1996 Saturn Sl Problems

I NOTICED THAT THE TEMPERATURE GAUGE WOULD GO 3/4 TOWARDS THE RED. IF I AM STOPPING AT A LIGHT, THE TEMPERATURE GAUGE KEEP GOING 3/4 TOWARDS THE RED, THEN GOES BACK VERY SLOWLY TO THE MIDDLE. I HAVE BEEN INFORMED THAT I WOULD NEED TO REPLACE MY GASKET. THIS WOULD COST APPROXIMATELY $1,200. *TR

TL*THE CONTACT OWNS A 1996 SATURN SL. THE VEHICLE WAS LEAKING OIL ON THE GROUND AND ALL OVER THE COOLING SYSTEM. THE TEMPERATURE GAUGE KEPT FLUCTUATING INTO THE RED ZONE. THE CHECK ENGINE SOON LIGHT ILLUMINATED INTERMITTENTLY AND THE VEHICLE BEGAN TO DRIVE DIFFERENTLY. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS A CRACKED CYLINDER HEAD. THE COST TO REPAIR THE VEHICLE WAS $2,257. THE CONTACT RECEIVED A SPECIAL POLICY LETTER FROM SATURN IN JUNE OF 1999 CONCERNING A CRACKED CYLINDER HEAD. THE LETTER STATED THAT THERE WAS NO RECALL CAMPAIGN AND IT WAS UNNECESSARY TO TAKE THE VEHICLE TO A DEALER. THE CURRENT MILEAGE WAS 73,000 AND FAILURE MILEAGE WAS 63,000. UPDATED 05/06/08. *LJ UPDATED 05/06/08. *JB

TL* - THE CONTACT WOULD LIKE TO MAKE A COMPLAINT CONCERNING THE BRAKES ON 1996 SATURN SL2. THE CONTACT STATED THAT SHE WAS DRIVING 35 MPH WHEN SHE WAS CUT OFF BY ANOTHER CAR. SHE THEN APPLIED THE BRAKE PEDAL WHICH GAVE NO RESISTANCE. THE CONTACT STATED THAT BEFORE BEING CUT OFF THE BRAKES DID WORK. THE CONTACT STATED THAT THE CAR FINALLY STOPPED AFTER SHE PUMPED THE BRAKES. THE CONTACT CONTINUED TO DRIVE AT APPROXIMATELY 5 MPH UNTIL SHE REACHED HER DESTINATION AND HAD THE CAR TOWED TO A SATURN DEALERSHIP. THE CONTACT STATED THAT THIS BRAKE FAILURE OCCURRED APPROXIMATELY DECEMBER 5, 2006. THE CONTACT STATED THAT IT WAS A NICE DAY, AND THAT THE WEATHER WAS NOT A FACTOR. THE CONTACT PULLED MUSCLES IN HER BODY, AND WAS CURRENTLY ON MUSCLE RELAXANTS. THE CONTACT ASKED THE SATURN DEALER FOR THE DAMAGED PARTS AND WAS TOLD THAT THE PARTS WERE THROWN AWAY. THE CONTACT ALSO STATED THAT SHE HAS HAD PROBLEMS WITH THE BRAKES PULSATING AND GOING ALL THE WAY DOWN TO THE FLOOR SINCE SHE PURCHASED THE CAR. THE CONTACT STATED HAD BRAKE WORK DONE IN 2001 AT 36,000 MILES, THE BRAKE CALIPERS HAD FAILED. THE CONTACT WAS REFERRED TO NHTSA BY THE RHODE ISLAND STATE ATTORNEY'S OFFICE. *AK

I HAVE A 1996 SATURN SL1. ONE DAY I WENT TO PULL UP THE PARKING BRAKE AND FOUND THAT THE LITTLE BUTTON HAD POPPED OFF AND LANDED ON THE DASH, THE SPRING ENDED UP ON THE FLOOR. THE BUTTON IS PLASTIC AND ONE SIDE THAT LATCHED IN TO KEEP IT IN PLACE APPARENTLY BROKE. TO USE THE PARKING BRAKE I WOULD HAVE TO PUT THE SPRING AND BUTTON BACK ON AND ENGAGE THE BRAKE, THEN LET IT POP OFF AGAIN OR JUST TAKE IT OFF. I HAVEN'T BEEN ABLE TO REPLACE IT YET AS I UNDERSTAND THEY DON'T SELL JUST THE PART FOR THE 1996 SATURN. *JB

FIRST PROBLEM IS DOOR CHIMES WITH KEY OUT OF IGNITION. SECOND PROBLEM IS DOME LIGHT STAYS ON IN FRONT OR REAR POSITION WITH ALL DOORS SHUT. THIRD PROBLEM IS NO POWER AT ALL TO THE CAB WHEN I TRIED TO START CAR, AND THEN MY PASSENGER OPENED AND SHUT THE PASSENGER FRONT DOOR AND THE POWER CAME BACK ON AND I WAS ABLE TO START THE CAR. I HAD TO RESET THE CLOCK AND RADIO.

TL* THE CONTACT OWNS A 1996 SATURN SL. THE CONTACT STATED THAT THE IGNITION KEY WAS VERY DIFFICULT TO TURN WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE. THE CONTACT ALSO STATED THAT THE ENGINE WOULD NOT SHUT OFF WHEN THE KEY WAS IN THE IGNITION. THE FAILURE WAS RECURRING OVER A TWO YEAR PERIOD. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM), HOWEVER, THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

DT: THE CONTACT STATED THE GEAR SHIFTER BROKE. SHE HAD IT REPAIRED BY A MECHANIC. THEN, THE SHIFTER BROKE AGAIN. THE CONTACT'S VEHICLE WAS INVOLVED IN AN ACCIDENT AS A RESULT OF THE FAILURE. THE AFOREMENTIONED MECHANIC WAS COMING TO PICK UP THE VEHICLE FOR REPAIRS.*AK

DT: THE CONTACT STATED GEAR SHIFTER BROKE. SHE HAD IT REPAIRED BY A MECHANIC. CURRENTLY, THE SHIFTER BROKE AGAIN. THIS RESULTED THE CONTACT'S VEHICLE BEING INVOLVED IN A CRASH. SHE SPOKE TO A MECHANIC. HE WAS COMING TO GET THE VEHICLE AND REPAIR IT. SHE HAS NOT SPOKEN TO SATURN OR GENERAL MOTORS.*AK

BEGINNING IN 2002 THE REAR DOORS ON 1996 SATURN SL2 BEGAN OPENING SPONTANEOUSLY WHILE DRIVING, FIRST THE PASSENGER SIDE, THEN THE DRIVER SIDE. THEY WOULD NOT RELATCH. WE USED BUNJI CORDS AND THEN FINALLY ROPE THROUGH PARTIALLY OPEN WINDOWS TO KEEP THEM FROM FLYING OPEN AT SPEED. REPEATED OPEN AND SHUTTING AND PLAYING WITH MECHANISM FINALLY GOT THEM TO LATCH AND KEEPING THEM LOCKED SEEMED TO HELP. RECENTLY THE DOOR ON PASSENGER SIDE WAS ACCIDENTALLY OPENED AND WOULD NOT LATCH AGAIN. SAME THING ON DRIVERS SIDE. ALTHOUGH WE GOT THEM LATCHED AND LOCKED AGAIN, NO PASSENGER OR CARGO IS SAFE IN THE BACK SEAT IF THOSE DOORS ARE UNLOCKED OR SOMETIMES EVEN WHEN LOCKED.*AK

UNSATISFACTORY RESPONSES FROM SATURN CUSTOMER SERVICE; REPAIRS THAT SHOULD BE COVERED PER CALIFORNIAS LEMON LAW FOR OUR 1996 SATURN SL1 WITH ONLY 46K MILES. ROTE TO GM & SATURN CEO'S. THEY LIE AND DO NOT STAND BEHIND THEIR CRAPPY PRODUCT. WE WILL NEVER BUY AMERICAN AGAIN!PER MY RECENT CONVERSATIONS WITH SATURN CUSTOMER SERVICE, THERE HAS BEEN ABSOLUTELY NO EFFORT OF GOODWILL TO REIMBURSE AND FIX THE BELOW AFOREMENTIONED MECHANICAL PROBLEMS FROM THE INFERIOR MATERIALS USED IN BUILDING OUR SATURN VEHICLE. THE FAILURES WE NEED REIMBURSEMENT FOR ARE: 1.STARTER REPLACEMENT: $211.08 + 45.17 = $256.25; WE WERE BROKEN DOWN AND HAD TO GET FIXED IMMEDIATELY AT A PEP BOYS SHOP, 2.NEW INTERSTATE BATTERY: $108.15; WE WERE BROKEN DOWN AND HAD TO GET FIXED IMMEDIATELY AT A CHEVRON SHOP, 3.TRANSMISSION GASKET PARTS AND LABOR: $ ~150. (TBD); ALREADY PAID AND IN SATURN DATABASE; TRANS. SEIZED UP NOW AND NEEDS $3000 WORK; SATURN WON'T PAY FOR REPAIRS, 4.ALTERNATOR PARTS AND LABOR: $176.61; WE WERE BROKEN DOWN AND HAD TO GET FIXED IMMEDIATELY AT A PEP BOYS SHOP, THE WORK THAT NEEDS TO BE DONE AT SATURN NOW IS: 5.RADIATOR PARTS AND LABOR (SATURN WORK ORDER ESTIMATE SO# 123412): $417.16 6.OIL GASKET PARTS AND LABOR (SATURN WORK ORDER ESTIMATE SO# 126859): $ TBD 7.REPEAT TRANSMISSION SERVICE AND GASKET PARTS AND LABOR (SATURN WORK ORDER ESTIMATE SO# 126859): $ TBD, THIS HAS ALREADY BEEN DONE 18 MONTHS AGO AND IS LEAKING AGAIN! ALSO COMPLETE REBUILD/ $3000.8.FRONT PASSENGER SEAT RECLINING MECHANISM NEEDS REPAIR. *AK

TL* THE CONTACT OWNS A 1996 SATURN SL. WHILE MAKING A RIGHT TURN AT 20 MPH, THE STEERING WHEEL TURNED RIGHT AND LEFT INDEPENDENTLY. AS A RESULT, THE CONTACT CRASHED INTO THE REAR DRIVER SIDE OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED MUSCULAR PAIN THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 97V138000 (STEERING); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 166,000.

TL* THE CONTACT OWNS A 1996 SATURN SL. THE CONTACT STATED THAT THE IGNITION KEY WAS VERY DIFFICULT TO TURN WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE. THE CONTACT ALSO STATED THAT THE ENGINE WOULD NOT SHUT OFF WHEN THE KEY WAS IN THE IGNITION. THE FAILURE WAS RECURRING OVER A TWO YEAR PERIOD. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM), HOWEVER, THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNS A 1996 SATURN SL. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED AND THE HORN BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CLOCK SPRING AND THE MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN.

I WAS IN A BROAD SIDE COLLISION (T-BONE) TYPE ACCIDENT WHERE I HIT ANOTHER DRIVER AFTER SHE TURNED IN FRONT OF ME CAUSING THIS COLLISION AND NO AIR BAGS DEPLOYED MY SEATBELT LOCKED CAUSING ME TO HAVE SEVERE NERVE DAMAGE IN MY NECK ON THE LEFT SIDE, MY LEFT LEG NOW HAS INJURY FROM THIS ACCIDENT NEEDLESS TO SAY I WILL HAVE THIS LIFELONG PROBLEM STEMMING FROM THIS ACCIDENT. *TR

TL*THE CONTACT OWNS A 1996 SATURN SL2. WHILE DRIVING LESS THAN 10 MPH AND ENGAGING THE BRAKE PEDAL THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. IN ORDER TO STOP THE ACCELERATION, THE CONTACT HAD SHIFT INTO NEUTRAL GEAR AND TURN THE VEHICLE OFF. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT HAD THE COOLANT TEMPERATURE SENSOR HARNESS REPLACED. THERE WERE NO PRIOR WARNINGS. THE FAILURE MILEAGE WAS 76,824. UPDATED 02/17/10. *LJ UPDATED 02/18/10

WHEN TRYING TO RESET THE CRUISE CONTROL ACCELERATOR PEDAL WENT DOWN TO THE FLOOR, CAUSING THE VEHICLE TO ACCELERATE UP TO 70 MPH. AFTER A COUPLE OF SECONDS ACCELERATOR PEDAL POPPED UP, AND THE VEHICLE BEGAN TO SLOW DOWN. *AK *PH

CONSUMER HAS A COMPLAINT ON THE SLANTED WINDSHIELDS CAUSING A BLINDING REFLECTION ON THE COMPONENTS ON THE DASH. *JG

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

REAR LIGHTS KEPT GOING OUT - SATURN DEALER SAID THE ELECTRICAL SYSTEM HAD BEEN BUTT-SPLICED. SINCE ONLY SATURN WORKED ON THE VEHICLE, THIS WAS UNEXPLAINABLE. IT SEEMS, HOWEVER, MY CAR IS NOT THE ONLY ONE WITH THIS PROBLEM. APPARENTLY, THE BUTT-SPLICING IS BEING DONE BY SATURN AND BEING BLAMED ON THE CONSUMER -- AND CHARGED TO THE CONSUMER. I DISCOVERED THIS PROBLEM AFTER BEING STOPPED BY THE POLICE, TWICE.*AK

WEATHER STRIPING TO VEHICLE IS DEFECTIVE. WHEN THERE IS RAIN VEHICLE FILLS UP WITH WATER IN REAR. *AK

WHILE DRIVING 65 MPH REAR PASSENGER'S SIDE TIRE TREAD SEPARATED. AS A RESULT THE REAR QUARTER PANEL AND BUMPER WERE SEVERELY DAMAGED. NO IMPACT REPORTED. *AK *NM

MY TIRE BLEW OUT WHILE DRIVING FROM LONG BEACH, CA. TO PHOENIX, AZ. WHICH IS ABOUT SIX HOURS AWAY. ABOUT AN HOUR OUTSIDE OF PHOENIX MY TIRE BLEW OUT. I LOST CONTROL OF THE CAR AND IT WENT OFF THE ROAD AND ROLLED 2 - 3 TIMES. I EXPERIENCED MINOR INJURIES TO MY HEAD AND OTHER PLACES ON MY BODY. I ALSO EXPERIENCED WHIPLASH THAT AFFECTED MY MEMORY AND CONCENTRATION.*AK

ON HIS WAY TO WORK ON SEPT. 16, 2008, MY BOYFRIEND HEARD A STRANGE SOUND AND THEN LOST USE OF 2,4,R GEARS. IN MORNING RUSH HOUR TRAFFIC ON US 1, HE CONTINUED TO WORK WITH THE USE OF 1,3 GEARS. WE TROUBLESHOOT ONLINE AND THROUGH FRIENDS WITH MECHANICAL EXPERIENCE AND TEMPORARILY USED A ZIP TIE CONFIRMING THAT THE DEFECTIVE PART WAS THE SHIFT CABLE BUSHING. LOCAL STORES DO NOT CARRY THE PART AS IT IS CARRIED BY DEALER ONLY. SATURN DOES NOT SELL THE PART WITHOUT THE ENTIRE ASSEMBLY (MANUAL TRANSMISSION SHIFT CABLE BUSHING WITH CLIP PART # 14043) AND HAS PRICED WITHOUT INSTALLATION AT $198.00. THE PARTS MANAGER DID NOT EVEN ASK ME FOR THE MODEL, SAID HE HAS PLENTY IN STOCK AND THAT THERE IS A MINIMUM 3 HOUR INSTALLATION WITH LABOR PRICED AT $95/HR. HE ALSO STATED THAT AS THIS IS A COMMON DEFECT HE HAS KNOWN OF PEOPLE TO USE ZIP TIES AND THEIR OWN NUT/BOLT SYSTEM TO REMEDY. UPON FURTHER INTERNET RESEARCH I HAVE FOUND THOUSANDS OF COMPLAINTS FOR THE SAME EXACT PROBLEM, SOME OWNERS WITH UNFORTUNATE OUTCOMES. IT IS A BLESSING THAT I WAS NOT DRIVING THAT DAY WITH MY 2 YOUNG CHILDREN, AS I PROBABLY WOULD HAVE LOST CONTROL OF THE VEHICLE! IT IS AMAZING TO ME THAT SATURN HAS BEEN ALLOWED TO SELL SUCH DANGEROUS VEHICLES WITH NO RECALL! MORE HORRIFYING IS THAT I FOUND THE PART AT NAPA AUTO PARTS FOR $19.95 AND SATURN INSISTS ON SELLING THE ENTIRE ASSEMBLY TAKING ADVANTAGE OF PEOPLE WHO JUST DON'T KNOW BETTER. THIS REEKS OF SCAM TO THE CRIMINAL LEVEL!!!!!!! *TR

ENGINE CUT OFF, ENGINE SURGED,TACHOMETER BOUCES,REPLACED VALVE GUIDES AT 60000 MILES, COMPRESION STILL NOT CORRECT, CK ENGINE LIGHT ALWAYS COMES ON, BURNS OIL, 2 QTS MORE THAN SPECS SAY. SEAT BELT LIGHT STAYS ON EVEN WHEN IN USE.

1996 SATURN SL2, A VEHICLE DEFECT CAUSED THE DRIVER TO LOSE CONTROL AND STRIKE THE CONCRETE BARRIER. *BF THE LEFT FRONT STRUT BROKE WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. THE DRIVER SUFFERED MINOR INJURIES. (OHIO TRAFFIC CRASH REPORT # 10-0304-91)*JB UPDATED 08/05/10 *BF

1. HIGH REVVING ON IDLE MANUAL TRANS 2. FRONT END NOISE MANUAL TRANS P/S SIMILAR TO OTHER RECALL WORN OUT ? *NM

THE FUEL LINE IN THIS CAR IS EXPOSED AT THE BOTTOM OF THE CAR, AND TWICE NOW (ON 11/3/05 AND EARLIER IN 12/2003) THE FUEL LINE HAS RIPPED AND GASOLINE HAS SPILLED ONTO THE GROUND WHEN TRYING TO START THE CAR. THE GASOLINE SPILL OBVIOUSLY CREATES A SAFETY HAZARD. *NM

DRIVE BELT AND SERPENTINE BELT FAILED, VALVE BODY COVER AND GASKET WERE REPLACED. *YH

NO SUMMARY

SHOULDER SEATBELT ON DRIVER SIDE WILL NOT RETRACT , CAUSING A LOSS OF PROTECTION. CONSUMER HAS CONTACTED DEALER. *AK.

WHEN DIMMING HEADLIGHTS AT NIGHT WITH ON OFF SWITCH AND DIMMER SWITCH ON SAME SWITCH EASY TO SHUT LIGHT OFF AT HIGH SPEEDS AND OPOSING TRAFFIC UNABLE TO SEE YOU AND WITH ALL INTERIOR LIGHT NOW SHUT OFF AT 55 MPH YOU ARE TRYING TO FIGURE OUT WHAT HAPPENED AND WATCH TRAFFIC AND GET LIGHTS BACK ON

VENTILLATION SYSTEM BLOW AIR THAT SMELLS AND CONTAINS MOLD.

THE FUEL LINE IN THIS CAR IS EXPOSED AT THE BOTTOM OF THE CAR, AND TWICE NOW (ON 11/3/05 AND EARLIER IN 12/2003) THE FUEL LINE HAS RIPPED AND GASOLINE HAS SPILLED ONTO THE GROUND WHEN TRYING TO START THE CAR. THE GASOLINE SPILL OBVIOUSLY CREATES A SAFETY HAZARD. *NM

I OWN A 1996 SATURN SL1 THAT I PURCHASED USED IN DECEMBER OF 2000. I HAVE BEEN HAVING PROBLEMS WITH MY HORN SINCE I BOUGHT IT. I HAVE HAD TO HAVE IT SERVICED TWICE AND THE HORN IS BROKEN FOR A THIRD TIME. I REPLACED A FUSE IN SPRING 2001, BECAUSE IT WENT OUT. IN DECEMBER OF 2002 THE HORN WENT OUT AGAIN, SO IN MAY OF 2003 HAD THE DEALER REPLACE THE ENTIRE HORN ASSEMBLY. THIS LASTED UNTIL OCTOBER OF 2003 WHEN MY HORN STARTED GOING OFF WILDLY IN THE MIDDLE OF THE NIGHT, CAUSING THE LOCAL POLICE TO RESPOND AND GIVE ME A WARNING FOR A NOISE VIOLATION. IN THE STATE OF LOUISIANA I AM REQUIRED TO HAVE AN OPERATIONAL HORN TO GET MY VEHICLE INSPECTED, WHICH IS CURRENTLY COSTING ME AN $66/YEAR IN REPLACEMENT. THIS SHOULD NOT BE CONSIDERED REGULAR MAINTENANCE. I WAS LOOKING ON THE INTERNET FOR PARTS TO FIX MY HORN AGAIN, WHEN I CAME ACROSS A RECALL NHTSA: 98V-307, GM RECALL: 98C301. THIS APPLIES ONLY TO THE SW MODELS OF THE 1996 SATURN LINE. WHY DOES THIS ONLY APPLY TO THIS MODEL? THE EQUIPMENT AND THE CONFIGURATION ARE ALMOST IDENTICAL, AND YOU WOULD NOT BELIEVE HOW MANY PEOPLE HAVE HAD PROBLEMS WITH THIS SPECIFIC COMPLAINT. *JB

VENTILLATION SYSTEM BLOW AIR THAT SMELLS AND CONTAINS MOLD.

IGNITION KEY STICKING.