2005 Suzuki C90 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Suzuki C90, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical666.7%
- Fuel system222.2%
- Powertrain (other)111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 SUZUKI C90. THE CONTACT STATED THAT THE MOTORCYCLE HESITATED AND FAILED TO SHIFT GEARS AT LOW AND HIGH SPEEDS. THE GEAR SHIFT FRACTURED DUE TO THE FAILURE AND THE CONTACT HAD TO REPLACE THE PART. IN ADDITION, THE BATTERY WAS REPLACED FOUR TIMES AND TAKEN TO THE DEALER THREE TIMES. THE FAILURE WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE MOTORCYCLE WAS ALSO TAKEN TO AN INDEPENDENT MECHANIC THREE TIMES. THE MOTORCYCLE STALLED SEVERAL TIMES WITHOUT WARNING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.
THE GENERATOR (STATOR) SHORTED TO GROUND. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL GAUGE QUITE WORKING. NOTHING WAS DONE TO REPLACE, AS THE SENDING UNIT IS BAD AND YOU CAN NOT PURCHASE A NEW SENDING UNIT. *TR
TL*THE CONTACT OWNS A 2005 SUZUKI C90 MOTORCYCLE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 06V025000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY) AND IMMEDIATELY CALLED THE DEALER. THE TECHNICIAN PROCRASTINATED WITH SCHEDULING AN APPOINTMENT FOR THE RECALL REPAIR. ONE WEEK LATER, THE CONTACT NOTICED FUEL LEAKING FROM HIS VEHICLE, WHICH COULD POSSIBLY CAUSE A FIRE. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 11,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 SUZUKI C90. THE CONTACT STATED THAT THE MOTORCYCLE HESITATED AND FAILED TO SHIFT GEARS AT LOW AND HIGH SPEEDS. THE GEAR SHIFT FRACTURED DUE TO THE FAILURE AND THE CONTACT HAD TO REPLACE THE PART. IN ADDITION, THE BATTERY WAS REPLACED FOUR TIMES AND TAKEN TO THE DEALER THREE TIMES. THE FAILURE WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE MOTORCYCLE WAS ALSO TAKEN TO AN INDEPENDENT MECHANIC THREE TIMES. THE MOTORCYCLE STALLED SEVERAL TIMES WITHOUT WARNING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .