Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 1996 Subaru Legacy submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
TL*THE CONTACT OWNS A 1996 SUBARU LEGACY. THE VEHICLE FAILED TO START AND WAS TOWED TO THE DEALER. THE DEALER ATTRIBUTED THE CAUSE OF FAILURE TO THE WIRES INSIDE THE FUEL TANK BEING BURNT BECAUSE THE INTERNAL CONNECTOR HAD LOOSE TERMINALS. THE FUEL PUMP MODULE WAS REPLACED. THE CURRENT MILEAGE IS 85,000 AND FAILURE MILEAGE WAS 84,600.
TL*THE CONTACT OWNS A 1996 SUBARU LEGACY. WHILE FILLING THE GAS TANK THE CONTACT NOTICED A PUDDLE OF GAS FORMING UNDER THE VEHICLE. THE FILLER PIPE RUSTED THROUGH AND CAUSED THIN HOLES. THE CURRENT AND FAILURE MILEAGES WERE 110,000.*AK
DT*: THE CONTACT STATED AN ODOR OF FUEL WAS DETECTED AND A PUDDLE BEGAN TO FORM ON THE GROUND WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE FUEL FILLER TUBE WAS REPLACED. UPDATED 9/5/2006 - *NM
DT: THE CALLER SAYS HIS GAS GAUGE WILL SHOW EMPTY WHEN IT GETS DOWN TO HALF A TANK. HE STATES THAT IT DOES NOT HAPPEN ALL THE TIME. IT HAS BEEN HAPPENING FOR A MONTH. DEALER AND MANUFACTURER HAVE NOT BEEN CONTACTED YET.*AK THE CONSUMER DID CONTACT THE MANUFACTURER AND WAS TOLD TO TAKE THE VEHICLE TO THE DEALER, BUT THERE WOULD BE A CHARGE TO INSPECT THE VEHICLE. *JB
STONE GAURD PROTECTING FUEL FILLER PIPE CAUSED DIRT TO BE TRAPPED BLOCKING DRAIN AND WATER TO ACCUMULATE AGAINST FILLER PIPE. RUSTED FILLER PIPE CAUSING LEAKING.
DT: THE FILLER PIPE ON FUEL TANK ROTTED OUT AND LEAKED FUEL ALL OVER THE PLACE. DEALER SAID IT WAS NOT A SAFETY DEFECT AND NO RECALL WAS NOTED.
I HAVE A 1996 SUBARU LEGACY L WITH AN INTERMITTENT ENGINE MISS WITH A P0304 (MISS IN CYLINDER 4) CODE. MOST OF THE TIME IT RUNS FINE BUT WHEN IT MISSES, IT IS VERY VIOLENT. IT SEEMS TO RESONATE. CHANGING SPEED USUALLY MAKES IT GO AWAY. WHEN IT FIRST STARTED, IT ONLY OCCURRED ONCE A MONTH. OVER THE PAST YEAR, AND AFTER SEVERAL MECHANICS VISITS, IT NOW OCCURS NEARLY EVERY TRIP.I HAVE REPLACED SPARK PLUGS (YES NGK), SPARK PLUG WIRES (SUBARU ORIGINAL EQUIPMENT), GAS FILTER, AIR FILTER, COIL, PCV VALVE, KNOCK SENSOR, CAM AND CRANKSHAFT SENSORS. THE INJECTORS HAVE BEEN SWAPPED BETWEEN CYLINDERS. I HAVE BEEN TO AN INDEPENDENT MECHANIC TWICE. ON THE SECOND TRIP HE GAVE UP AND ADVISED I GO TO A SUBARU DEALER. AFTER TWO VISITS TO THE SUBARU DEALER, I'VE SPENT SEVERAL HUNDRED ADDITIONAL DOLLARS AND STILL HAVE THE PROBLEM. THEY REPLACED PLUGS, KNOCK, CAM, AND CRANKSHAFT SENSORS.DOESN'T SUBARU HAVE DIAGNOSTICS TO IDENTIFY WHAT THIS PROBLEM IS. I TOOK THE CAR TO THEM WITH THE EXPECTATION THAT THEY COULD IDENTIFY WHAT IS WRONG INSTEAD OF JUST REPLACING HIGHLY SUSPECT PARTS. THEY DON'T SEEM TO BE DOING ANY BETTER THAN I HAVE DONE ON MY OWN.*AK I'VE SEEN OTHERS POST PROBLEMS HERE AND AT EDMUNDS WITH DRIVEABILITY ISSUES. I'VE NEVER SEEN A POSTING THAT INDICATED IT WAS ACTUALLY SOLVED. SURELY SUBARU KNOWS ABOUT THIS PROBLEM AND HAS A FIX. IT HAS GONE FROM AN ANNOYANCE TO A SAFETY ISSUE. DOES ANYONE HAVE ANY SUGGESTIONS? ARE SOME SUBARUS JUST LEMONS?
GAS GAUGE IS INOPERATIVE, CANNOT INDICATE HOW MUCH GAS IS IN THE VEHICLE WHICH MAY CAUSE STALLING. DEALER NEEDS TO REPLACE THE FUEL SENDER UNIT. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .