2007 Subaru Forester Suspension Problems

The contact owns a 2007 Subaru Forester. The contact stated that while the vehicle was at an independent mechanic for routine maintenance, the contact was notified of NHTSA Campaign Number: 11V464000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the issue but confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11592157

Incident

Apr 24, 2024

I was driving my car in Upstate NY toward a border crossing wicket and the vehicle began to vibrate violently. I thought that it was a blown tire. I stopped to check and the tires looked fine. I continued for a few yards and it began again. I pulled over and called a tow truck. When the car was loaded onto the tow bed, the front wheel was pitched out at an angle rather than at 90 degrees. Very scary to think what could have happened if I had been driving at 60 mph on the interstate. The car was towed to the nearest garage. The mechanic believed it to be a faulty lower control arm on the front driver's side. Related to Recall #WVX34

NHTSA ID

11567232

Incident

Jan 19, 2024

Started getting a vibration I thought was a tire problem. It would only show up after 30 minutes or so of driving. It happened several times while trying to have the tire store figure it out. On Friday 15 Sep 2023 we drove at highway speeds to Dayton and back. Noticed it occur twice. The next morning we were a few miles from home checking out a dog boarding place. We went to leave and heard a loud pop. The lower right control arm broke. If it had happed the previous day it could have been fatal! This vehicle has been almost exclusively service by Busam Subaru at all recommended short intervals, 3,750miles. The recall for this was performed by Busam on1/31/2012. They always state they have performed a complete inspection and what needs attention. I am now having service done locally since all of their latest services have been dismal at best. I have counted on them to keep me, my family, and my Forester safe. Very disappointing considering how this could have turned out.

NHTSA ID

11547772

Incident

Sep 16, 2023

I was driving and heard bumping noise and thought it was just ice or snow stuck in some parts underneath the car, but the vehicle at one instant pulled over to the other side of the road and I almost lost control and slid off the road. I inspect myself and discover a problem with one of the rear wheel bearings, so I take it to my mechanic. My mechanic discovers rust all underneath and the rust has caused some serious mechanical problems. Front lower control arms and other parts of the suspension are damaged as well because of the rust. This car originally came from the "salt-belt" and Subaru said that the Front lower control arms recall had already been taken care of, yet I have the same issue at low milage for a Subaru Forester. Subaru of America is refusing to fix their screw up. The only warning lamps were ABS, Check Engine, and cruise control light flashing. If this instant happened while kids were in the car, Subaru of America would've gone to court. I hope that either Subaru will either fix their mistake or give me a settlement check.

NHTSA ID

11509200

Incident

Dec 29, 2022

On 7/19/2022 while backing out of a parking spot with a right hand turn we heard a loud noise and the car did not seem to want to continue moving. Upon further inspection the right front tire was sitting at an extreme and unusual angle. Tipped out at the top and no longer pointing in the same direction as the other front tire. Upon recovery of the vehicle and inspection the lower control has completely separated from its inboard forward attachment point due to corrosion. As a secondary result the right from CV axle was disconnected at the transmission CV joint. Due to the slow speed during the incident there was no injury or other vehicle damage. Had this broken at highway speeds the result could have been much different. The vehicle is in our home garage for repair. It has not been otherwise inspected. All parts are available for inspection and I also have pictures of the failed lower control arm. The vehicle is current on all recalls.

NHTSA ID

11475995

Incident

Jul 19, 2022

On Sunday 4/3/2022, driving in a semi highway at 50mph the front passenger suspension arm broke off causing a lose of control of the vehicle. Ended up resting at the road shoulder.

NHTSA ID

11460421

Incident

Apr 3, 2022

My forester has been used in salt belt for 12 years. Was on the list of recall for Front Suspension Control Arm Failure. We brought it to the dealership to have the car inspected and for a 4 year old car, they didn’t do anything. On 10/15/21, the front control arm broke right after we drove off highway. If the arm broke on the highway, then us and others might have been killed as the tire would have broke off. We highly doubt the job to correct the recall was done properly, if they did anything at all. After the accident, we had the car and component inspected by the East Forest Garage. There weren’t any warning signs before the accident.

NHTSA ID

11438437

Incident

Oct 15, 2021

TL* THE CONTACT OWNS A 2007 SUBARU FORESTER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH IN A PARKING LOT, THE LOWER CONTROL ARM FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE LOWER CONTROL ARM WAS FRACTURED DUE TO RUST. THE CONTACT CALLED KENNY ROSS SUBARU (11299 LINCOLN HWY, NORTH HUNTINGDON, PA 15642, (724) 864-5100, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V464000 (SUSPENSION). THE FAILURE MILEAGE WAS APPROXIMATELY 69,000.*DT *BF CONSUMER STATED HAMILTON MAZDA SUBARU AND KENNY ROSS SUBARU ARE THE SAME.*JB

NHTSA ID

11328152

Incident

Jun 7, 2020

Mileage

69,000 mi

TL* THE CONTACT OWNS A 2007 SUBARU FORESTER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS A RATTLING NOISE WAS HEARD COMING FROM THE FRONT END OF THE VEHICLE. WHILE DRIVING IN REVERSE THE DRIVER SIDE FRONT CONTROL ARM AND AXLE FRACTURED WITHOUT WARNING. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER LESTER GLENN SUBARU (1501 NJ-37 W, TOMS RIVER NJ) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 129,000.

NHTSA ID

11301195

Incident

Dec 1, 2019

Mileage

129,000 mi

I PURCHASED THIS CAR USED FROM NJ, AND RECENTLY RELOCATED TO WA. APPROX. 126K MILES, THE LOWER FRONT CONTROL ARM ON THE DRIVER SIDE RUSTED THROUGH, DROPPING THE CAR ONTO THE WHEEL, AND PULLING THE DRIVEAXLE FROM THE TRANSMISSION. IT APPEARS THAT THE CONTROL ARM RUSTED FROM THE TOP SIDE, WHICH WOULD LIKELY BE DIFFICULT TO IDENTIFY DURING A ROUTINE INSPECTION IF YOU DIDN'T KNOW TO LOOK FOR IT. THIS HAPPENED WHEN FIRST BACKING UP FROM THE DRIVEWAY IN THE MORNING, LESS THAN 1 FOOT OF TRAVEL BEFORE I STOPPED TO SEE WHAT WAS GOING ON. I SPOKE WITH SUBARU OF AMERICA, WHO TOLD ME THAT THE RECALL ON THE CONTROL ARM WAS "CLOSED" AND THAT THE REPAIR COSTS WOULD BE MY RESPONSIBILITY. I AM A MECHANICAL ENGINEER, AND WOULD NEVER ACCEPT THAT CATASTROPHIC CORROSION IN A FUNDAMENTAL PART OF THE SUSPENSION COULD BE AN ACCEPTABLE DEFECT FOR WHICH THE END USER SHOULD ASSUME RESPONSIBILITY. IF THE CAR WAS INDEED "TREATED" FOR THIS CONDITION BY THE OWNER AT THE TIME OF THE RECALL, THEN CLEARLY THE TREATMENT IS UNSATISFACTORY AND SHOULD NOT BE TAKEN AS AN ACCEPTABLE RESPONSE TO A VERY SIGNIFICANT SAFETY HAZARD. MY ONLY BLESSING IN THIS SITUATION IS THAT IT DID NOT FAIL THE PREVIOUS EVENING WHEN I WAS DRIVING HOME, OR LATER THAT MORNING HAD I BEEN ABLE TO GET OUT OF MY DRIVEWAY.

NHTSA ID

11092313

Incident

May 6, 2018

Mileage

126,000 mi

I'VE BEEN HAVING PROBLEMS WITH FRONT END CONTROL WHENEVER I GO OVER A BUMP AT HIGHWAY SPEEDS. IT FEELS AS THOUGH THE STEERING WHEEL IS BEING PULLED FROM MY HANDS. I GET AN ALIGNMENT EVERY 6 MONTHS WITH NO IMPROVEMENT.

NHTSA ID

11052045

Incident

Nov 30, 2017

Mileage

125,000 mi