 3 YEARS OLD!!!! THIS IS NOT NORMAL WEAR AND TEAR - ITS A DESIGN FAULT. THE WIRES SEEM TO CATCH ON THE SHARP EDGE OF THE PLASTIC PROTECTOR (!) THAT FITS INTO THE LID. THEY RUB AGAINST THIS AS THE LID IS OPEN AND CLOSED. YOU CAN CHECK TO SEE IF YOURS IS OK SIMPLY BY PULLING OFF THE PROTECTIVE RUBBER BOOT THAT ATTACHES TO THE END OF THE PLASTIC PROTECTOR. I DID THE VERY SIMPLE CHECK THE POSTER RECOMMENDED ABOVE BY PULLING THE RUBBER COVER BACK AND WAS SOMEWHAT AMAZED TO SEE 4 WIRES COMPLETELY CUT AND THE OTHER 3 WITH BROKEN INSULATORS. AS THE POSTER ON SAABNET INDICATED, THIS IS A DESIGN FLAW AND APPEARS AS IF IT COULD LEAD TO FIRE. LOOKING FURTHER ON SAABNET, I SEE THAT MANY PEOPLE HAVE HAD THIS PROBLEM AS IT IS DISCUSSED QUITE FREQUENTLY. I BELIEVE THIS SITUATION PRESENTS A POTENTIAL ELECTRICAL AND FIRE HAZARD AND THAT THE NHTSA SHOULD IMMEDIATELY ISSUE A RECALL ON THIS ITEM. *NM