2011 Suzuki DL650 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2011 Suzuki DL650, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical266.7%
- Fuel system133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
FAILED COMPONENT; FUEL INDICATOR THE DIGITAL FUEL INDICATOR IS NOT READING ACCURATELY. FUEL INDICATOR SHOWS MORE FUEL THAN WHAT IS ACTUALLY AVAILABLE IN THE TANK. - AT ONLY 1/4 FULL TANK, TEH INDICATOR STILL SHOWS AS 3/4 FULL. - WHEN FILLING THE TANK (5.4 GAL CAPACITY) AT APPX 1/4 FULL (OR APPX 1.3 GAL), THE TANK ACCEPTS APPX 4 GAL OF FUEL. - THIS REFLECT AN ERROR OF APPX 60% LESS MORE FUEL THAN ACTUALLY AVAILABLE. - THIS INACCURACY CAN CAUSE ENGINE STALLING AND A POSSIBLE ACCIDENT. - MANUFACTURER SHOULD PROVIDE A CORRECTION/FIX TO HAVE THIS READING BE ACCURATE TO ~10% OR SOME ACCEPTABLE STANDARD, NOT A 60% ERROR. *TR
FAILED COMPONENT: SPEEDOMETER. THE SPEEDOMETER ON THIS VEHICLE IS HIGHLY IN ACCURATE. AT MAY ROADWAYS (40 TO 55MPH) AND HIGHWAY SPEEDS (UP TO 85 IN SOME STATES). AT THESE SPEEDS, THE SPEEDOMETER IS OVER BY AS MUCH AS 10 TO 12 MPH OR AS MUCH AS 15%. MEASURED AGAINST GPS, OTHER VEHICLES, AND POINT-TO-POINT TIMING. THIS HAS SEVERAL EFFECTS: - WHEN TRAVELING ON ROADS WITH MINIMUM SPEED LIMITS, ONE COULD BE TRAVELING SLOWER THAN PASTED - TRAVELING IN HIGHWAYS AT POSTED SPEEDS, ONE IS TRAVELING LESS THAN WHAT THE SPEEDOMETER SAYS AND COULD BE OVERTAKEN BY ANOTHER VEHICLE. - ODOMETER IS OVERSTATED OVER THOUSANDS OF MILES. VEHICLES SHOWS MORE MILEAGE THAN ACTUAL, THEREFORE DEVALUATION. I.E. AT 25K MILES, THE VEHICLE WOULD BE STATING AS 2K TO 2.5K MORE/EXTRA MILES THAN ACTUAL. - THE EXTRA MILES COULD EXPIRE WARRANTY EARLIER THAN WHAT IS EXPECTED. THIS ISSUE NEEDS TO BE ADDRESSED. MANUFACTURERS HAVE TO PROVIDE CALIBRATION TO A MORE ACCEPTABLE RANGE - ~2% TO 3%. MOST VEHICLES ARE WITHIN THESE STANDARDS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FAILED COMPONENT; FUEL INDICATOR THE DIGITAL FUEL INDICATOR IS NOT READING ACCURATELY. FUEL INDICATOR SHOWS MORE FUEL THAN WHAT IS ACTUALLY AVAILABLE IN THE TANK. - AT ONLY 1/4 FULL TANK, TEH INDICATOR STILL SHOWS AS 3/4 FULL. - WHEN FILLING THE TANK (5.4 GAL CAPACITY) AT APPX 1/4 FULL (OR APPX 1.3 GAL), THE TANK ACCEPTS APPX 4 GAL OF FUEL. - THIS REFLECT AN ERROR OF APPX 60% LESS MORE FUEL THAN ACTUALLY AVAILABLE. - THIS INACCURACY CAN CAUSE ENGINE STALLING AND A POSSIBLE ACCIDENT. - MANUFACTURER SHOULD PROVIDE A CORRECTION/FIX TO HAVE THIS READING BE ACCURATE TO ~10% OR SOME ACCEPTABLE STANDARD, NOT A 60% ERROR. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .