RoadVitals

1995 Spartan Mountain Master Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Newest Nov 25, 1996
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

4 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

96V201000

VEHICLE SPEED CONTROL

Nov 25, 1996
7,633 units potentially affected
The defect: THE ECO-CRUISE ACTUATOR CAN BIND THE THROTTLE.
The risk: IF THE ACTUATOR BINDS, ENGINE SPEED MAY NOT DECREASE TO THE LEVEL ANTICIPATED BY THE OPERATOR, INCREASING THE RISK OF A VEHICLE ACCIDENT.
The remedy: DEALERS WILL REMOVE THESE ACTUATORS UNTIL NEW OR REMANUFACTURED UNITS CAN BE SUPPLIED.
SPARTAN MOTORS, INC.View on NHTSA.gov
96V072000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

May 1, 1996
741 units potentially affected
The defect: THESE SOLENOIDS CAN FAIL TO OPERATE OR PASS CURRENT. THESE SOLENOIDS ARE USED TO TURN THE POWER TO THE IGNITION BUS BAR(S) ON THE POWER PANEL(S) ON AND OFF.
The risk: FAILURE OF A SOLENOID WILL CAUSE THE SET OF CONTROLLED DEVICES NOT TO FUNCTION. SOME OF THESE DEVICES ARE: CRUISE CONTROL, BACK-UP LAMP, ANTI-LOCK BRAKE ELECTR0NIC CONTROL UNIT POWER; TURN SIGNALS; HEATER/ DEFROSTER, AND/OR WINDSHIELD WIPERS.
The remedy: DEALERS WILL REPLACE THESE DEFECTIVE SOLENOIDS WITH AN "AUTOMOTIVE CONTROLS COMPANY" SOLENOID.
SPARTAN MOTORS, INC.View on NHTSA.gov
96V014000

STEERING: STEERING WHEEL/HANDLE BAR

Jan 23, 1996
358 units potentially affected
The defect: INTERMITTENT DISRUPTION OF THE FUNCTIONS CONTROLLED BY THE STEERING WHEEL CENTER TOUCH PAD CAN OCCUR CAUSED BY ELECTRICAL SHORTAGE INSIDE THE STEERING WHEEL ASSEMBLY. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 104, "WINDHSIELD WIPING AND WASHING SYSTEMS;" AND NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT."
The risk: CONSEQUENCE OF NON-COMPLIANCE: THIS CONDITION CAN CAUSE IMPROPER OPERATION OF THE FUNCTIONS CONTROLLED BY THE TOUCH PAD. THE FUNCTION (1) FAILS TO OPERATE; (2) OPERATES INTERMITTENTLY; OR (3) OPERATES UNEXPECTEDLY, I.E. A FUNCTION COMES ON WITHOUT BEING SWITCHED ON. ANY OF THESE COULD DISTRACT A DRIVER INCREASING THE POTENTIAL FOR AN ACCIDENT.
The remedy: DEALERS WILL REPAIR THE STEERING WHEEL CENTER CONTROL ASSEMBLIES TO ELIMINATE THE ELECTRICAL SHORTING.
SPARTAN MOTORS, INC.View on NHTSA.gov
95V064000

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Mar 27, 1995
1,166 units potentially affected
The defect: WHEN IN OPERATION, THE PRE-HEATER REQUIRES GOOD ENGINE GROUND. HOWEVER, THE ALTERNATORS ARE NOT GROUNDED THROUGH THE CASE, LIMITING THE GROUND FOR ENGINE ELECTRICAL COMPONENTS. THE PRE-HEATER AMPERAGE CAN THEN GROUND TO THE STEEL BRAIDED AIR COMPRESSOR HOSE WHICH IS SECURED IN A RUBBER LINED CLIP. IN SOME CIRCUMSTANCES, THE CLIP CAN CONTACT THE FRAME RAIL CAUSING AN ARC.
The risk: THIS CONDITION CAN CAUSE A HOLE TO BE BURNED THROUGH THE AIR LINE, PREVENTING THE AIR COMPRESSOR FROM DELIVERING SUFFICIENT AIR PRESSURE TO THE BRAKING SYSTEM REDUCING BRAKE CAPABILITY AND INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The remedy: DEALERS WILL INSTALL A 6 GAUGE GROUND CABLE BETWEEN THE ENGINE AND THE EXISTING STARTER GROUND CABLE LOCATED INSIDE THE FRAME RAIL.
SPARTAN MOTORS, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .