2003 Saturn Ion Transmission Problems

TL* THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT THE KEY FAILED TO TURN TO THE ON POSITION AND THE TRANSMISSION FAILED TO SHIFT INTO PARK FROM REVERSE OR DRIVE. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO GET THE VEHICLE TO SHIFT INTO PARK AND REMOVE THE KEY. THE CONTACT HAD TO WIGGLE THE KEY BACK AND FORTH, APPLY FORCE TO THE SHIFTER AND TURN THE WHEEL BACK AND FORTH TO REMOVE THE KEY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN DIAGNOSED THAT THE SHIFTER AND CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

NHTSA ID

10648889

Incident

Aug 17, 2014

Mileage

33,000 mi

2003 SATURN ION. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEMS AND SEEKS VEHICLE REIMBURSEMENT. *SMD THE CONSUMER STATED WHEN HE BACKED THE VEHICLE OUT OF THE GARAGE, AND PUT THE GEAR IN DRIVE, THE VEHICLE WOULD NOT GO FORWARD. THE CONSUMER BACKED THE VEHICLE BACK IN TO THE GARAGE. THE NEXT DAY HE TRIED IT, AND THE VEHICLE WENT FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO FIND A PROBLEM. FROM SEPTEMBER 2012, UNTIL JANUARY 2013, THE CONSUMER HAD PROBLEMS WITH THE VEHICLE GOING FORWARD. EACH TIME, IT WOULD WORK AGAIN AFTER LETTING THE VEHICLE SIT FOR AWHILE. THEN ON FEBRUARY 23, 2013, THE VEHICLE WOULD NOT GO INTO REVERSE. AFTER LETTING THE VEHICLE SIT FOR ABOUT FOUR HOURS, THE SHIFTING WORKED. AFTER DRIVING THREE BLOCKS, THE VEHICLE STOPPED AND THE SHIFTING WENT OUT AGAIN. THE VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP. THE REPAIR SHOP INFORMED THE CONSUMER THE TRANSMISSION HAD FAILED AND THE PARTS ALONE WOULD COST $3,982.58.

NHTSA ID

10510086

Incident

Sep 1, 2012

TL*THE CONTACT OWNS A 2003 SATURN ION. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE AND ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE EVENTUALLY STARTED AFTER SEVERAL ATTEMPTS. SHE TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER INFORMED HER THAT SHE NEEDED TO REPLACE THE STARTER. THE VEHICLE WAS REPAIRED. SHE ALSO STATED THAT THE KEY WAS GETTING STUCK INSIDE OF THE IGNITION WHICH MADE IT IMPOSSIBLE TO TURN THE VEHICLE OFF OR REMOVE THE KEY FROM THE CYLINDER. THE VEHICLE WAS INSPECTED FOR THAT FAILURE AND INFORMED HER THAT SHE NEEDED TO REPLACE THE IGNITION SWITCH. INSTEAD OF REPLACING THE IGNITION SWITCH DUE TO COST THEY OPTED TO REPROGRAM THE KEY SO THAT SHE COULD REMOVE IT NO MATTER WHAT GEAR THE VEHICLE WAS IN. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. UPDATED 2/23/11 *CN ACCORDING TO THE SERVICE INVOICE, THE VEHICLE NEEDED A NEW SHIFTER WHICH WAS CAUSING THE KEY TO BECOME STUCK IN THE IGNITION. UPDATED 06/20/11

NHTSA ID

10376232

Incident

Jul 1, 2010

Mileage

70,000 mi

WAS STOPPED AT A RED LIGHT; WHEN IT TURNED GREEN, CAR DID NOT ACCELERATE. HAD TO BE PUSHED OFF TO SIDE OF ROAD; TURNED CAR OFF, THEN RE-STARTED IT. IT DROVE A SHORT DISTANCE, THEN HAD NO POWER, BUT WAS ABLE TO COAST SAFELY TO SIDE OF ROAD. CAR WAS TOWED TO GAS STATION. MECHANIC CHECKED FLUID LEVEL WAS GOOD AND DID NOT HAVE BURNT SMELL. TRIED TO START CAR AGAIN - MADE LOW WINDING NOISE AND WOULD NOT GO INTO GEAR. WHEN GAS PEDAL WAS PRESSED, THE SPEEDOMETER MOVED. MECHANIC SAID IT NEEDS NEW TRANSMISSION. CAR HAS 90,000 MILES. *TR

NHTSA ID

10344281

Incident

Jul 12, 2010

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2003 SATURN ION. WHILE ACCELERATING ONTO A HIGHWAY AT 40 MPH, THE VEHICLE BEGAN TO ABNORMALLY DECELERATE WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE A DIAGNOSTIC TEST INDICATED THE TRANSMISSION WOULD NEED TO BE REPLACED. THE MANUFACTURER ADVISED THEY WOULD GET BACK WITH THE CONTACT TO DETERMINE IF ANY ASSISTANCE WOULD BE PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 74,085.

NHTSA ID

10340407

Incident

Jun 25, 2010

Mileage

74,085 mi

TRANSMISSION FAILURE. THERE WAS A SAFETY ALERT LETTER ISSUED NOVEMBER OF 2009 FOR 2003 SATURN ION OWNERS WITH STIPULATIONS CLAIMING THAT THE CAR HAD TO BE IN SERVICE FOR 5 YEARS OR LESS TO BE ABLE TO HAVE THE PART REPAIRED AT NO COST. NO ONE FALLS UNDER THIS CRITERIA CONSIDERING THAT THIS ALERT WAS SENT OUT IN NOVEMBER OF 2009, REFER TO SAFETY ALERT #09280. MY CAR HAS 55,000 MILES ON IT AND A TRANSMISSION IS NOT AN EXPENSE THAT A SATURN CUSTOMER SHOULD HAVE TO BE PAYING IN MY OPINION. THEY DO OFFER A 50% OFF DEAL WHERE THEY TAKE CARE OF HALF THE COST. IT'S A $5000 JOB AND HALF IS $2500, STILL A VERY HIGH COST FOR A PROBLEM THAT SHOULD HAVE BEEN CONSIDERED A RECALL. I HAVE ONLY HAD THIS CAR FOR 2 YEARS AND TO HAVE THIS PROBLEM ON A CAR THAT I HAVE A CAR PAYMENT ON. PLEASE ASSIST THE SATURN OWNERS IN FINDING OUT HOW THIS DID NOT BECOME A RECALL. SO MANY PEOPLE ARE HAVING THIS ISSUE AND IT SEEMS UNFAIR TO HAVE TO PAY MORE MONEY FOR A DEFECT IN THE SATURN ION AND VUE'S TRANSMISSION. THANK YOU FOR YOUR TIME AND HELP IN THIS MATTER. *TR

NHTSA ID

10334789

Incident

Apr 4, 2010

Mileage

55,000 mi

I WAS AT A STOP SIGN AND MY CLUTCH PEDAL DISCONNECTED FROM ITS SOCKET JUST AS I WAS ABOUT TO BEGIN DRIVING. *TR

NHTSA ID

10329234

Incident

May 4, 2009

Mileage

59,000 mi

I WAS DRIVING MY 2003 SATURN ION2 WITH 4 CYL AND VTI TRANSMISSION WITH 71,000 MILES TO WORK AND IT FELT LIKE IT WENT INTO NEUTRAL AND THEN SLOWED TO A STOP. I WAS ALMOST REAR-ENDED AND WAS STRANDED ON A BUSY HIGHWAY. IT TURNS OUT MY VTI TRANSMISSION IS DEFECTIVE, THERE IS A CLASS ACTION LAW SUIT AGAINST GM FOR IT, AND IT IS FOLLOWING THE SETTLEMENT BEFORE IT HAS BEEN RULED UPON BY THE JUDGE. THEY ARE COVERING 75% OF THE REPAIR BECAUSE I AM THE SECOND OWNER. IF I WAS THE ORIGINAL OWNER, THEY WOULD HAVE COVERED 100%. I PURCHASED THE CAR FROM THE DEALER WHERE IT WAS ORIGINALLY SOLD AND IT WAS A CERTIFIED USED CAR. I WAS HAVING TRANSMISSION NOISES AFTER I BOUGHT THE CAR AND IN REQUESTING THE SERVICE RECORDS, I FOUND OUT THAT THE PREVIOUS OWNER HAD TRANSMISSION PROBLEMS AND WORK WAS DONE FOR THEM. I BROUGHT THE CAR IN AND THEY ALSO DID A REPAIR ON MY TRANSMISSION (THIS WAS PRIOR TO IT HAVING 36,000 MILES AND WAS STILL COVERED UNDER THE FACTORY WARRANTY). I'M TRYING TO FIGURE OUT WHY THERE HAS NOT BEEN A RECALL ON THIS TRANSMISSION WHEN ALL YOU HAVE TO DO IS DO A GOOGLE SEARCH FOR SATURN VTI TRANSMISSION PROBLEMS AND YOU WILL FIND THOUSANDS OF PEOPLE THAT HAVE HAD PROBLEMS. THE 75% REPAIR STILL LEAVES ME PAYING $1,150 AND MY CAR IS WORTH VERY LITTLE BECAUSE ALL THE CAR COMPANIES KNOW ABOUT THE PROBLEM, WHICH HAS DEVALUED THE CAR. THE WORST PART OF THIS IS THAT THEY ARE PUTTING IN THE VERY SAME DEFECTIVE TRANSMISSION AND AGAIN THE GOOGLE SEARCH REVEALS THEY GO BAD AGAIN AND AGAIN AND AGAIN. CAN THE NHTSA PLEASE HELP ME AND THE THOUSANDS OF OTHER SATURN OWNERS WITH THIS PROBLEM? THIS TRANSMISSION NEEDS TO BE RECALLED. *TR

NHTSA ID

10265117

Incident

Apr 2, 2009

Mileage

71,000 mi

2003 SATURN TRANSMISSION FAILED TO WORK PROPERLY WITH AROUND 69000 AND SATURN REFUSED TO HONOR MY WARRANTY ON MY CAR. *TR

NHTSA ID

10240317

Incident

Jan 9, 2006

Mileage

69,000 mi

FAILED TRANSMISSION. *TR

NHTSA ID

10233339

Incident

Jul 3, 2008

Mileage

23,000 mi

WHILE DRIVING MY 2003 SATURN ION 3 THE MOTOR WILL STALL OUT AND LOOSE POWER WHILE DRIVING IT SEEMS LIKE THE TRANSMISSION SLIPS AND A NEW ONE WAS PUT IN AND IT STILL DOES THE SAME THING. WHILE DRIVING ON HIGHWAY IT DOES THIS. *TR

NHTSA ID

10226870

Incident

Oct 11, 2007

Mileage

90,025 mi

2003 SATURN ION III DISENGAGES IN THE MIDDLE OF TRAFFIC AS IF GEARS HAVE SLIPPED INTO NEUTRAL AT SPEEDS FROM BETWEEN 20 AND 60 MPH, SO THAT THERE IS NO FORWARD MOVEMENT SUDDENLY AND THEN RE-ENGAGES. ALMOST REAR-ENDED SEVERAL TIMES ALSO CAR WILL NOT START IF TURNED OFF FOR A SHORT TIME AND KEY LOCKS IN IGNITION. GEARS WERE RE-CALIBRATED AND IGNITION REPLACED, BUT PROBLEMS CONTINUE. *TR

NHTSA ID

10219981

Incident

Mar 1, 2008

Mileage

2,000 mi

WILL DRIVING DOWN THE ROAD THE TRANSMISSION IN MY SATURN ION LVL 3 SLIPS AND I HAVE TO LET MY FOOT OFF THE GAS AND THEN KICK THE GAS PEDAL FOR IT TO GO INTO GEAR. IT DOES THIS ALL THE TIME WHEN I AM DRIVING IT. ALSO WHEN I GO TO PARK THE CAR, I PUT IT IN PARK AND PULL UP THE EMERGENCY BRAKE AND I GO TO REMOVE THE KEY AND IT WILL ONLY GO AS FAR AS ACC MODE. IT WILL NOT RELEASE. I HAVE TO WAIT 20 TO 30 MINUTES UNTIL IT RELEASES AUTOMATICALLY. I HAVE READ ONLINE THIS IS A KNOWN PROBLEM WITH SATURNS AND I HAVE BEEN TOLD THAT THEY WILL NOT FIX IT. IT DOES THIS ALMOST EVERY SINGLE DAY. *NM

NHTSA ID

10178597

Incident

Jan 1, 2007

Mileage

51,500 mi

SINCE WE PURCHASED THIS VEHICLE BRAND NEW IN 2003, THE TRANSMISSION HAS SLIPPED OCCASIONALLY UPON NORMAL ACCELERATION. WE BROUGHT THIS TO THE ATTENTION OF THE DEALERSHIP AT OUR REGULAR MAINTENANCE APPOINTMENTS, AND THEY TOLD US THAT THIS WAS THE NORMAL FUNCTIONING OF THE TRANSMISSION. FAST-FOWARD 3 YRS, 40,000 MILES, AND THE PROBLEM HAS BECOME A THREAT TO THE SAFETY OF THOSE DRIVING IN AND AROUND THE VEHICLE. WHEN ATTEMPTING TO MAKE A TURN OUT OF A PARKING LOT ONTO A MAJOR ROAD, THE CAR ROLLED DOWN THE HILL INTO THE ROAD, BUT IT WOULD NOT MOVE ANY FARTHER ONCE ON A FLAT SURFACE. I AM LUCKY THAT NO ONE WAS COMING TOO CLOSE OR FAST BEHIND ME, OR MY VEHICLE WOULD HAVE BEEN A SUDDEN, UNAVOIDABLE ROADBLOCK FOR SURE. THIS ALSO HAPPENED WHILE I WAS ATTEMPTING TO MAKE A LEFT HAND TURN WITH HEAVY ONCOMING TRAFFIC. PEOPLE WERE SOMEHOW ABLE TO AVOID MY CAR, ALTHOUGH IT WAS A MAJOR HAZARD TO SAFETY. THESE WERE TERRIFYING EXPERIENCES, AND I IMMEDIATELY DROPPED MY CAR OFF AT THE DEALERSHIP THAT NIGHT (I HAPPENED TO BE DOWN THE ROAD FROM THE DEALER WHEN THESE EVENTS OCCURRED). ACCORDING TO THE DEALERSHIP, THE TRANSMISSION FLUID WAS VERY DARK, FLUID PUMP SEVERELY DAMAGED, AND THE 2ND GEAR CLUTCH AND COAST ASSEMBLY "BURNED UP". THE TRANSMISSION, PUMP, GEARS, CLUTCHES, AND TORQUE CONVERTER WERE REPLACED AT A COST OF $1250, WHICH THEY CLAIMED WAS A GREAT DEAL FOR US, AS THIS WAS CLAIMED TO BE A $5500 JOB. I APPRECIATE THEIR EFFORTS AND ATTEMPT TO RECTIFY THE SITUATION, HOWEVER I AM STILL DISAPPOINTED IN THE LACK OF QUALITY CONTROL, AND THE APPARENT LACK OF RESEARCH AND DEVELOPMENT IN THE ENGINEERING OF THIS VEHICLE. NO ONE EXPECTS TO NEED TO REPLACE A TRANSMISSION IN A CAR WITH 40,000 MILES. MY LIFE WAS PUT AT RISK BECAUSE OF A MANUFACTURING ERROR IN THIS VEHICLE, AND I HOPE THAT THE THE NHTSA TAKES THE NECESSARY ACTIONS TO PREVENT MORE LIVES FROM BEING PUT AT RISK OR LOST DUE TO THIS ERROR.

NHTSA ID

10168397

Incident

Sep 12, 2006

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH THE VEHICLE REVVED AT A HIGH RATE FOLLOWED BY A SUDDEN DECREASE. THE VEHICLE WAS SEEN BY AN INDEPENDENT REPAIR SHOP. THE MECHANIC PERFORMED A DIAGNOSTIC AND ROAD TESTED WHICH INDICATED A NEW TRANSMISSION WAS NEEDED. THE MECHANIC REPLACED THE AUTOMATIC TRANSMISSION AND REBUILT THE TORQUE CONVERTER, WHICH CORRECTED THE PROBLEM. THE CONTACT INSISTED THAT THE TRANSMISSION WAS DEFECTIVE FROM THE FACTORY. THE VEHICLE WAS 3 YEARS OLD. THE CONTACT HAD THE TRANSMISSION REPLACED. HAD TO PAY OUT-OF-POCKET EXPENSES IN THE AMOUNT OF $2,136.00. UPDATED ON 05/18/2006. *AK UPDATED 06/15/06. *JB

NHTSA ID

10154942

Incident

Feb 12, 2006

Mileage

46,000 mi

THIS HAS HAPPENED TWICE IN EXACTLY THIRTEEN MONTHS THE FIRST TIME WAS ON FEBRUARY 3, 2005. I ADJUSTED MY POWER DRIVERS SIDE MIRROR WHILE DRIVING HOME AT NIGHT ON HIGHWAY 61 AND HEARD A POP AND ALL MY LIGHTS INCLUDING HEADLIGHTS AND DASH LIGHTS WENT OUT . MY FOUR WAY SAFETY FLASHERS ALSO WOULD NOT WORK I WAS DRIVING IN COMPLETE DARKNESS WHILE TRAVELING APPROXIMATELY 67 MPH THIS INCIDENT OCCURRED ALMOST IDENTICALLY LAST YEAR WHILE DRIVING IN TOWN APPROXIMATELY 25 MPH ADJUSTED MIRROR HEARD A POP AND ALL LIGHTS WENT OUT. LUCKILY IN BOTH INCIDENTS NO ONE HIT ME FROM BEHIND DUE TO THE FACT THEY COULDN'T SEE ME UNTIL IT WAS TOO LATE. NO ONE WAS KILLED OR INJURED BUT THAT WAS JUST PURE LUCK .. LAST YEARS INCIDENT I HAD MY CAR TOWED TO SATURN AND THEY DETERMINED THAT THE BCM FUSE WAS BAD THEY REPLACED FUSE. OBVIOUSLY THEY DID NOT GET TO THE ROOT OF THE PROBLEM YOU WOULD THINK YOU CAN ADJUST YOUR POWER MIRROR WITHOUT HAVING ALL LIGHTS SHUT OFF INCLUDING DASH LIGHTS .. ONCE YOU PUT THE VEHICLE INTO PARK YOU CANNOT TURN IT OFF COMPLETELY THE KEY WILL ONLY GO AS FAR AS THE ACCESSORY POSITION AND CANNOT BE REMOVED. THE ENGINE WILL RUN YOU JUST CAN'T MOVE THE VEHICLE. SOMEHOW I DO NOT THINK THEY CORRECTED THE PROBLEM ENTIRELY WHEN THEY REPLACED THE FUSE. IT SEEMS TO ME YOU SHOULD NOT BLOW A BCM FUSE EVERY THIRTEEN MONTHS EXACTLY TO THE DAY. IT IS SUCH A POTENTIALLY FATAL PROBLEM THE CONSEQUENCES ARE TERRIFYING. MY 2003 SATURN ION-3 CAN NOT BE THE ONLY CAR OUT THERE WITH THIS HAPPENING ESPECIALLY TWICE IN THIRTEEN MONTHS. *JB

NHTSA ID

10152158

Incident

Mar 3, 2006

Mileage

45,470 mi

I HAVE A 2003 SATURN ION THAT IS HAVING SHIFTING PROBLEMS. THE CAR HAS 52,000 MILES ON IT, AND IT IS OUT OF WARRANTY, MY DAUGHTER ORIGINALLY HAD THE CAR, AND DROVE IT, WITHOUT ME KNOWING SHE WAS HAVING PROBLEMS WITH IT SHIFTING. ALSO THERE SEEMS TO BE A VIBRATION IN THE FRONT END. I AM TAKING IT IN FOR EVALUATION. I HAVE HAD IT IN SEVERAL TIMES FOR THE TRANSMISSION, BUT THEY COULDN'T FIND ANYTHING WRONG. I DON'T UNDERSTAND GM NOT DOING SOMETHING ABOUT THESE TRANSMISSION PROBLEMS. ALSO THE SEAT BELT LOCKS AND YOU CAN'T GET OUT OF IT. THIS IS A REAL SAFETY ISSUE AND I HOPE THE ADDRESS IT. YOU LITERALLY HAVE TO CRAWL OUT OF THE BELT. *JB

NHTSA ID

10150986

Incident

Jan 1, 2005

Mileage

37,000 mi

2003 ION HAS HAD BLOWER FAN, CLUTCH SWITCH, CYLINDER CABLE HOOD LATCH, BRAKE LIGHT BULB, WIPER MODULE ALL REPLACED WITH IN MONTHS APART FROM EACH OTHER. *TS THE ROTORS WERE WARPED AND THE TAIL LAMP FAILED. *JB

NHTSA ID

10150851

Incident

Oct 1, 2004

DT: THE CONSUMER STATED TRANSMISSION HAS NEVER WORKED PROPERLY. THE VEHICLE HAS BEEN TO THE DEALERSHIP MULTIPLE TIMES, THEY STATED COULD DUPLICATE THE PROBLEM. THE PROBLEM WAS DUPLICATED ONCE, AND THE TRANSMISSION MODULE WAS REPLACED. THE CONSUMER HAS GONE THROUGH 1-800- MY- LEMON, AND SINCE THAT, THE DEALERSHIP WAS NOT WILLING TO HELP HER ANYMORE. THE MANUFACTURER WAS CONTACTED, AND THEY ALSO CLAIM ED IT COULD NOT BE T BE DUPLICATED, SO THEY COULD NOT HELP. THERE HAVE BEEN MULTIPLE THINGS WRONG WITH THE VEHICLE; THE GAS GAUGE AND OTHER THINGS. THE CONSUMER DID HAVE THE WORK ORDERS AND COULD SEND IN THAT INFORMATION. THE TRANSMISSION WOULD GO UP TO HIGH RPMS. IT WOULD JERK, AND ALMOST SHUT OFF. IT HAPPED ON STRAIGHT ROADS AS WELL AS HILLS. *AK

NHTSA ID

10130396

Incident

Jul 23, 2003

Mileage

800 mi

DRIVER NOTICED THAT THE TRANSMISSION WOULD DOWN SHIFT ON ITS OWN. DRIVER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TRANSMISSION WAS ADJUSTED ON MORE THAN ONE OCCASION. HOWEVER, DRIVER INFORMED THE MECHANIC THAT THE PROBLEM STILL OCCURRED, AND HAD NOT BEEN RESOLVED. *AK THE CONSUMER STATED THAT THE ENGINE TAKES 2-5 MINUTES FOR IT TO IDLE DOWN FROM 2500 RPM'S. THE CONSUMER STATED THAT THE DEFOSTER ON THE PASSENGER SIDE FAILED. THE CONSUMER STATED THAT THE HOOD WOULD NOT ALWAYS CLOSE PROPERLY.

NHTSA ID

10109636

Incident

Feb 2, 2005

Mileage

303,000 mi

WHILE ON LOCAL INTERSTATE HIGHWAY, THE SATURN ION 3 QUAD COUPE AUTOMATIC TRANSMISSION BEGAN TO SLIP. THE RPMS REACHED ABOUT 6,000 WHILE TRYING TO MAINTAIN THE SPEED AND PULL OVER TO THE RIGHT. AFTER A BRIEF FULL STOP (WHILE IN DRIVE), THE TRANSMISSION ENGAGED PROPERLY AND DID NOT SLIP. UPON TAKING THE NEXT EXIT, THE CAR WAS PLACED INTO PARK AND WAS IDLING. EXITING THE VEHICLE, THERE WAS A STRONG BURNING SMELL WHICH WAS QUITE SIMILAR TO A CLUTCH SLIPPING IN A MANUAL TRANSMISSION. NO FLUIDS WERE SEEN DRIPPING AND THERE WAS NO COSMETIC DAMAGE. THE CAR WOULD NOT RETURN TO DRIVE. DESPITE PRESSING THE BRAKE AS REQUIRED, THE CAR WAS 'LOCKED' INTO PARK. A STRANGE CLICK WAS HEARD FROM THE AREA NEAR THE TRUNK RELEASE BUTTON. THIS WAS DIFFERENT FROM THE NORMAL CLICK THAT IS HEARD WHEN THE BRAKE IS DEPRESSED IN PARK. HE VEHICLE WAS SHUT OFF AND THEN RESTARTED. THE CAR WOULD PROPERLY ENTER DRIVE AND THE ABNORMAL CLICK WAS NOT PRESENT.THE LOCAL SATURN DEALER REPLACED THE "INPUT" AND "OUTPUT" FILTERS IN THE TRANSMISSION PER DIRECTION OF SATURN CORPORATION. TRANSMISSION HAS NOT SLIPPED AGAIN SINCE THIS REPAIR. *AK

NHTSA ID

10105756

Incident

Dec 16, 2004

Mileage

18,000 mi

TRANSMISSION: WHILE DRIVING 25 MPH VEHICLE FROZE. CONSUMER COULD NOT GO BACKWARD OR FORWARD. SHE HAD THIS PROBLEM SEVERAL TIMES IN THE PAST. CONTACTED THE DEALER, BUT THE PROBLEM STILL EXISTS. *AK

NHTSA ID

10103765

Incident

Jul 13, 2003

Mileage

14,000 mi

THE TRANSMISSION ON MY SATURN ION QUAD COUPE INTERMITTENTLY DISENGAGES OR FAILS TO ENGAGE WHEN I STEP ON THE GAS. THIS IS DANGEROUS BECAUSE IF IT DOES NOT ENGAGE WHILE I AM PULLING INTO TRAFFIC I COULD BE HURT. I TOOK IT TO THE DEALER AND THEY SAID THEY COULD NOT DUPLICATE THE CONCERN, BUT ACKNOWLEDGED THERE WAS A PROBLEM WITH THESE TRANSMISSIONS AND A "FIX" WOULD BE OUT SOMETIME IN THE FUTURE. I HAD PREVIOUSLY RECEIVED ON OWNER NOTIFICATION LETTER RE THIS ISSUE (IMPLYING THAT THE TRANSMISSIONS WOULD BE REPLACED IF THERE WAS A PROBLEM.) WHEN I CALLED THE COMPANY TO DISCUSS MY CONCERNS, THE DEALER'S RESPONSE THAT NOTHING COULD BE DONE, AND THE OWNER NOTIFICATION LETTER CONTENTS, THE RESPONSE WAS ESSENTIALLY THAT IF THE DEALER CANNOT DUPLICATE THE CONCERN, THERE IS NO PROBLEM--ESSENTIALLY, THEY SAID SOMETHING BAD HAS TO HAPPEN BEFORE THEY WILL TAKE ACTION, AND THE DEALER DOESN'T HAVE TIME TO DRIVE THE CAR UNTIL THEY CAN DUPLICATE THE CONCERN. I THINK IT'S WRONG AND THEY SHOULD FIX THE PROBLEM. THIS HAPPENS AT LEAST 2X PER DAY, NEVER IN THE SAME PLACE, NO RHYME OR REASON TO IT.*AK

NHTSA ID

10093060

Incident

Sep 21, 2004

Mileage

16,000 mi

CAR HESITATES WITH NO WARNING WHEN TAKING OFF FROM STOP. ALMOST REAR ENDED. ALSO ALMOST STRUCK FROM SIDE IN INTERSECTION.*AK

NHTSA ID

10081019

Incident

Jun 16, 2004

Mileage

4,945 mi

WHEN MAKING TURNS, PARTICULARLY RIGHT TURNS, MY WIFE'S NEW SATURN ION QUAD COUPE, LOSES POWER AND HESITATES AFTER IT GETS THE TURN PARTIALLY COMPLETED. THIS HAPPENS INTERMITTENTLY ABOUT ONCE A WEEK SO IT IS TOUGH TO DUPLICATE BUT IT HAS CAUSED HER TO BE NEARLY HIT SEVERAL TIMES BY ON COMING TRAFFIC. THE DEALERSHIP STATES THIS IS THE WAY THE VTI TRANSMISSION IS DESIGNED TO WORK SO THERE IS NOTHING TO FIX. SATURN IN SPRING HILL DID NOT DENY THIS WAS HOW THE TRANSMISSION WAS DESIGNED TO WORK. I ASKED IF THERE WERE ANY SERVICE BULLETINS THAT WOULD FIX THIS AND THEY SAID NONE WOULD ACTUALLY FIX THIS PROBLEM AND THEY HAD NO IDEA HOW TO FIX IT. THEY ALSO REFUSED TO PROVIDE A WRITTEN RESPONSE TO MY CERTIFIED RETURN RECEIPT LETTER EVEN THOUGH I SPECIFICALLY REQUESTED A WRITTEN RESPONSE. PEOPLE ARE TAKING THEIR CARS TO INDEPENDENT TRANSMISSION SHOPS TO BE FIXED. SATURN IS REIMBURSING SOME OF THESE CHARGES BUT THEY CALL IT STRICTLY A "CUSTOMER SATISFACTION ISSUE". COMPLAINTS 10049664 AND 10049638 SOUND VERY SIMILAR. I WOULD SUGGEST THAT YOU REQUEST THAT SATURN PROVIDE ALL COMPLAINTS FILED WITH THEM ABOUT THE VTI TRANSMISSION, ESPECIALLY WHERE INDEPENDENT SHOPS DID REPAIRS. THOSE OWNERS/INDEPENDENT SHOPS COULD PROBABLY PROVIDE A WEALTH OF INFO ABOUT VTI TRANSMISSION PROBLEMS. I THINK YOU WILL FIND THIS IS A SAFETY PROBLEM AND A RECALL IS WARRANTY. *AK

NHTSA ID

10078453

Incident

Dec 1, 2003

Mileage

100 mi