2006 Suzuki AN650 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Suzuki AN650, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical360.0%
- Body & structure120.0%
- Transmission120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
MOTORCYCLE FAILS TO START. DETERMINED THAT THE CONTACTS IN THE SWITCH MELT AND FAIL TO MAKE CONTACT. SIMILAR CONDITION EXISTED IN THE START BUTTON THAT RESULTED IN HEADLIGHTS NOT WORKING. FORCED TO BYPASS SWITCH TO MAKE HEADLIGHTS WORK.
TL* THE CONTACT OWNS A 2006 SUZUKI AN650 BURGMAN SCOOTER. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED A FEW MOMENTS LATER. THE CONTACT REPLACED THE IGNITION SWITCH HIMSELF, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ISSUED NHTSA CAMPAIGN NUMBER: 05V372000 (ELECTRICAL SYSTEM) FOR THE 2003 AND 2004 MODEL YEARS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THIS IS A POTENTIALLY DANGEROUS SITUATION INVOLVING A 2006 SUZUKI BURGMAN SCOOTER HERE ARE SOME DETAILS: PURCHASED NEW 2006 SUZUKI BURGMAN SCOOTER, WITH ONLY 138 MILES ON THIS SCOOTER MY SELF(DAVE) AND THE SERVICE MANAGER(TREVOR) NOTICED RUSTY WELD JOINTS,HE CONTACTED HIS AREA SUZUKI SERVICE REP AND WE BOTH WERE SHOCKED AT HIS SOLUTION"JUST PUT TOUCH UP PAINT OVER THE RUST?????????????? WE BOTH THOUGHT SUZUKI WOULD EITHER SEND ANOTHER SCOOTER TO REPLACE THIS ONE OR AT THE VERY LEAST REPLACE THE FRAME! AFTER ALL THE FRAME IS THE BACK BONE OF THIS SCOOTER AND RUST IN THE WELD JOINTS AFTER 138 MILES OF USE SUGGESTS AN UNSAFE CONDITION! I CONTINUED TO RIDE THIS SCOOTER WAITING TO HERE FROM THE SUZUKI REP I WAS CONTACTED BY SUZUKI ONCE CONCERNING THE RUSTY WELDS AND THEY TOO SUGGEST TOUCHUP PAINT?????????????? THIS IS NOT A SAFE REPAIR THE FRAME SHOULD BE REPLACED IN THE INTEREST OF SAFETY. I TOLD SUZUKI I WAS GIVING THEM TIME TO RESPOND AND IT HAS BEEN 5 MONTHS AND NO ONE FROM SUZUKI HAS CONTACTED ME OR TREVOR I'M TURNING TO YOU FOR HELP IN THIS SITUATION AND TO REMEDY A POTENTIAL HAZARD. THANK YOU FOR YOUR RESPONSE DAVID A ZICHEK. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
MY TRANSMISSION ON MY SUZUKI BURGMAN 650 KEEPS GOING OUT. IT SEEMS TO HAPPEN ABOUT EVERY 12 TO 15K MILES; WITH THE EXCEPTION OF THIS LAST TIME IT HAPPENED AT ABOUT 5K. THE SCOOTER DOESN'T SHIFT OUT OF SECOND GEAR. IT FIRST STARTS WITH INTERMITTENT GEAR SHIFTING PROBLEMS THEN GETS SEVERE AND STAYS IN FIRST OR SECOND. I'VE HAD IT IN THE SHOP 3 TIMES NOW IN JUST OVER ONE YEAR. EVERY TIME ITS BEEN IN THE SHOP, ITS BEEN THERE FOR ON AVERAGE AT LEAST 2 MONTHS. THE LONGEST THE BIKE HAS BEEN IN THE SHOP WAS FOR THREE MONTHS. EFFECTIVELY THE BIKE HAS BEEN IN THE SHOP FOR ABOUT A THIRD OF THE TIME THAT I'VE OWNED IT. I REALLY LIKE THE BIKE BUT I THINK THIS A PROBLEM THAT THE COMPANY SHOULD RECOGNIZE AND RECTIFY. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .