1998 Subaru Forester Problems

1. WHEEL BEARINGS HAVE CONSISTENTLY NEEDED REPLACEMENT STARTING 4 YEARS AFTER CAR PURCHASED NEW. AT 450.00 TO 500.00 EACH TIME. THIS IS A DESIGN ISSUES AND SUBARU NEEDS TO PAY OF EACH REPLACEMENT. 2. FUEL LINE LEAK. THIS IS VERY DANGEROUS AND AGAIN LISTED MANY MANY TIME ON ALL SUBARU FIX WEB SITES. COST TO FIX 1600.00 AND MORE IF FUEL TANK NEEDS REPLACING. AGAIN, SUBARU NEEDS TO DEAL WITH THIS. THESE HAVE BEEN HAPPENING SINCE CAR PURCHASED. CAR HAS BEEN WELL MAINTAINED SINCE PURCHASE.

INCREASING GRINDING NOISE FROM REAR OF CAR; DEALER INSPECTED AND FOUND FAILING RIGHT REAL WHEEL BEARING; REPAIR FOUND FAILED SEAL ON AXLE; ONE CONTROL ARM REPLACED ALONG WITH AXLE AND BEARING. *TR

DEALER RESEALED OIL PUMP DUE TO AN OIL LEAK, CONSUMER WAS LATER INFORMED THAT ENGINE WAS IN BEGINNING STAGES OF POSSIBLE FAILURE. *YH

VEHICLE EXPERIENCED AN ENGINE NOISE AND ODOR, DEALER ADVISED THAT BEGINNING STAGES OF POWER TRAIN FAILURE WAS OCCURRING. *SLC

TL* THE CONTACT OWNS A 1998 SUBARU FORESTER. THE CONTACT STATED THAT THE SERVICE ENGINE INDICATOR ILLUMINATED AND THE ENGINE REVVED UP AND DOWN. THE VEHICLE WOULD NEED TO ACCELERATE IN ORDER TO REV DOWN. AN INDEPENDENT MECHANIC STATED THAT THE FAILURE MAY BE DUE TO THE OXYGEN SENSOR OR THE CATALYTIC CONVERTER. THE CONTACT CALLED LIBERTY AUTO CITY (1000 E PARK AVE, LIBERTYVILLE, IL 60048, (847) 362-2683) AND WAS INFORMED THAT THERE WERE NO RECALLS. THE MANUFACTURER PROVIDED THE CONTACT WITH A CASE NUMBER. THE FAILURE MILEAGE WAS 120,000.

1998 SUBARU FORESTER. CONSUMER STATES THAT WHILE DRIVING SHE HEARD A LOUD NOISE, PULLED OVER TO INSPECT THE VEHICLE IT WAS ON FIRE. *MC THE CONSUMER REPLACED THE KNOCK SENSOR 30 DAYS PRIOR. (OHIO TRAFFIC CRASH REPORT). *JB

MY 1998 SUBARA FORESTER WENT INTO A "SUDDEN ACCELERATION". LUCKILY, NO ONE WAS KILLED, BUT THE CAR SUSTAINED SIGNIFICANT DAMAGE. *TR

DT*: THE CONTACT STATED THE VEHICLE ACCELERATED WHILE PARKED. THE VEHICLE WENT THROUGH A FENCE AND HIT SOME BRUSH. THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE. TWO WEEKS PRIOR TO THE INCIDENT THE CONTACT SMELLED SOMETHING BURNING. THE HEATER WOULD NOT WORK PROPERLY. THE VEHICLE WAS TAKEN TO A DEALERSHIP. THE THERMOSTAT WAS REPLACED. THERE WAS NOT A POLICE REPORT FILED. UPDATED 3/28/2006 - *NM

CLUTCH CHATTERS BADLY AND CLUTCH DOES NOT ENGAGE UNTIL THE PEDAL IS ALMOST FULLY DEPRESSED WHEN VEHICLE SITS OVERNIGHT. PROBLEM SEEMS MORE PRONOUNCED IN COLDER WEATHER, BUT OCCURS IN ALL WEATHER CONDITIONS. IN ADDITION TO CAUSING AN UNSAFE DRIVING SITUATION, THE CONDITION MAY CAUSE FIRST AND REVERSE GEARS TO GRIND WHEN SELECTING THESE GEARS FROM A STOP. AFTER DRIVING A FEW MILES THE PROBLEM GOES AWAY AND THE CLUTCH OPERATES NORMALLY. THE PROBLEM HAS BEEN REPORTED TO SUBARU REPAIR SHOPS NUMEROUS TIMES, INCLUDING AT 33,220; 59,451; 74,213; AND 92,380 MILES. THE SUBARU REPAIR SHOPS CAN USUALLY DUPLICATE THE CHATTER, BUT THEY HAVE NEVER BEEN ABLE TO DUPLICATE THE CLUTCH ENGAGING ONLY AFTER BEING ALMOST COMPLETELY DEPRESSED. AT 92,380 MILES THE VEHICLE WAS DRIVEN ONLY 1.5 MILES IN THE MORNING TO THE SUBARU REPAIR SHOP WITH THE POOR CLUTCH ENGAGEMENT STILL OCCURRING, AND THE SUBARU REPAIR SHOP SAID THEY STILL COULD NOT DUPLICATE THE PROBLEM. THE ENTIRE CLUTCH ASSEMBLY WAS REMOVED AND REPAIRED SHORTLY AFTER THE 33,220 MILE SERVICE COMPLAINT AT SUBARUS EXPENSE, BUT THE PROBLEM RETURNED WITHIN A FEW THOUSAND MILES. THIS APPEARS TO BE A COMMON PROBLEM FOR SUBARU FORESTERS, AND POSSIBLY OTHER MANUAL TRANSMISSION SUBARUS (FOR PLE, ://FORUMS.VMAG.COM/SUVSUBARU0200/MESSAGES/5197.HTML).*AK

CONSUMER WAS PARKING ON AN UPGRADE. CONSUMER STATED THAT THEY PUT VEHICLE IN PARK ATTEMPTED TO EXIT WHEN VEHICLE BEGAN TO ROLL BACKWARDS. CONSUMER APPLIED BRAKES, PEDAL WENT TO THE FLOOR. WHICH RESULTED IN VEHICLE CROSSING A RESIDENTIAL STREET AND STOPPING IN SOMEONES YARD. CONSUMER FEELS THIS WAS VERY DANGEROUS, SOMEONE COULD HAVE BEEN HIT. PLEASE PROVIDE ANY FURTHER INFORMATION.

VEHICLE EXPERIENCED AN ENGINE NOISE AND ODOR, DEALER ADVISED THAT BEGINNING STAGES OF POWER TRAIN FAILURE WAS OCCURRING. *SLC

DUE TO DEFECTIVE WHEEL BEARING WHICH WENT BAD,. PROBLEM HAPPENED 5 TIMES. DEALER COULD NOT DETERMINE THE CAUSE. *AK RIGHT REAR WHEEL BEARINGS MAKES A LOUD NOISE AT LAST FAILED AND SMOKE CAME OUT OF THE WHEEL. *YH

MY 98 FORESTER HAD THE RIGHT REAR BEARING CHANGED 3 TIMES BY NON DEALER CHAIN. STARTED MAKING NOISE AGAIN. WHEN I WENT TO SUBARU, THE MECHANIC TOLD ME THAT IT'S COMMON. HE HAS BEEN REPLACING THEM WITH LEGACY BEARINGS AND HAS NOT HAD ANY COMPLAINTS. ALSO THE VENT ON TOP OF REAR DIFFERENTIAL BLOWS OR SWEATS DIFF FLUID OUT ONTO DIFFERENTIAL. POTENTIAL FOR FREEZE UP OF DIFFERENTIAL ONCE ALL FLUID IS GONE. MECHANIC CLAIMS HE WOULD HAVE TO OPEN DIFFERENTIAL AND "NOTCH" SOME METAL GUARD IN THERE TO PREVENT THIS. THIS ALONG WITH BEARINGS-$600. *TR

1998 SUBARU FORESTER'S TIRE BLEW OUT. *TS WHEN THE TIRE BLEWOUT IT CAUSED THE VEHICLE TO GO OFF THE ROADWAY AND STRIKE A CONSTRUCTION CONE, DELINEATOR POST AND SOUTH DITCH. THE VEHICLE LEFT REAR QUARTER PANEL, TAILLIGHT AND BUMPER WERE DAMAGED. THERE WERE NO INJURIES. *NM

WHILE RIDING ON HIGHWAY PEBBLES HIT WINDSHIELD CAUSING IT TO BREAK. *AK

AFTER OWNING THE FORESTER JUST 3 MONTHS, THE WINDSHIELD HAD THREE CHIPS IN IT WHICH THEN SPREAD INTO A CRACK ACROSS THE DRIVER'S VIEWING AREA. AFTER ONLY 21,000 MILES THE CLUTCH DISC/PLATE HAD TO BE REPLACED AND WAS NOT A WARRANTY MATTER. AFTER 42,000 MILES A BEARING IN THE REAR AXLE HAS GONE BAD AND THE CLUTCH IS BEGINNING TO MAKE THE SAME NOISE FOR WHICH IT HAD TO BE REPLACED EARLIER. I AM MOST DISAPPOINTED IN THIS VEHICLE.000 MILES,000 MILES THE

MY SPOUSE HAD A MINOR ACCIDENT WITH OUR 1998 SUBARU FORESTER. THE FRONTAL IMPACT CAUSED BOTH AIR BAGS TO DEPLOY. THE PASSENGER SIDE AIR BAG WHEN IT DEPLOYED BROKE THE FRONT RIGHT SIDE (PASSENGER SIDE) DOOR WINDOW AND THE REAR VIEW MIRROR. NO ONE WAS SEATING IN THE FRONT PASSENGER SEAT. I BELIEVE THIS IS A DEFECT THAT MAY BE A RESULT OF THE AIR BAG IMPROPERLY INSTALLED OR ALIGNED. *NLM

AIRBAG LIGHT CAME ON. DEALER REPLACED CLOCKSPRING ASSEMBLY.*AK

MY 1998 SUBARU FORESTER HESITATES ON ACCELERATION IN THE LOW RPM RANGE. ONCE OVER ABOUT 3000 RPM, IT RUNS FINE. ACCORDING TO A TECHNICAL SERVICE BULLETIN RELEASED BY SUBARU IN JAN 1999, #11-53-98, THIS IS CAUSED BY THE ENGINE CONTROL MODULE INCORRECTLY INTERPRETING VIBRATIONS IN THE ENGINE AS SKIPPING AND READJUSTING THE FUEL FLOW RATE. THE FIX REQUIRES INSTALLING AN UPGRADED ECM--TO THE TUNE OF WELL OVER $1000. THIS HESITATION PRODUCES AN UNSAFE SITUATION BECAUSE THE CAR MAY AT ANY TIME REFUSE TO ACCELERATE, OR ACCELERATE SUDDENLY WITHOUT WARNING.*AK

WHEN VEHICLE WAS TURNED ON IT SUDDENLY ACCELERATED BACKWARDS VERY FAST, CRASHING INTO TWO VEHICLES. CONSUMER HAS CONTACTED DEALER. CAUSE OF THE PROBLEM HAS YET TO BE DETERMINED. *AK WHILE VEHICLE WAS IN PARK AND CONSUMER HAD FOOT ON THE BRAKE AND TURNED ON IGNITION THE VEHICLE ACCELERATED VERY FAST IN REVERSE AND CAUSED ACCIDENT, CONSUMER IS ALSO HAVING VARIOUS ELECTRICAL PROBLEMS WITH THE VEHICLE, SUCH AS THE BATTERY DRAINING, SECURITY SYSTEM GOES OFF WHILE PARKED, AND THE DOORS LOCK BY THEMSELVES. *YD

1. WHEEL BEARINGS HAVE CONSISTENTLY NEEDED REPLACEMENT STARTING 4 YEARS AFTER CAR PURCHASED NEW. AT 450.00 TO 500.00 EACH TIME. THIS IS A DESIGN ISSUES AND SUBARU NEEDS TO PAY OF EACH REPLACEMENT. 2. FUEL LINE LEAK. THIS IS VERY DANGEROUS AND AGAIN LISTED MANY MANY TIME ON ALL SUBARU FIX WEB SITES. COST TO FIX 1600.00 AND MORE IF FUEL TANK NEEDS REPLACING. AGAIN, SUBARU NEEDS TO DEAL WITH THIS. THESE HAVE BEEN HAPPENING SINCE CAR PURCHASED. CAR HAS BEEN WELL MAINTAINED SINCE PURCHASE.

WHEN AT THE GAS STATIONS I TRY TO PUT GAS INTO MY CAR, IT IS NOT GOING INTO THE TANK PROPERLY, IT KEEPS SHUTTING THE GAS NOZZLE OFF WITHIN SECONDS. VERY HARD TO PUT GAS INTO MY CAR.

KAZOO NOISE IN FRONT SINCE 31K, BECAME RATCHET NOISE AT 52K. RACK AND PINION ADJUSTMENT STOPPED NOISE BUT STEERING IS SLOPPY AND PULLS TO RIGHT SOMETIMES.

A FIRE STARTED WITHIN THE ENGINE COMPARTMENT OF THE VEHICLE DUE TO A FAULTY POWER STEERING HOSE. PLEASE GIVE ANY FURTHER DETAILS. *AK

MY PARENTS RECENTLY GAVE MY DAUGHTER A 1998 SUBARU FORESTER AND SHE IS HAVING PROBLEMS GETTING THE BABY'S CARSEAT TO TIGHTEN DOWN PROPERLY. I EMAILED SUBARU ABOUT THIS PROBLEM AND THEY SUGGESTED USING A ROLLED TOWEL TO FILL THE VOID AND MAKE IT TIGHTER. SHE HAS TAKEN THE CAR TO SERVERAL DEALERSHIPS AND THEY SAY THEY KNOW OF NO PROBLEMS. IS THE ROLLED TOWEL SAFE TO USE? SHE MAKES SURE THAT HER CARSEAT IS PROPERLY INSTALLED, EVEN PURCHASING A RATCHETING SYSTEM TO TIGHTEN. WE ARE VERY CONCERNED ABOUT THIS, EVEN TO THE POINT OF SELLING THE CAR.*AK

UNABLE TO FIT CHILD CAR SEAT IN TO BACK SEAT BECAUSE OF SEAT BELT POSITIONING/DESIGN. YH

MY SPOUSE HAD A MINOR ACCIDENT WITH OUR 1998 SUBARU FORESTER. THE FRONTAL IMPACT CAUSED BOTH AIR BAGS TO DEPLOY. THE PASSENGER SIDE AIR BAG WHEN IT DEPLOYED BROKE THE FRONT RIGHT SIDE (PASSENGER SIDE) DOOR WINDOW AND THE REAR VIEW MIRROR. NO ONE WAS SEATING IN THE FRONT PASSENGER SEAT. I BELIEVE THIS IS A DEFECT THAT MAY BE A RESULT OF THE AIR BAG IMPROPERLY INSTALLED OR ALIGNED. *NLM

1. LEFT AIR/HEAT VENT NON-FUNCTIONAL. AIR/HEAT IS PUSHED OUT WITH ALMOST NO FORCE, UNLIKE RIGHT VENT, WHICH BLOWS WITH SIGNIFICANTLY GREATER FORCE. BROUGHT THIS COMPLAINT TO DEALER WHO SAID HE HAD THE SAME PROBLEM WITH HIS CAR. SAID IT WAS DESIGN FLAW, DID NOTHING TO ADDRESS PROBLEM. 2. A SPOT OF OIL OR GREASE-LIKE SUBSTANCE APPEARED ON REAR LEFT SEAT BACK. AT FIRST THOUGHT IT WAS NOTHING, NOW STAIN HAS GROWN TO COVER ALMOST A THIRD OF THE ENTIRE SEAT BACK. THE LEAK IS OBVIOUS AND GROWING, THE SEAT BACK CONTINUOSLY GREASY AND WET. DEALER NOTIFIED, CLAIMED THERE WAS NOTHING HE COULD DO ABOUT IT.

EVAPORATOR CORE SPRUNG A LEAK, RESULTING IN AIR CONDITIONING FAILING.*AK