1997 Subaru Legacy Problems

1997 SUBARU LEGACY GT 2.5L ENGINE, APPROX. 92K MILES, ENGINE STARTED OVERHEATING. CAR WAS TAKEN TO TWO DIFFERENT REPAIR FACILITIES AND DIAGNOSED AS BLOWN HEAD GASKET AFTER PRESSURE TEST, BLOCK TEST, NO SIGNS OF LEAKING. CAR HAD BEEN SERVICED FAITHFULLY BY ORIGINAL OWNER AT SUBARU DEALERSHIPS SINCE PURCHASE. I FOUND OUT THIS IS A COMMON PROBLEM FROM REPAIR FACILITIES WITH THIS MODEL AND ENGINE BUT WHEN QUESTIONED SUBARU DEALERSHIP THEY SAID IT COULDN'T HAVE HAPPENED AS HEAD GASKET AND COOLING SYSTEM ARE NOT RELATED (?) AND PROBLEM WAS A CRACKED BLOCK OR CYLINDER. ESTIMATED COST TO REPLACE HEAD GASKET $2450-. ESTIMATED COST TO REPLACE ENGINE $5700-. I HAD ALSO HAD A PROBLEM WHERE THE FUEL FILLER TUBE THAT CONNECTS TO THE GAS TANK FROM WHERE YOU PUR THE GASOLINE IN FROM THE PUMP HAD RUSTED AWAY AND LEAKED FUEL ONTO THE GROUND. I HAD THAT REPLACED AT APPROX. COST OF $400-. AGAIN SUBARU DENIED THERE WAS A PROBLEM WHEN I CALLED THE DEALERSHIP. THESE PROBLEMS OCCURRED WITH IN SIX MONTHS OF EACH OTHER. *TR

1997 SUBARU LEGACY 2.5 L ENGINE. 118,000 MILES. CHRONIC OVERHEATING. MANY DOLLARS SPENT ONLY TO FIND THAT THESE CARS ARE NOTORIOUS FOR BLOWING HEAD GASKETS. SURE ENOUGH, THAT'S THE TROUBLE. *TR

IN COLD WEATHER (ZERO OR BELOW), THE BRAKE PEDAL ON MY 1997 SUBARU LEGACY SEDAN BECOMES HARD, AND WHEN I PUT IT ANY GEAR, FORWARD OR REVERSE, THE IDLE SPEED WILL CAUSE THE CAR TO MOVE AND THE BRAKES WILL NOT STOP THE CAR-I HAVE TO SHIFT INTO NEUTRAL. I HAVE LEARNED THAT PUMPING THE BRAKE PEDAL WHILE THE CAR IS AT IDLE IN N OR P WILL USUALLY HELP, AT -20 DEGREES, I HAVE TO LET THE CAR IDLE FOR 5 TO 10 MINUTES AND THEN TRY IT. THE DEALER INDICATED THAT THIS IS NOT UNCOMMON, BUT THAT THERE IS NO EASY FIX FOR THIS. THIS HAS HAPPENED EVERY WINTER SINCE I BOUGHT THE CAR IN 2001. *TR

RIGHT FRONT BRAKE HAS FAILED TO OPERATE PROPERLY ON AT LEAST FOUR OCCASIONS. THE BRAKES HAVE GOTTEN VERY HOT AND COULD POSSIBLY CAUSE A FIRE OR CAUSE THE BRAKES TO LOCK UP. THE DUAL PISTON DESIGN RESULTS IN ONE PISTON DOING MOST OF THE WORK SO THE OTHER PISTON BECOMES STIFF AND DOES NOT RELEASE. WE HAVE HAD THE BRAKES GRAB AND BECOME EXTREMELY HOT TO THE POINT THAT WE ARE NOW ON OUR FOURTH SET OF CALIPERS WITH JUST OVER 36,000 MILES ON THE CAR. OUR MECHANIC ADVISES THIS PROBLEM IS QUITE COMMON ON SUBARU'S FOR AT LEAST THE 1996 THROUGH 1998 MODEL YEARS. WE HAVE HAD THE BRAKES REPLACED THREE TIMES BUT DO NOT HAVE THE OLD PARTS AVAILABLE. *JB

CAR WAS SOMETIMES DIFFICULT TO START, OTHER TIMES IT WOULD STALL/HESITATE WHEN IN MOTION ON CITY STREET. DISCOVERED TO BE CAUSED BY AGED/WORN FUEL PUMP CAUSING OVERCURRENT DRAW THAT FAILS TO BLOW FUSE CAUSING MELTDOWN IN WIRING HARNESS CONNECTOR WHERE PIGTAIL FROM PUMP CONNECTS TO THE CHASSIS SIDE OF THE WIRING HARNESS. HEAT/SPARK POTENTIAL IS CREATED IN CLOSE PROXIMITY TO FUEL TANK THAT HAS MANY REPORTED CASES OF FUEL FILLER NECK RUSTING OFF AND LEAKING FUEL. A QUICK GOOGLE SEARCH REVEALS THAT A NUMBER OF PEOPLE, WITH PHOTOS, HAVE EXPERIENCED THIS FAILURE. PHOTO PROVIDED IS FROM INTERNET BUT THE RESULT IS THE SAME.

TL* THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT ATTEMPTED TO START THE IGNITION AND THE ENGINE FAILED TO START. THE BATTERY WAS JUMP STARTED; HOWEVER THE FAILURE RECURRED WHILE DRIVING. THE BATTERY WAS RECHARGED FOR A SECOND TIME. THE CONTACT REPLACED THE BATTERY TERMINAL DUE TO SEVERE RUST AND CORROSION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. UPDATED 02/28/12 *BF THE CONSUMER STATED BATTERY CORROSION DESTROYED THE NEGATIVE TERMINAL. UPDATED 03/08/12

WHILE THE VEHICLE WAS RUNNING IN THE PARK POSITION, THE CONSUMER WAS UNABLE TO SHIFT THE GEARS IN ANY DIRECTION. VEHICLE WAS NOT DRIVABLE. *AK THE CAUSE WAS DUE TO POOR GROUND TO THE SHIFTER SOLENOID. THIS WOULD NOT ACUATE TO ALLOW THE SHIFTER IN GEAR. THE CONSUMER WAS TOLD BY SEVERAL MECHANICS THAT THIS WAS A COMMON PROBLEM IN THIS MAKE/MODEL. *SCC *JB

WHILE TRAVELING ON A STEEP HILL GEAR WILL MOVE TO ANOTHER GEAR AS IF VEHICLE IS COASTING. *AK ENGINE DOES NOT HOLD CAR WHEN GOING DOWN HILLS OR STOPPING, HAD TO DECEND A STEEP MOUNTAIN ROAD USING ONLY BRAKES, WHEN SLOWING VEHICLE ACTS IF THOUGH IT IS IN NEUTRAL WHEN IN 0,3,2,1. NEW TRANSMISSION COST $3000. *MJ

TL*THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT NOTICED THAT THE AIR BAG WARNING LIGHT CONSTANTLY ILLUMINATES ON THE INSTRUMENT PANEL, WHICH MEANS THAT SHE COULD EXPERIENCE SPORADIC AIR BAG DEPLOYMENT OR IMPROPER DEPLOYMENT IN THE EVENT OF A CRASH. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 84,000.

CONSUMER TRIED TO AVOID A CRASH WHILE TRAVELING 68-70 MPH. IN THE PROCESS, THE CONSUMER RAN THE VEHICLE OFF THE ROAD, RUNNING HEAD ON INTO A TREE. DRIVER'S AIR BAG FAILED TO DEPLOY. *AK

1997 SUBARU LEGACY OUTBACK WITH SUDDEN ACCELERATION PROBLEMS. CONSUMER STATES THAT THE VEHICLE MADE A LOUD NOISE AND THE BRAKE PEDAL WENT TO THE FLOOR AND VEHICLE SURGED WITHOUT WARNING AND HIT THE VEHICLE IN FRONT OF THE CONSUMER. *KB THE CONSUMER STATED BOTH VEHICLES HAD MINIMAL DAMAGE. THE DEALER REPLACED THE FAST IDLE AIR CONTROL VALVE. THE CONSUMER DOESN'T BELIEVE THAT THE SUDDEN ACCELERATION PROBLEM HAS BEEN RECTIFIED. THE CONSUMER DIDN'T STATE IF A POLICE REPORT WAS FILED. *JB

WHEN CRUISE CONTROL IS SET AT 65 MPH, GOING UP AN INCLINE AND MAKING A TURN VEHICLE SUDDENLY ACCELERATED, LOST CONTROL OF VEHICLE AND HIT A WALL. DRIVER INJURED. VEHICLE TOTALED*AK *YD

1997 SUBARU LEGACY OUTBACK. CAME OUT TO MY PARKED VEHICLE WITH THE RIGHT FRONT TIRE FLAT DUE TO PART OF THE SUSPENSION SPRING BEING SNAPPED AND STICKING INTO INSIDE OF THE TIRE. SPRING WAS INTACT WHEN I PARKED IT. FRIGHTENING TO THINK IF THAT HAD HAPPENED WHILE DRIVING ON THE HIGHWAY OF WHICH I WAS THE DAY BEFORE THIS HAPPENED.

I INSTALLED MEVOTECH STRUT MOUNTS (MP903987 & MP903986) ON OUR 1997 SUBARU LEGACY POSTAL WHEN INSTALLING NEW REAR SHOCK ABSORBER/STRUTS. THE RIGHT SIDE FAILED ON THE FIRST DAY AFTER AROUND 60 MILES. I REPLACED IT WITH THE ORIGINAL FACTORY PART THAT HAD LASTED 420,000 MILES. THE LEFT SIDE FAILED THE NEXT DAY AFTER BEING IN SERVICE FOR APPROXIMATELY 100 MILES TOTAL. I RETURNED THE OTHER ORIGINAL PART TO SERVICE. THE FAILURES ALLOWED THE STRUT TO PUSH THROUGH THE MOUNT AND HIT ON THE THIN RETAINING PLATE. IT ALLOWED THE REAR SUSPENSION TO BECOME EXTREMELY LOUD AND LOOSE. I REPORTED THIS TO THE MANUFACTURER AND RECEIVED NO RESPONSE. I REPORTED IT TO THE SELLER, ROCKAUTO, AND THEIR RESPONSE WAS THAT I SHOULD DO MORE RESEARCH ON PART QUALITY. I BELIEVE THERE IS A DIFFERENCE BETWEEN POOR QUALITY AND DANGEROUS DEFECT. I HAVE THE FAULTY MEVOTECH PARTS IN THEIR ORIGINAL BOXES. *TR

CAR WAS SOMETIMES DIFFICULT TO START, OTHER TIMES IT WOULD STALL/HESITATE WHEN IN MOTION ON CITY STREET. DISCOVERED TO BE CAUSED BY AGED/WORN FUEL PUMP CAUSING OVERCURRENT DRAW THAT FAILS TO BLOW FUSE CAUSING MELTDOWN IN WIRING HARNESS CONNECTOR WHERE PIGTAIL FROM PUMP CONNECTS TO THE CHASSIS SIDE OF THE WIRING HARNESS. HEAT/SPARK POTENTIAL IS CREATED IN CLOSE PROXIMITY TO FUEL TANK THAT HAS MANY REPORTED CASES OF FUEL FILLER NECK RUSTING OFF AND LEAKING FUEL. A QUICK GOOGLE SEARCH REVEALS THAT A NUMBER OF PEOPLE, WITH PHOTOS, HAVE EXPERIENCED THIS FAILURE. PHOTO PROVIDED IS FROM INTERNET BUT THE RESULT IS THE SAME.

1997 SUBARU LEGACY GT 2.5L ENGINE, APPROX. 92K MILES, ENGINE STARTED OVERHEATING. CAR WAS TAKEN TO TWO DIFFERENT REPAIR FACILITIES AND DIAGNOSED AS BLOWN HEAD GASKET AFTER PRESSURE TEST, BLOCK TEST, NO SIGNS OF LEAKING. CAR HAD BEEN SERVICED FAITHFULLY BY ORIGINAL OWNER AT SUBARU DEALERSHIPS SINCE PURCHASE. I FOUND OUT THIS IS A COMMON PROBLEM FROM REPAIR FACILITIES WITH THIS MODEL AND ENGINE BUT WHEN QUESTIONED SUBARU DEALERSHIP THEY SAID IT COULDN'T HAVE HAPPENED AS HEAD GASKET AND COOLING SYSTEM ARE NOT RELATED (?) AND PROBLEM WAS A CRACKED BLOCK OR CYLINDER. ESTIMATED COST TO REPLACE HEAD GASKET $2450-. ESTIMATED COST TO REPLACE ENGINE $5700-. I HAD ALSO HAD A PROBLEM WHERE THE FUEL FILLER TUBE THAT CONNECTS TO THE GAS TANK FROM WHERE YOU PUR THE GASOLINE IN FROM THE PUMP HAD RUSTED AWAY AND LEAKED FUEL ONTO THE GROUND. I HAD THAT REPLACED AT APPROX. COST OF $400-. AGAIN SUBARU DENIED THERE WAS A PROBLEM WHEN I CALLED THE DEALERSHIP. THESE PROBLEMS OCCURRED WITH IN SIX MONTHS OF EACH OTHER. *TR

DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A DRY HIGHWAY, THE HOOD LATCHE FAILED AND CRACKED THE WINDSHIELD. THE CONTACT WAS ABLE TO PULL OFF OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTO BODY SHOP. UPDATED 12/28/06. *JB

APRROX. 3 MONTHS AGO I WAS DRIVING DOWN A HIGHWAY AT ABOUT 65 MILES AN HOUR WHEN MY HOOD POPPED UP AND HIT THE WINDSHIELD. THE WINDSHIELD WAS CRACKED IN MANY PLACES AND THE HOOD WAS BENT AND PAINT CHIPPED. I CONTACTED SUBARU THE FOLLOWING DAY BECAUSE MY HOOD HAD NOT BEEN OPENED FOR APPROX 2MTHS PRIOR THIS AND WAS CONCERNED OF A DEFECT IN PART. THEY TOLD ME THERE WAS NONE AND SOMETIMES IT JUST HAPPENS. I PAID FOR A NEW WINDSHIELD (I BELEIVE ABOUT 235) AND HAVE YET TO REPLACE HOOD. TODAY I WAS INFORMED BY A TECHNICIAN THAT REPLACES WINDSHIELDS (CONTACT WAS UNRELATED TO MY CAR) THAT HE REPLACES MORE WINDSHIELDS ON SUBARUS THAN ANY OTHER CAR BECAUSE THE FIRST HOOD LATCH FAILS AND THE SECOND LETS GO WHEN HIGH WAY SPEED IS REACHED. I BELIEVE THIS IS A PART MALFUNCTION THAT POSES A SERIOUS THREAT TO DRIVERS AND SHOULD BE INVESTIGATED. IF I HAVE CONTACTED THE WRONG DEPARTMENT OR COMPANY PLEASE DIRECT ME IN RIGHT DIRECTION. I AM UNSURE BUT COULD FIND OUT OF THE EXACT INCIDENT DATE.

1997 SUBARU LEGACY OUTBACK. CAME OUT TO MY PARKED VEHICLE WITH THE RIGHT FRONT TIRE FLAT DUE TO PART OF THE SUSPENSION SPRING BEING SNAPPED AND STICKING INTO INSIDE OF THE TIRE. SPRING WAS INTACT WHEN I PARKED IT. FRIGHTENING TO THINK IF THAT HAD HAPPENED WHILE DRIVING ON THE HIGHWAY OF WHICH I WAS THE DAY BEFORE THIS HAPPENED.

BOLT ON THE IDLER ARM SNAPPED, CAUSING THE TIMING CHAIN TO DROP, AND RESULTING IN A BENT ENGINE VALVE. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED.*AK

TL* THE CONTACT OWNS A 1997 SUBARU LEGACY. THE CONTACT STATED THAT THE VEHICLE BECAME STUCK IN PARK. THE FAILURE WAS RECURRING. THE VEHICLE HAD BEEN TAKEN TO AN AUTHORIZED DEALER, WHO LUBRICATED THE AUTOMATIC TRANSMISSION SHIFTER BUT TO NO AVAIL. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN BACK FOR FURTHER DIAGNOSIS AND IT WAS ADVISED THAT THE PART REQUIRED FOR THE REPAIR WAS NO LONGER AVAILABLE. THE AUTHORIZED DEALER ADVISED THE CONTACT TO PURCHASE THE SHIFT LOCK MODULE AND AN AUTHORIZED DEALER WOULD REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 75000. UPDATED 06/10/14 MA THE CONSUMER WAS INFORMED, THE PART WAS NO LONGER AVAILABLE. UPDATED 07/23/14

VEHICLE HAS BEEN LOOKED AT DURING A PERIOD OF TIME AND MECHANIC FOUND SEVERAL PROBLEMS. RADIATOR AND HEAD GASKETS WERE REPLACED. OIL WAS LEAKING FROM THE MOTOR, AND THE AXLE ON THE PASSENGER SIDE HAD GONE BAD. *AK

REAR SEAT, CENTER SEATBELT LATCHING MECHANISM FAILED WHILE ATTEMPTING TO SECURE CHILD SAFETY SEAT. THE SEATBELT LATCH MECHANISM IS HELD TOGETHER WITH TWO PLASTIC RIVETS. THESE RIVETS PULLED THROUGH THE PLASTIC SEATBELT LATCH HOUSING, AND THE LATCH FELL APART INTO 5 PIECES !!!

THE INFANT CAR SEAT PUT IN THE REAR CENTER SEAT, SEAT BELT BUCKLE WAS SNAPPED AND FELL APART, DID NOT SECURE CAR SEAT. YH

GASOLINE FILLER TUBE ON SUBARU LEGACY MODELS (1994 & 1997) RUST OUT AND CAUSE VERY SERIOUS DANGER FROM POSSIBLE FIRE/EXPLOSION DUE TO LEAKING FUEL. THIS APPEARS TO BE A VERY COMMON PROBLEM FOR SUBARU OWNERS AND COSTLY ($350+) TO REPAIR. THIS PART WAS REPLACED ON BOTH A 1994 AND A 1997 SUBARU LEGACY AND THE REPAIR SHOP INDICATED THAT THIS IS A COMMON PROBLEM THAT THEY HAVE DEALT WITH QUITE OFTEN. I FEEL THE PROBLEM IS VERY DANGEROUS AND SHOULD BE ADDRESSED BY THE MANUFACTURER. *TR

1) ALL 4 RIMS HAVE A TENDENCY TO COLLECT ROAD SILT AND WATER INSIDE. THIS IMBALANCES THE CAR AND MAY EXPLAIN SOME OF THE BRAKE PROBLEMS. PERHAPS AIRFLOW UNDER THE VEHICLE SHOULD BE STUDIED. 2) PADS AND SPRINGS LOCATED ON FRAME WHERE THE REAR GATE CLOSES AGAINST THE BODY ARE RUSTED TIGHT. 3) DASH LIGHTS FOR HVAC HAVE FAILED AT ABOUT 30,000 MILES. 4) GAS GAUGE DOES NOT DESCEND ACCURATLY.

OIL LEAK FROM CRANK CASE SEAL DRIPS BACK ONTO EXHUST MANAFOLD DURING NORMAL DRIVING. ONCE CAR HAS STOPPED AND IS AT IDLE THE OIL BURNS OFF THE MANAFOLD AND LARGE AMOUNTS OF SMOKE POUR FROM UNDER THE HOOD AND UNDER THE CAR. IF VENTILATION SYSTEM LEFT ON THEN SMOKE ENTERS THE PASSENGER COMPARTMENT. NUMBER 2: THE CAR SHUDDERS WHEN TURNS LEFT OR RIGHT AT LOW SPEEDS (5MPH). NUMBER 3: THE METAL GUIDES FOR THE SIDE WINDOW (DRIVERS SIDE) HAVE SCRATCHED THE GLASS AND IT CAN'T BE REPAIRED MUST REPLACE. NUMBER 4: CAR STARTED TO SPUTTER OR MISS AFTER 61000 MILES. IT OCCURS ONLY AFTER THE ENGINE WARMS UP.

7) ALL 4 RIMS HAVE A TENDENCY TO COLLECT ROAD SILT AND WATER INSIDE. THIS IMBALANCES THE CAR AND MAY EXPLAIN SOME OF THE BRAKE PROBLEMS. PERHAPS AIRFLOW UNDER THE VEHICLE SHOULD BE STUDIED. 8) LEFT REAR PASSENGER WINDOW DOES NOT GO UP ALL THE WAY ANY LONGER. 84,000 MILES. 9) PADS AND SPRINGS LOCATED ON FRAME WHERE THE REAR GATE CLOSES AGAINST THE BODY ARE RUSTED TIGHT. 10) DASH LIGHTS FOR HVAC HAVE FAILED AT ABOUT 30,000 MILES. 11) GAS GAUGE DOES NOT DESCEND ACCURATLY.

PROBLEMS WITH HEADLIGHT EQUIPMENT STARTING TO CLOUD.*MR THE CONSUMER STATED THE HEAD LIGHT LENS HAS NOT BECOME A SAFETY ISSUE AS OF NOW, BUT MAY BECOME AN ISSUE IN THE FUTURE. *JB *NM

WHILE DRIVING AT 45 MPH THE ALTERNATOR WENT OUT, CAUSING THE CONSUMER TO LOSE ALL POWER. ALSO, HEADLIGHTS WENT OUT, AND STEERING BECAME DIFFICULT. MANUFACTURER DENIES PROBLEM. *AK *ML

1997 SUBARU LEGACY OUTBACK. CAME OUT TO MY PARKED VEHICLE WITH THE RIGHT FRONT TIRE FLAT DUE TO PART OF THE SUSPENSION SPRING BEING SNAPPED AND STICKING INTO INSIDE OF THE TIRE. SPRING WAS INTACT WHEN I PARKED IT. FRIGHTENING TO THINK IF THAT HAD HAPPENED WHILE DRIVING ON THE HIGHWAY OF WHICH I WAS THE DAY BEFORE THIS HAPPENED.

CONSUMER STATES WHILE DRIVING AT 55 MPH THE LEFT REAR WHEEL STUD BROKE AND THE TIRE FELL OFF AND THE CONSUMER COULD NOT CONTROL THE VEHICLE, THIS IS THE THIRD TIME THE VEHICLE HAS HAD THIS PROBLEM. CONTACTED DEALER.*JB

AIR CONDITIONER COMPRESSOR FROZE UP, THIS CAUSED BELT TO SHRED, PART OF THE BELT THAT SHREDDED WAS OVER IN ENGINE COMPARTMENT, HAD NO WARNING EXCEPT AIR CONDITIONER WAS NOT COOLING PROPERLY, CONTACTED DEALER, AND WROTE LETTER TO SUBARU MANUFACTURER. *AK *SLC

AIR CONDITIONER BLEW FUMES INTO VEHICLE, CAUSING CONSUMER TO PASS OUT AND RUN OFF ROAD, RESULTING IN A VEHICLE COLLISION.

THE TIRES SHOWED NO OBVIOUS DEFECTS, THEY WERE BALANCED ABOUT A MONTH PRIOR TO THE INCIDENT. WHILE DRIVING ON THE HIGHWAY THE LEFT REAR TIRE SUDDENLY CAME APART. IT WAS NOT A BLOW OUT OR PUNCTURE. THE INSIDE TIRE TREAD DELAMINATED FROM THE TIRE AND THE STEEL BELT WAS SHOWING. ONCE I PULLED OVER I NOTICED THE SAME WEAR WAS ON THE RIGHT REAR TIRE ALSO. THE SAME EXACT MODEL TIRES WERE PUT ON BY THE DEALER ON JULY 17TH. ARE THESE SAFE TIRES?*AK( DOT NUMBER: TIRE SIZE: 15 )