2008 Suzuki Forenza Electrical Problems

Every neutral safety switch made for this vehicle is faulty be driving down the road it'll switch from drive to neutral or any other gear I've had it go into reverse while going 50 mph down the road I've replaced this part five times still have same problem part works for about a month then goes out. Other times transmission won't even go into drive have to screw with shifter to get it to go into gear May last for about a mile and jumps back out of gear. Next problem computer tells me throttle positioning sensor is out car works fine at first then starts to rev around 5-6k or it to rev to half a grand and stall while driving down the road.

NHTSA ID

11486246

Incident

Jan 5, 2022

I WAS DRIVING HOME FROM WORK AND SMOKE STARTING TO COME INSIDE THE CAR FROM THE DRIVER SIDE VENTS. I PULLED OVER AND LET THE SMOKE AIR OUT AS I CALLED A TOW TRUCK. ON THE TOW TRUCK AT THE POOLER PARKWAY EXIT OFF OF I-16, THE CAR ALARM WAS GOING OFF, THE LIGHTS WERE FLASHING, AND THE CAR WAS COMPLETELY FILLED WITH SMOKE. THE TOW TRUCK DRIVER PULLED OVER, RAN TO THE CAR ON THE TOW TRUCK BED, OPENED THE DRIVER SIDE DOOR AND SAW FLAMES ENGULFING THE PANEL UNDER THE STEERING WHEEL. HE GRABBED THE FIRE EXTINGUISHER AND PUT OUT THE FIRE AND DISCONNECTED THE BATTERY. DURING THIS TIME, I WAS IN THE CAB OF THE TOW TRUCK. CAR WAS THEN CONSIDERED A LIABILITY, THEREFOR WAS NOT ALLOWED AT THE TOW TRUCK YARD OR MY APARTMENT COMPLEX. THE TOW TRUCK DRIVER TOWED THE CAR TO DAN VADEN CHEVROLET, WHERE I HAD BEEN CONTACTING THEM FOR TWO WEEKS REGARDING THE PART I GOT A NOTICE ON ABOUT THE RECALL.

NHTSA ID

11025101

Incident

Sep 20, 2017

Mileage

120,000 mi

THE CAR WAS PARKED IN THE DRIVEWAY. IT SPONTANEOUSLY CAUGHT ON FIRE, BURNING THE ENTIRE DASH ON THE DRIVERS SIDE. THE CAR IS A TOTAL LOSS. THE CAR WAS NOT RUNNING AT THE TIME AND HAD BEEN SITTING UNOCCUPIED FOR A COUPLE OF HOURS. THE SMOKE FROM THE ELECTRICAL FIRE BLACKENED THE WINDOWS ON THE ENTIRE CAR. THE SPEEDOMETER AND ALL OTHER GUAGES ON THE DASH WERE COMPLETELY MELTED AND THE DASH BURNED ALL THE WAY BACK TO THE FIREWALL. IT APPEARS TO HAVE STARTED IN OR RIGHT AT THE STEERING WHEEL.

NHTSA ID

11011569

Incident

Jul 27, 2017

ELECTRICAL DOOR LOCKING SYSTEM MALFUNCTIONING, DOORS WILL NOT REMAIN LOCKED, HAS CONSTANT CLICKING AND UNLOCKING ALL DOORS WHEN I LOCK THE CAR.

NHTSA ID

10917477

Incident

Aug 1, 2016

CAR HEADLIGHT SHUT OF ON ME WHILE DRIVING DOWN ROAD ALONG WITH AIR CONDITIONING AND WINDOWS THEY ALL SHUT OFF ON ME WHILE DRIVING WINDOWS WOULD NOT GO DOWN AND I HAD TO PULL OVER NEAR THE NEAREST STORE AND CUT CAR OFF THANKS I TURNED IT BACK ON AND THEY ALL SRARTED WORKING ACCEPT THE AIR THAT DIDNT START WORKING AGAIN TILL ABOUT THIRTY MINS LATER CAR ALSO JUMPS WHEN PULLING OUT OF PARK IN TO DRIVE OR REVERSE REALLY HARD JUMP THE CAR HEADLIGHTS ALSO FLICKER WHEN PRESSING WINDOWS BUTTONS TO GO DOWN TIRE SENSOR LIGHT WONT GO OUT CAR ALSO HAS A HARD TIME ACCELERATING GOING UPHILL U HAVE PRESS DOWN ALL THE WAY ON GAS FOR IT TO GO

NHTSA ID

10893886

Incident

Jun 8, 2016

Mileage

91,000 mi

I HAVE HAD THE TRANSMISSION RANGE SENSOR REPLACED ON MY 2008 SUZUKI FORENZA TWICE ALREADY AND IT HAS MALFUNCTIONED AGAIN. WHEN IT MALFUNCTIONS, MY CAR JERKS HEAVILY WHEN CHANGING GEARS, AND IT IS AN AUTOMATIC ENGINE. THE RPMS WILL NOT EXCEED 3000, THE CHECK ENGINE LIGHT COMES ON, AND "HOLD" FLASHES IN THE DASH. THE CAR ACCELERATES VERY SLOWLY SHUDDERS ABOVE 50 MPH. THE SPEEDOMETER HAS DROPPED TO ZERO WHILE I HAVE BEEN DRIVING ON THE HIGHWAY, SO I CANNOT TELL HOW FAST I AM GOING.

NHTSA ID

10850096

Incident

Mar 15, 2016

Mileage

108,000 mi

TRANSMISSION RANGE SENSOR FAILURE.

NHTSA ID

10824572

Incident

Jun 20, 2009

Mileage

87,000 mi

THE DRL STAYED ON EVEN AFTER THE CAR WAS PARKED AND OFF. I JUST CAME HOME WITH MY SON AND NEWBORN THANK GOD WE WERE NOT IN THE CAR. THE CAR STARTED SMOKING WHICH CAUSED A FIRE. THE FIRE DEPARTMENT CAME OUT, INVESTIGATED AND LOOKED UP RECALLS AND MY CAR WAS ON THE LIST THE SAME THING HAPPENED, ON THE LEFT SIDE. NOW MY CAR IS RUINED! I HOPE SUZUKI WILL BE REPLACING MY CAR!

NHTSA ID

10758611

Incident

Aug 21, 2015

WE WERE SENT A SAFETY RECALL NOTICE DATED 7/22/2014 STATING THERE IS A DEFECT RELATING TO ABNORMAL OPERATION OF THE HIGH AND/OR LOW BEAM HEADLAMPS AND THE DAYTIME RUNNING LAMPS. THE NOTIFICATION STATES "RECALL SERVICE PARTS ARE NOT YET AVAILABLE TO CORRECT THIS CONDITION. PROVIDING REPAIR PARTS IS A TOP PRIORITY, HOWEVER, THEIR AVAILABILITY IS NOT KNOWN AT THIS TIME. VEHICLE OWNERS WILL BE NOTIFIED BY MAIL WHEN REPAIR PARTS ARE AVAILABLE AND SCHEDULING APPOINTMENTS CAN THEN BEGIN". IT HAS BEEN NEARLY ONE FULL YEAR AND NO FURTHER COMMUNICATION FROM SUZUKI MOTOR OF AMERICA, INC. HAS BEEN RECEIVED. IN THE MEANTIME WE ARE FORCED TO OPERATE A VEHICLE WITH "AN INCREASED RISK OF FIRE" AND WITH THE POSSIBILITY THAT SOMEONE MAY NOT BE ABLE TO PROPERLY SEE THE VEHICLE DUE TO THE MALFUNCTIONING HEADLIGHTS. MILLIONS OF CARS HAVE BEEN MADE WITH PROPERLY FUNCTIONING HEADLIGHTS AND DAYTIME RUNNING LAMPS, THIS CANNOT POSSIBLY BE THAT DIFFICULT OF A REPAIR TO QUICKLY ENGINEER AND IMPLEMENT. IS THIS UNNECESSARY DELAY DUE TO THE FACT THAT SUZUKI NO LONGER SELLS VEHICLES IN THE U.S. AND THEREFORE NO LONGER THINKS IT HAS THE OBLIGATION TO FULFILL RECALL REQUIREMENTS?? ANY HELP THAT CAN BE PROVIDED WOULD BE GREATLY APPRECIATED. THANK YOU.

NHTSA ID

10731838

Incident

Jul 22, 2014

Mileage

42,000 mi

MY HEAD LIGHTS WERE ON DIM, THERE WAS A FLASH AND ONE LIGHT WENT OUT. ABOUT A MILE LATER, THE OTHER HEAD LIGHT WENT OUT. I HAD TO RUN WITH MY HIGH BEAMS ON BECAUSE I HAD NO DIM HEADLIGHTS. I RECEIVED A RECALL LETTER THAT STATES THAT MY CAR COULD BE AFFECTED AND I WANT THIS FIXED! THIS CAR IS MY ONLY WAY OF GOING. *TR

NHTSA ID

10700900

Incident

Mar 21, 2015

TL* THE CONTACT OWNS A 2008 SUZUKI FORENZA. WHILE TRAVELING 15 MPH, THE STEERING AND THE IGNITION SEIZED AND THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO GET THE STEERING AND IGNITION TO RELEASE, BUT THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN THE FAILURE OCCURRED. THERE WAS NO WARNING PRIOR TO THE FAILURE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE STEERING CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 91,000.

NHTSA ID

10694899

Incident

Jan 5, 2015

Mileage

91,000 mi

WHILE CAR WAS MOVING, IT UNLOCKED TWICE, THEN STOPPED, THEN UNLOCKED TWICE AGAIN. IT KEPT REPEATING THIS OVER AND OVER FOR ABOUT 10 MINUTES. *TR

NHTSA ID

10694342

Incident

Mar 14, 2015

Mileage

104,541 mi

THE CAR DAYTIME RUNNING LIGHT MODULE(DRL MODULE) BURNED AND MELTED, LIGHTS WERE NOT WORKING PROPERLY, THE EMERGENCY BRAKE LIGHT REMAINED ON, THE DASHBOARD, CAR HAD A BURNED SMELL SO STRONG THAT I HAD TO DETAIL IT AND IT DID NOT GO(THE STRONG BURNING ODOR) AWAY AFTER 2 WEEKS. I TOOK MY CAR TO THE SHOP AND REPAIRED THE PROBLEM OUT OF MY POCKET(DRL MODULE). I SENT ALL THE PROPER DOCUMENTATION TO SUZUKI MOTOR OF AMERICA CUST SVC DEPARTMENT P.O. BOX 1100 BREA, CA 92822-1100, INCLUDING THE RECEIPT OF THE REPAIR, A COPY OF MY DRIVER LICENSE, COPY OF THE REGISTRATION, COPY OF THE TITLE OF THE VEHICLE(ALL DOCUMENTATION THAT THEY ASKED FOR IN THE SAFETY RECALL NOTICE), CASE AND POINT THEY DO NOT WANT TO REIMBURSE ME, THEY ARE GIVING ME A HARD TIME, PLEASE HELP ME BECAUSE SUZUKI MOTOR OF AMERICA IS GOING TO FIND ANY EXCUSE NOT TO PAY ME BACK, BECAUSE OF THIS IRRESPONSIBLE BEHAVIOR TOWARDS CUSTOMERS AND THE BAD PRODUCTS THEY MAKE ARE OUT OF THE MARKET. *TR

NHTSA ID

10693839

Incident

Jul 1, 2014

Mileage

118,200 mi

BOUGHT VEHICLE APPROX 1 1/2YRS AGO. IT HAD ABOUT 26,000 MILES. IT NOW HAS APPROX 34,500 AD STILL HAS THE SUZUKI WARRANTY. I JUST HAD TO REPLACE A TRANSMISSION RANG SENOR AND NOW BEING TOLD CODES B1382, B114, B1102, B1103, B1405 CAME ON AND NEEDS REPLACEMENT OF DIAGNOSTIC MODULE AND PASSENGER AIRBAGS!! I FEEL THIS SHOULD BE UNDER WARRANTY SINCE THIS IS A HUGE SAFETY ISSUE! I AM TOLD IT WILL COST $1400.00 AND THE AIRBAGS WON'T DEPLOY UNTIL I GET WORK DONE! I SIMPLY CANNOT AFFORD THIS!!! THIS "SENSOR MODULE" SEEMS DEFECTIVE TO ME IF ALL THESE PROBLEMS KEEP ARISING. ALSO THE TIRE PRESSURE SENSOR WILL NOT TURN OFF SINCE TIME OF PURCHASE. *TR

NHTSA ID

10651779

Incident

Oct 14, 2014

Mileage

34,500 mi

MY HEADLIGHTS ALL OF A SUDDEN STAYED ON EVEN AFTER THE CAR HAD BEEN TURNED OFF, AND I FELT A LOT OF HEAT COMING FROM UNDERNEATH THE STEERING WHEEL ON THE LEFT SIDE; THERE WAS A SMALL RELAY OR MODULE SO HOT YOU COULDN'T EVEN TOUCH IT; I HAD TO THE HEADLIGHTS FUSE OFF AND LET IT COOL DOWN. I PROCEEDED TO TAKE THE MODULE OFF AND UNPLUG IT, DID SOME RESEARCH AND FOUND OUT THAT THERE WAS A RECALL ON THIS MODULE CALLED THE DLR MODULE. I CONTACTED THE DEALER BUT EVEN THOUGH THEY HAVE THE PART IN STOCK TO FIX AND REPLACE THIS MODULE, THEY REFUSED TO TAKE CARE OF IT, SAYING THAT THEY STILL DIDN'T HAVE THE PART TO FIX THIS ISSUE AND I WOULD BE CONTACTED BY MAIL WHEN THEY DID. THEY'RE WILLING TO SELL YOU THE PART BUT THEY WON'T REPLACE IT. THEY JUST DON'T WANT TO TAKE RESPONSIBILITY! I ASKED TO HAVE SOMEONE FROM CUSTOMER SERVICE CALL ME, BUT THEY HAVEN'T. I WAS LUCKY TO FIND THE ROOT OF THE PROBLEM IN TIME, OTHERWISE IT WOULD HAD CAUGHT ON FIRE. THIS ISSUE NEEDS TO BE ADDRESSED IMMEDIATELY. PLEASE HELP. *TR

NHTSA ID

10630628

Incident

Aug 25, 2014

Mileage

96,000 mi

THE LOCKS CLICK AS THOUGH THE DOORS ARE LOCKING AND UNLOCKING WHILE IDLE OR DRIVING. THE CHECK ENGINE LIGHT FLASHES. THE AIRBAG LIGHT WAS COMING ON AND GOING OFF PERIODICALLY UNTIL IT FINALLY JUST STAYED ON. *TR

NHTSA ID

10629551

Incident

Jun 1, 2014

I JUST RECEIVED A RECALL LETTER FROM SUZUKI CONCERNING A FIRE POSSIBLE STARTING IN THE LIGHTS....I AM VERY CONCERNED DUE TO SMELLING A BURNING SMELL FOR A WHILE NOW WHEN I AM DRIVING ! ...I CANNOT AFFORD A NEW CAR THIS IS MY ONLY CAR WHAT DO I NEED TO DO? ...I HAVE TO DRIVE TWO HOURS TO WORK AND BACK EVERYDAY DOES ANYONE KNOW WHEN SUZUKI WILL FIX THE PROBLEM?? THANK YOU *TR

NHTSA ID

10621933

Incident

Aug 4, 2014

TL* THE CONTACT OWNS A 2008 SUZUKI FORENZA. THE CONTACT STATED THAT THE HEADLIGHTS AND HAZARD LIGHTS FAILED. THE CONTACT ALSO STATED THAT THERE WAS A BURNING ODOR BEING EMITTED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE FUSE WAS MELTED AND BURNED. IN ADDITION, THE CARPET NEAR THE DRIVER SIDE WAS BURNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. ADDITIONALLY, THE CONTACT RECEIVED NOTIFICATIONS FOR NHTSA CAMPAIGN ID NUMBER: 14V262000 (ELECTRICAL) AND STATED THAT THE PART WAS NOT AVAILABLE FOR THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

NHTSA ID

10618638

Incident

Aug 14, 2013

Mileage

47,000 mi

TL* THE CONTACT OWNS A 2008 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE PARKED, SMOKE STARTED TO EMIT INSIDE OF THE VEHICLE AND FLAMES EMERGED FROM UNDER THE LEFT SIDE OF THE STEERING COLUMN. THE FLAMES SPREAD THROUGH THE ENTIRE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE FIRE COULD HAVE BEEN CAUSED BY A WIRING MALFUNCTION. THE VEHICLE WAS NOT REPAIRED OR REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.

NHTSA ID

10611032

Incident

Jun 24, 2014

Mileage

99,000 mi

2008 SUZUKI FORENZA. CONSUMER WRITES IN REGARDS TO VEHICLE STALLS WHILE DRIVING. *SMD THE CONSUMER STATED THE VEHICLE WOULD STALL AFTER DRIVING 5-10 MILES, ONCE HE STARTED TO SLOW DOWN. THE CONSUMER WAS ABLE TO RE-START THE VEHICLE. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED. *JB

NHTSA ID

10587970

Incident

Jun 14, 2013

THE DOOR LOCKS KEEP MAKING A CLICKING NOISE EVEN WHEN THE CAR IS NOT STARTED. HAVE TO TURN THEM OFF AND ON SEVERAL TIMES TO MAKE IT STOP BUT A FEW DAYS LATER IT HAPPENS AGAIN. I HAVE 4 BRAND NEW TIRES AND THE TIRE SENSOR LIGHT KEEPS COMING ON. THE FRONT DRIVER TIRE KEEPS LOSING AIR. HAVE HAD IT CHECKED AND THERE IS NO LEAKS ANYWHERE. THEY PUT AIR IN AND TIRE SENSOR LIGHT GOES OFF BUT WITHIN 30 MINUTES THE LIGHT COMES BACK ON. *TR

NHTSA ID

10572741

Incident

Mar 5, 2014

Mileage

116,000 mi

MULTIPLE TIMES THE TRANSMISSION THUDS WHEN SHIFTING FROM PARK TO REVERSE. DASH DISPLAY DOES NOT SHOW "R" BUT HAS AN "X" THROUGH IT. TURN CAR OFF AND ON ABOUT THREE TIMES TO TRY TO GET IT TO WORK PROPERLY. EVENTUALLY WORKS OK FOR A WHILE. HAS HAPPENED MULTIPLE TIMES. CAR IS SLUGGISH TO DRIVE AFTER THIS HAPPENS AND ENGINE REVS TOO HIGH. CHECK ENGINE LIGHT COMES ON BUT GOES OFF IN A FEW DAYS. TRANSMISSION RANGE SENSOR IS BAD. *TR

NHTSA ID

10547487

Incident

May 1, 2012

Mileage

20,000 mi

EVERY TIME I CHANGE GEARS, MY CAR THUNKS UNDER THE HOOD AND MY CHECK ENGINE LIGHT IS CONTINUOUSLY ON. A MACHINE WAS HOOKED UP TO MY CAR AND IT READS THAT THERE IS A BAD TRANSMISSION RANGE SENSOR. I'VE DONE MY RESEARCH, AND NOTICE AN UNBELIEVABLE AMOUNT OF COMPLAINTS DUE TO THE SAME ISSUE/PART. WHEN THIS HAPPENS IN MY VEHICLE, IT DRIVES VERY POORLY AND FEELS LIKE IT CANNOT SHIFT INTO THE CORRECT GEAR. THIS IS UNSAFE. *TR

NHTSA ID

10536737

Incident

Jul 1, 2013

Mileage

49,885 mi

TL* THE CONTACT OWNS A 2008 SUZUKI FORENZA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, SHE HEARD A LOUD GRINDING SOUND COMING FROM UNDER THE HOOD AREA. THE BRAKE AND ELECTRICAL SYSTEM LIGHTS THEN ILLUMINATED AS THE VEHICLE BECAME DIFFICULT TO STEER. THE CONTACT STOPPED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE ENGINE SERPENTINE BELT WAS FRACTURED AND PULLING THE BRAKE LINE OUT OF THE FIRE WALL, SPINNING IT AROUND THE BRAKE LINE, THE ALTERNATOR PULLEY, AND THE STEERING ROD. THE ELECTRICAL SYSTEM HARNESS WAS ALSO FRACTURED. THE MECHANIC REPLACED THE BRAKE LINE AND THE ENGINE DRIVE BELT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 44,380. *TR

NHTSA ID

10536723

Incident

Aug 20, 2013

Mileage

44,380 mi

WHEN SHIFTING FROM PARK TO REVERSE, THE TRANSMISSION THUMPS AND THE CHECK ENGINE LIGHT COMES ON. CAR WILL ONLY DRIVE SLUGGISHLY. GOES AWAY EVENTUALLY, BUT HAS HAPPENED 3 TIMES. LOOKING ON INTERNET, IT APPEARS TO BE TRANSMISSION RANGE SENSOR. ALSO, THE BRAKE SHIFT INTERLOCK FAILED, AND COULD NOT GET THE CAR OUT OF PARK. USED THE OVER-RIDE HOLE TO GET CAR OUT OF PARK. *TR

NHTSA ID

10524302

Incident

May 1, 2012

Mileage

25,000 mi