RoadVitals

2003 Sprinter 3500 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jan 20, 2013
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Sprinter 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Seat belts150.0%
  • Tires & wheels150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Seat belts

Reports naming seat belts, buckles, retractors and pretensioners.

1
report

From owner reports, verbatim

PASSENGER SEAT BELT KEPT LOCKING WHILE VAN WAS MOVING AND THEN WOULD NOT RETRACT AT ALL. DRIVER SIDE RETRACTS BUT VERY SLOWLY. *TR

NHTSA ID 10493560 · filed Jan 20, 2013

Too few reports in this category for a page of its own — they appear in the full complaint list.

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

1
report

From owner reports, verbatim

2003 SPRINTER 3500 SHC, UNIT 1 AND UNIT 2 WERE WESTBOUND ON THE TURNPIKE WHEN A SET OF DUAL TIRES CAME OFF UNIT 1 AND STRUCK UNIT 2. BOTH UNITS SUBSEQUENTLY PULL OVER ON THE NORTH SHOULDER. *BF THE LEFT REAR DUALS SHEERED OFF THE HUB. (OHIO TRAFFIC CRASH REPORT # 10-0062-89)*JB UPDATED 03/29/11 *BF

NHTSA ID 10393173 · filed Mar 21, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .