1993 Subaru Legacy Problems

DEAR SIR/MADAM: THANKS FOR HELP. IT IS THREATEN TO THOUSANDS SUBARU CAR DRIVERS, LIKE FIRESTONE TIRES THREATEN TO THOUSANDS CAR DRIVERS USING FIRESTONE TIRES. I HAVE A 93 4D LEGACY SEDAN, IT HAVE A PROBLEM SINCE 1994 AND BECOME VERY BAD SINCE 7/2000, SOME TIME CAR UNCONTROLLABLE TO SLOWDOWN TO 10 TO 20 MPH AND SOME TIME ENGINE STOPPED, PUT ME IN VERY DANGEROUS SITUATION: MY CAR UNCONTROLLABLE STOPPED WHEN OTHER CARS DRIVE 65+ MILES ON FREE WAY OR 45+ MILS ON LOCAL ROAD. I THINK THIS A CONTROLLER DESIGN PROBLEM, IT SHOULD NOT SLOW DOWN AND STOP ENGINE WITHOUT WARNING LIGHT FIRST AND SHOULD NEVER STOP ENGINE. IF YOU SEARCH INTERNET WITH KEY WORD "+SUBARU +LEGACY +HESITATION" YOU CAN SEE MANY COMPLAINTS ABOUT THE MALFUNCTIONED CONTROLLER. I STILL THINK SUBARU HAVE FOLLOWING OBLIGATIONS: 1. AFTER SO MANY COMPLAINTS FROM SUBARU CAR OWNERS ABOUT THE MALFUNCTIONED CONTROLLER, SUBARU SHOULD REPLACE MALFUNCTIONED CONTROLLER BEFORE THE DANGEROUS UNCONTROLLABLE SITUATION HAPPEN. 2. SUBARU SHOULD REPLACE MALFUNCTIONED CONTROLLER FREE WHEN A CUSTOMER COMPLAIN THE PROBLEM. NOW SOME DEALERS JUST DENY THE PROBLEM IF THEY CANNOT DUPLICATE THE PROBLEM, BUT FOR SOME CAR THE PROBLEM ONLY HAPPEN ON CERTAIN ROAD AND CERTAIN SPEED AND DIFFICULT TO DUPLICATE. SOME DEALER ALSO LIKE TO CHARGE HOURS TO CHECK THE PROBLEM AND FIX THE PROBLEM. ZHONGMIN SUN 18666 REDMOND WAY, RR2141 REDMOND, WA 98052 TEL:4258369419 EMAIL: [email protected]

DEAR SIR/MADAM: THANKS FOR HELP. IT IS THREATEN TO THOUSANDS SUBARU CAR DRIVERS, LIKE FIRESTONE TIRES THREATEN TO THOUSANDS CAR DRIVERS USING FIRESTONE TIRES. I HAVE A 93 4D LEGACY SEDAN, IT HAVE A PROBLEM SINCE 1994 AND BECOME VERY BAD SINCE 7/2000, SOME TIME CAR UNCONTROLLABLE TO SLOWDOWN TO 10 TO 20 MPH AND SOME TIME ENGINE STOPPED, PUT ME IN VERY DANGEROUS SITUATION: MY CAR UNCONTROLLABLE STOPPED WHEN OTHER CARS DRIVE 65+ MILES ON FREE WAY OR 45+ MILS ON LOCAL ROAD. I THINK THIS A CONTROLLER DESIGN PROBLEM, IT SHOULD NOT SLOW DOWN AND STOP ENGINE WITHOUT WARNING LIGHT FIRST AND SHOULD NEVER STOP ENGINE. IF YOU SEARCH INTERNET WITH KEY WORD "+SUBARU +LEGACY +HESITATION" YOU CAN SEE MANY COMPLAINTS ABOUT THE MALFUNCTIONED CONTROLLER. I STILL THINK SUBARU HAVE FOLLOWING OBLIGATIONS: 1. AFTER SO MANY COMPLAINTS FROM SUBARU CAR OWNERS ABOUT THE MALFUNCTIONED CONTROLLER, SUBARU SHOULD REPLACE MALFUNCTIONED CONTROLLER BEFORE THE DANGEROUS UNCONTROLLABLE SITUATION HAPPEN. 2. SUBARU SHOULD REPLACE MALFUNCTIONED CONTROLLER FREE WHEN A CUSTOMER COMPLAIN THE PROBLEM. NOW SOME DEALERS JUST DENY THE PROBLEM IF THEY CANNOT DUPLICATE THE PROBLEM, BUT FOR SOME CAR THE PROBLEM ONLY HAPPEN ON CERTAIN ROAD AND CERTAIN SPEED AND DIFFICULT TO DUPLICATE. SOME DEALER ALSO LIKE TO CHARGE HOURS TO CHECK THE PROBLEM AND FIX THE PROBLEM. ZHONGMIN SUN 18666 REDMOND WAY, RR2141 REDMOND, WA 98052 TEL:4258369419 EMAIL: [email protected]

DT: THE CONTACT STATED THE SHOULDER HARNESS ON BOTH FRONT SEAT BELTS DID NOT PROVIDE ADEQUATE RESTRAINT WHEN IN USE. THE STRAPS GAVE WAY WHEN PROPERLY BUCKLED. THE SEAT BELTS WERE NOT COVERED UNDER WARRANTY. HE PURCHASED REPLACEMENT STRAPS AND PLANNED TO REPLACE THE STRAPS HIMSELF. *AK

CONSUMER NOTICED THE FRONT SEAT BELTS DOESN'T COME UP PROPERLY, DEALER REPLACED THE BELT THREE TIMES AND THE PROBLEM STILL REOCCURING. NLM

CONSUMER WAS TRAVELING ABOUT 45MPH AND A DEER RAN ACROSS THE ROAD. CONSUMER JAMMED THE BRAKES, AND WENT OFF THE ROAD, SLAMMING INTO A DITCH. UPON IMPACT, AIRBAGS DIDN'T GO OFF. *AK

VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND THE AIRBAGS DID NOT DEPLOY. VEHICLE WAS TOTALED. MANUFACTURER AND DEALER HAVE BEEN NOTIFIED. *AK

DT*: THE CONTACT STATED THERE WAS A RECALL ON THE VEHICLE, NHTSA #94V052000 CONCERNING THE MANUAL TRANSMISSION. THE RECALL WORK WAS PERFORMED PRIOR TO PURCHASE. THE TRANSMISSION LOCKED UP WHILE DRIVING 25 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP, BUT HAS NOT BEEN INSPECTED.

TRANSMISSION PROBLEM WITH LEGACY. *BF THE CONSUMER STATED THAT HIS VEHICLE WILL NOT SHIFT PAST THE SECOND GEAR. *TC

TWO YEAR OLD TIRES (ALL 4, PURCHASED AT SAME TIME) HAVE CIRCUMFERENTIAL CRACKS IN TREAD GROOVES - TIRE SELLER SAYS THESE ARE VERY ABNORMAL AND IS REPLACING ALL OF THEM. HAVE ONLY 20,000 MILES OF WEAR ON TIRES RATED FOR 80,000. NO CATASTROPHIC FAILURES. TIRES A GOODRICH TRACTION T/A 195/60R15 88H. DOT CODE ON ALL 4 TIRES: ANRBMC112705. *TR

THE CONSUMER PURCHASED FOUR NEW FIRESTONE TIRES. THE RIGHT REAR TIRE WENT FLAT. THE VEHICLE WAS PARKED. THE CORD THAT MEETS THE RIM OF THE WHEEL SEPARATED FROM THE TIRE. CONTACTED THE MANUFACTURER WAS TOLD SHE COULD PURCHASE ANOTHER TIRE FOR HALF PRICE. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB

VEHICLE EXPERIENCED BRAKE FAILURE WHILE APPLYING BRAKES. WHEN COMING TO A SLOW STOP ON WET / ICY ROAD CONDITIONS, VEHICLE REAR ENDED ANOTHER VEHICLE IN FRONT. DEALER NOTIFIED, AND INFORMED CONSUMER THAT NOTHING COULD BE FOUND. *AK

RACK AND PINION SEALS LEAK FLUID.

CONSUMER WAS TRAVELING ABOUT 15MPH ON HIGHWAY AND DRIVER'S SIDE FRONT WINDOW JUST EXPLODED. DEALERSHIP WILL BE NOTIFIED. *AK

THE MOTORIZED SHOULDER HARNESS RETRACTOR OPERATES ERRATICALLY, FREQUENTLY LEAVING THE HARNESS ONLY PARTIALLY RETRACTED. WE ARE CONCERNED ABOUT SAFE OPERATION OF THE VEHICLE BECAUSE OF INTERFERENCE WITH STEERING, TURN SIGNAL OPERATION AND VISIBILITY (INCLUDING VISIBILITY IN LEFT REAR VIEW MIRROR). THERE IS ALSO CONCERN ABOUT STRANGULATION IN THE EVENT OF A CRASH BECAUSE OF THE POSITION OF THE BELT WELL FORSARD OF THE BODY, AND BELOW THE LEVEL OF THE NECK. MY WIFE CONSISTENTLY DISCONNECTS THE BELT, LEAVING ONLY THE LAP BELT, BUT THIS CERTAINLY DOESN'T PROVIDE OPTIMAL SAFETY EITHER, PARTICULARLY BECAUSE THE VEHICLE IS EQUIPPED WITH AN AIR BAG. THE DEALER HAS ESTIMATED REPAIR COSTS AT OVER $500.00. WE FEEL BECAUSE IT IS REQUIRED SAFETY EQUIPMENT, THEY SHOULD REPAIR IT AT THEIR EXPENSE. THANKS FOR YOUR HELP. *AK

AFTER APPROX. 2 MINUTES AFTER ENGINE START AND AT APPROX. 20MPH, ENGINE RPM'S SUDDENLY AND RAPIDILY ACCELERATED TO 5000 RPM'S. ENGINE DID NOT RETURN TO NORMAL UNTIL ENGINE SHUT OFF AND RESTARTED. COULD NOT STOP CAR EVEN WITH BOTH FEET APPLYING BRAKES. HAD TO JAM TRANSMISSION INTO PARK TO STOP CAR..

AFTER COLD ENGINE START, APPROX. 2 MINUTES OF DRIVING, AT APPROX. 20 MPH ENGINE RPM'S VERY SUDDENLY AND RAPIDLY WENT TO 5000RPMS UNCONTROLLED. DID NOT RETURN TO IDLE UNTIL ENGINE SHUT OFF. *AK

VEHICLE KEPT STALLING OUT AND WOULD NOT RESTART FOR AT LEAST 30 MINUTES. VEHICLE HAS BEEN TAKEN TO DEALER TWICE. BUT, COULD NOT DETERMINE CAUSE. CONSUMER FEELS IT IS AN ELECTRICAL PROBLEM. *AK *SLC

VEHICLE IS SOMETIMES UNCONTROLLABLE TO SLOWDOWN AT 10 TO 20 MPH AND ENGINE STOPS WHILE OTHER VEHICLES ARE DRIVING 65 MPH, VEHICLE STALLS INTERMITTENTLY WITHOUT WARNING, DUE TO MALFUNCTIONED CONTROLLER. *ET

FUEL FILLER PIPE HAD ALL KINDS OF DIRT, DEBRIS AND RUST CAUSING IT TO FAIL AND LEAK OIL. THE FILER TUBE RUSTED AND CAUSED FUEL TO LEAK FROM THE VEHICLE. WHEN THE CONSUMER PULLED THE PLASTIC SHROUD AWAY FROM THE FILLER PIPE HE NOTICED ALL KINDS OF ROAD DIRT, RUST AND DEBRIS HAD ACCUMULATED AND CAUSED THE PIPE TO FAIL. THE CONSUMER ALSO HAS A 1995 LEGACY L/L AND IS CONCERNED THAT THE FAILURE MAY OCCUR IN THAT VEHICLE. THE CONSUMER REQUESTED REIMBURSEMENT. *NLM

VEHICLE BROUGHT IN FOR SERVICE TWO SEPARATE TIMES FOR THE SAME PROBLEM AT 43,000 MILES, FOR SUSPECTED TRANSMISSION PROBLEMS. WAS TOLD THAT THE OIL PUMP, TIMING BELT, AND IDLE CONTROL VALVE WERE DEFECTIVE AND NEEDED REPLACEMENT UNDER WARRANTY. AT 60,000 MILES THE CAR WAS SERVICED FOR REGULAR MAINTENANCE, AND TOLD TO CHECK THE TRANSMISSION, AS IT WAS STILL NOT FUNCTIONING CORRECTLY. FOUR THOUSAND MILES LATER, AT 64,000 MILES, THE TRANSMISSION SEIZED WHILE DRIVING WITH TWO SMALL CHILDREN AND ONE PASSENGER. THE DEALER REFUSES TO PAY FOR REPAIR AT THIS TIME. RETRIEVED INFORMATION REGARDING THE RECALL ON 1993 LEGACY TRANSMISSIONS, CONCERNED THAT I NEVER RECEIVED THE RECALL INFORMATION, NOR WAS TOLD BY ANY OF THE LAST THREE DEALERS THAT I HAVE DELT WITH ABOUT THIS POTENTIAL LIFE-THREATENING DEFECT!

THE MOTORIZED SHOULDER HARNESS RETRACTOR OPERATES ERRATICALLY, FREQUENTLY LEAVING THE HARNESS ONLY PARTIALLY RETRACTED. WE ARE CONCERNED ABOUT SAFE OPERATION OF THE VEHICLE BECAUSE OF INTERFERENCE WITH STEERING, TURN SIGNAL OPERATION AND VISIBILITY (INCLUDING VISIBILITY IN LEFT REAR VIEW MIRROR). THERE IS ALSO CONCERN ABOUT STRANGULATION IN THE EVENT OF A CRASH BECAUSE OF THE POSITION OF THE BELT WELL FORSARD OF THE BODY, AND BELOW THE LEVEL OF THE NECK. MY WIFE CONSISTENTLY DISCONNECTS THE BELT, LEAVING ONLY THE LAP BELT, BUT THIS CERTAINLY DOESN'T PROVIDE OPTIMAL SAFETY EITHER, PARTICULARLY BECAUSE THE VEHICLE IS EQUIPPED WITH AN AIR BAG. THE DEALER HAS ESTIMATED REPAIR COSTS AT OVER $500.00. WE FEEL BECAUSE IT IS REQUIRED SAFETY EQUIPMENT, THEY SHOULD REPAIR IT AT THEIR EXPENSE. THANKS FOR YOUR HELP. *AK

RACK AND PINION SEALS LEAK FLUID.

FUEL FILLER PIPE HAD ALL KINDS OF DIRT, DEBRIS AND RUST CAUSING IT TO FAIL AND LEAK OIL. THE FILER TUBE RUSTED AND CAUSED FUEL TO LEAK FROM THE VEHICLE. WHEN THE CONSUMER PULLED THE PLASTIC SHROUD AWAY FROM THE FILLER PIPE HE NOTICED ALL KINDS OF ROAD DIRT, RUST AND DEBRIS HAD ACCUMULATED AND CAUSED THE PIPE TO FAIL. THE CONSUMER ALSO HAS A 1995 LEGACY L/L AND IS CONCERNED THAT THE FAILURE MAY OCCUR IN THAT VEHICLE. THE CONSUMER REQUESTED REIMBURSEMENT. *NLM

PAINT IS PEELING OFF THE HOOD.

SOON AFTER PURCHASE, HEADLIGHT LENSES STARTED BECOMING OPAQUE/FOGGED IN APPEARANCE. THE HEADLIGHTS OF MY GIRLFRIEND'S '92 SUBARU LEGACY LOOKED THE SAME. NEVER THOUGHT MUCH ABOUT IT BECAUSE I LIVED IN A LARGE URBAN AREA WITH WELL LIT STREETS. WAS RECENTLY TRANSFERRED TO THE LITTLE CITY OF SAVANNAH, GA. NOTICED THAT IT IS HARD TO SEE AT NIGHT. LAST NIGHT SOMEONE INFORMED ME THAT I SHOULD REPLACE MY HEADLIGHTS BECAUSE THEY ARE BARELY VISIBLE. I LOOKED AT THEM AND THEY ARE EXTREMELY DIM. CALLED THE NEAREST DEALER AND THE PARTS MANAGER SAID THAT THIS IS A VERY COMMON PROBLEM CAUSED BY THE CHEAP PLASTIC USED TO MAKE THE LENS FOR THE HEADLIGHT ASSEMBLY. IT IS A LITTLE LATE TO BE REPORTING IT, BUT THIS SEEMS TO BE A DEFINITE SAFETY HAZARD. WAS THERE EVER A RECALL FOR THESE HEADLIGHTS?*AK

THE MOTORIZED SHOULDER HARNESS RETRACTOR OPERATES ERRATICALLY, FREQUENTLY LEAVING THE HARNESS ONLY PARTIALLY RETRACTED. WE ARE CONCERNED ABOUT SAFE OPERATION OF THE VEHICLE BECAUSE OF INTERFERENCE WITH STEERING, TURN SIGNAL OPERATION AND VISIBILITY (INCLUDING VISIBILITY IN LEFT REAR VIEW MIRROR). THERE IS ALSO CONCERN ABOUT STRANGULATION IN THE EVENT OF A CRASH BECAUSE OF THE POSITION OF THE BELT WELL FORSARD OF THE BODY, AND BELOW THE LEVEL OF THE NECK. MY WIFE CONSISTENTLY DISCONNECTS THE BELT, LEAVING ONLY THE LAP BELT, BUT THIS CERTAINLY DOESN'T PROVIDE OPTIMAL SAFETY EITHER, PARTICULARLY BECAUSE THE VEHICLE IS EQUIPPED WITH AN AIR BAG. THE DEALER HAS ESTIMATED REPAIR COSTS AT OVER $500.00. WE FEEL BECAUSE IT IS REQUIRED SAFETY EQUIPMENT, THEY SHOULD REPAIR IT AT THEIR EXPENSE. THANKS FOR YOUR HELP. *AK

LEFT CV JOINT MALFUNCTIONED. *AK

CONSUMER STATES THAT THE DRIVER SIDE FRONT DOOR HAS DEFECTIVE LOCKS, THE LOCKS WILL INTERMITTENLY LOCK. CONTACTED DEALER AND THE DEALER IS NOT WILLING TO DO ANYTHING. NLM