RoadVitals

2004 Suzuki VL800 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest May 30, 2011
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Suzuki VL800, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Electrical133.3%
  • Interior & seats133.3%
  • Other / unspecified133.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

DRIVING DOWN ROAD DOING ABOUT 25 MPH MOTORCYCLE STALLED WOULD NOT START AGAIN. CHECKED IGNITION FUSE AND FOUND IT TO BE BLOWN. REPLACED WITH NEW 15 AMP FUSE. TRIED TO START THE BIKE AGAIN AND THE FUSE BLEW RIGHT AWAY. INSPECTED WIRING HARNESS AND FOUND A BUNCH OF BURNT WIRES. IGNITION SWITCH WAS HOT TO THE TOUCH. I ONLY HAVE 4694 MILES ON THE BIKE. THIS CAN CAUSE A SERIOUS ACCIDENT DO TO THE BIKE STALLING OUT IN TRAFFIC.

NHTSA ID 10404752 · filed May 30, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

DT*: THE CONTACT STATED SINCE THE MOTORCYCLE WAS PURCHASED, IT WAS NOTICED THE SEAT WAS VERY UNCOMFORTABLE. WHILE DRIVING 65 MPH ON NORMAL HIGHWAY, THE CONTACT DEVELOPED SEVERE BACK PAIN. THE DEALERSHIP WAS CONTACTED WHO STATED THE MANUFACTURER AGREED TO GIVE A $50 CREDIT ON A PURCHASE OF A NEW SEAT WHICH WAS IDENTICAL TO THE ORIGINAL SEAT INSTALLED ON THE MOTORCYCLE. THE CONTACT EXPRESSED CONCERN THAT DRIVING THE VEHICLE WAS A SAFETY RISK DUE TO THE SEVERITY OF THE BACK PAIN CREATED BY THE UNPADDED SEAT. UPDATED 2/12/2007 - *NM

NHTSA ID 10175832 · filed Dec 11, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Other / unspecified

Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.

1
report

From owner reports, verbatim

2004 SUZUKI C-50 MOTORCYCLE CRACKS IN THE FRONT WHEEL, THESE ARE NOT CASTING MARKINGS.7K MILES ON WHEEL DONT KNOW HOW LONG CRACKS HAVE BEEN THERE. *TR

NHTSA ID 10395635 · filed Apr 12, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .