1991 Subaru Loyale Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Subaru Loyale, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Transmission527.8%
- Engine422.2%
- Seat belts316.7%
- Other / unspecified15.6%
- Suspension15.6%
- Driver assistance15.6%
- Visibility15.6%
- Electrical15.6%
- Interior & seats15.6%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
TL* - ON A COLD DAY WHILE TRYING TO DRIVE IN REVERSE THE WOULD NOT ENGAGE IN THE REVERSE GEAR. THE CONTACT WAITED FOR THE VEHICLE TO WARM UP, AND WAS ABLE TO DRIVE FOR SOMETIME, UNTIL THE TRANSMISSION SUDDENLY FAILED , CAUSING THE VEHICLE TO SLOW DOWN AND EVENTUALLY COME TO A COMPLETE STOP. THE CONTACT HAS THE VEHICLE AT SPEEDY TRANSMISSION WHERE THEY WILL REBUILD THE TRANSMISSION. THE CONTACT FELTTHAT VEHICLE SHOULD BE COVERED UNDER NHTSA RECALLCAMPAIGN 94V052000.*AK
2 FRONT AUTOMATIC SEATBELTS DON'T RETRACT/ AUTOMATIC WINDOWS ALL 4 WON'T COME DOWN/ REAR BACK UP LIGHTS DO NOT COME ON, AND 4 -WHEEL DRIVE DOES NOT WORK. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 1991 Subaru Loyale. The contact stated that while driving at an undisclosed speed, the automatic seat belt continuously opened and retracted independently, failing to secure the contact inside the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the automatic seat belt tightener system and observed an oil gasket leak. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 309,000.
EXHAUST FAILURE DETAILS: VERY SOON AFTER WE PURCHASED THIS VEHICLE, WE DISCOVERED THAT WHENEVER WE TOOK A CLOVERLEAF-TYPE OFFRAMP WHICH REQUIRED A QUICK DECCELERATION AND THEN A QUICK ACCELERATION, A THICK BLACK CLOUD OF SMOKE WOULD COME OUT OF THE EXHAUST PIPE. THE ONLY WAY I FOUND TO CORRECT THIS PROBLEM WAS TO PUT THE CAR INTO NEUTRAL, IF DISTANCE ALLOWED, AND ALLOW THE CAR TO DECOMPRESS BEFORE ACCELERATING. A VERY LITTLE PERCENTAGE OF MY DRIVING INVOLVES THIS TYPE OF OFFRAMP, AND ESTIMATES I REQUESTED FOR THIS REPAIR RANGED CLOSE TO $1000.00. MY HUSBAND ONCE HEARD A MAN CALL INTO AN AUTO-REPAIR RADIO STATION INTERVIEW WITH THE IDENTICAL PROBLEM IN HIS SUBARU LOYALE WAGON. MY AXLE PROBLEM HAS BEEN A REAL NUISANCE. I NEVER DO ANY OFF-ROAD DRIVING, ONLY REGULAR CITY DRIVING, AND I HAVE HAD TO REPLACE THE AXLE THREE TIMES, AND HAVE NOW BEEN TOLD THAT THE AXLE NEEDS TO BE REPLACED AGAIN, AND THE CAR IS NOT SAFE TO DRIVE. I THINK THIS IS AN UNREASONABLE OCCURRENCE FOR REGULAR CITY DRIVING AFTER ONLY 140,000 MILES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
The contact owns a 1991 Subaru Loyale. The contact stated that while driving at an undisclosed speed, the automatic seat belt continuously opened and retracted independently, failing to secure the contact inside the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the automatic seat belt tightener system and observed an oil gasket leak. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 309,000.
2 FRONT AUTOMATIC SEATBELTS DON'T RETRACT/ AUTOMATIC WINDOWS ALL 4 WON'T COME DOWN/ REAR BACK UP LIGHTS DO NOT COME ON, AND 4 -WHEEL DRIVE DOES NOT WORK. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact owns a 1991 Subaru Loyale equipped with a replacement CV-axle from Master Pro, Part Number: SB8003. The contact indicated that while driving in reverse, the vehicle suddenly stopped moving and would not drive forward or backwards. The vehicle was towed to the residence and examined by an independent mechanic who diagnosed that the CV-axle had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact indicated that the failure had also occurred on a second vehicle using the same part. The failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
WHEN DRIVING AT ANY SPEED VEHICLE JERKS AND VIBRATES. ALSO, ENGINE HEAD GASKET HAD A LEAKAGE. CONSUMER PUT THE VEHICLE IN REPAIR SHOP FOR REPAIRS, BUT PROBLEM HAS RETURNED. VEHICLE HAS BEEN IN REPAIR SHOP FOUR TIMES, AND DEALER CAN'T DETERMINE THE CAUSE OF THE PROBLEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
UPON STARTING ENGINE RACES UP TO 3000 RPM'S FOR APPOX. 10 MINUTES BEFORE IT SETTLES DOWN, DEALER'S MADE SEVERAL ATTEMPTS TO CORRECT, WAS TOLD TO LIVE WITH IT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
2 FRONT AUTOMATIC SEATBELTS DON'T RETRACT/ AUTOMATIC WINDOWS ALL 4 WON'T COME DOWN/ REAR BACK UP LIGHTS DO NOT COME ON, AND 4 -WHEEL DRIVE DOES NOT WORK. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
2 FRONT AUTOMATIC SEATBELTS DON'T RETRACT/ AUTOMATIC WINDOWS ALL 4 WON'T COME DOWN/ REAR BACK UP LIGHTS DO NOT COME ON, AND 4 -WHEEL DRIVE DOES NOT WORK. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE HOOD CAME UNLATCHED AND WAS FOLDED BACK AGAINST THE WINDSHIELD BY THE WIND WHILE THE CONSUMER WAS DRIVING. (OHIO TRAFFIC CRASH REPORT) *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .