2005 Spartan K2 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Spartan K2, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure125.0%
- Engine125.0%
- Steering125.0%
- Visibility125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 SPARTAN K2. THE CONTACT STATED THAT THE SIDE RADIATOR MOUNTED FRAMEWORK HAD BECOME STRUCTURALLY DISCONNECTED, WHICH IMPACTED A LOOSE CONNECTION OF THE SAND BLADE. AS A RESULT, THE SIDE RADIATOR HOUSING WAS FRACTURED, WHICH IMPACTED THE SAND BLADE, HOUSING UNIT, AND OTHER COMPONENTS. THE VEHICLE HAD NOT BEEN SERVICED BY THE MANUFACTURER'S AUTHORIZED FACILITY. THE CONTACT CALLED SEVERAL TIMES AND ALSO LEFT MESSAGES WITH THE MANUFACTURER. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE SIDE RADIATOR HOUSING UNIT NEEDED TO BE REPLACED. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 SPARTAN K2. THE CONTACT STATED THAT THE SIDE RADIATOR MOUNTED FRAMEWORK HAD BECOME STRUCTURALLY DISCONNECTED, WHICH IMPACTED A LOOSE CONNECTION OF THE SAND BLADE. AS A RESULT, THE SIDE RADIATOR HOUSING WAS FRACTURED, WHICH IMPACTED THE SAND BLADE, HOUSING UNIT, AND OTHER COMPONENTS. THE VEHICLE HAD NOT BEEN SERVICED BY THE MANUFACTURER'S AUTHORIZED FACILITY. THE CONTACT CALLED SEVERAL TIMES AND ALSO LEFT MESSAGES WITH THE MANUFACTURER. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE SIDE RADIATOR HOUSING UNIT NEEDED TO BE REPLACED. THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
THERE HAVE BEEN TWO SPARTAN K2 RECALLS ON STEERING RELATED ISSUES ON 2005 UNITS.05V283000 AND 07V300000 THESE ARE DEFECTS IN STEERING LINKAGE AND SPACERS THAT CAN CAUSE STEERING FAILURE. I AM TOLD BY SPARTAN THAT MY K2 IS NOT AFFECTED BY THE RECALLS. HOWEVER, MY UNIT HAS HAD A STEERING DEFECT SINCE DAY ONE. WHEN MAKING TURNS THERE IS OFTEN A LOUD BANG SOUNDS LIKE A BALL JOINT IS BAD. THEY FIRST TOLD ME IT WAS THE TIE ROD U BOLTS ON UPSIDE DOWN. CORRECTING DID NOT STOP THE LOUD BANG. THEY THEN TOLD ME IT WAS THE IFS AND THEY REPLACED A BELL CRANK ASSEMBLY IN IT. THE NOISE CONTINUED AND HAS BECOME MORE PRONOUNCED AND OCCURS MORE OFTEN AND IN LESS TURNING RADIUS. THEY HAVE TOLD ME THEY DO NOT KNOW WHAT THE CAUSE IS BUT THEY ARE SURE IT IS 100% SAFE SINCE IT HAS NOT YET CAUSED A CRASH OR INJURY TO ME OR OTHERS. THEY REFUSE TO MAKE ANY EFFORT TO DETERMINE THE CAUSE OF THE SOUND. I BELIEVE IT IS UNSAFE AND I AM AFRAID TO DRIVE IT. I BELIEVE THERE IS METAL FATIGUE OCCURRING WITH EACH LOUD POP AND THAT EVENTUALLY THE STEERING WILL FAIL AND CONTROL OF A ALMOST 50,000 LB COACH WILL BE LOST. YOU CAN EXPERIENCE A DEMO OF THIS DEFECT BY GOING TO THIS LINK TO A VIDEO POSTED ON GOOGLE. HTTP://VIDEO.GOOGLE.COM/VIDEOPLAY?DOCID=-8114109860308362131&HL=EN. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
DURING DRIVING, PASSENGER SIDE WINDSHIELD POPPED LOOSE AT AREA OF UPPER CORNER, EVENTUALLY CRACKING. MANUFACTURER OF MOTOR HOME HAD IT PICKED UP AND RETURNED TO THE FACTORY. THEY CLAIMED TO HAVE REPLACED TOTAL FRONT CAP, KEPT IT OVER 4 MONTHS, HAD IT RETURNED, IMMEDIATELY UPON RETURN, BEFORE, I COULD TAKE ANOTHER TRIP, BOTH FRONT WINDSHIELDS CRACKED AND WERE POPPING OUT. HAD IT REPAIRED AT A RV DEALER THAT THEY APPROVED. TOOK ANOTHER TRIP AND WINDSHIELD ON PASSENGER SIDE SETTLED AND LEFT A SLIT BETWEEN WINDSHIELD AND WINDSHIELD GASKET. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .