RoadVitals

2009 Thomas Built Buses Hdx Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest May 5, 2010
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2009 Thomas Built Buses Hdx, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Electrical150.0%
  • Exterior lighting150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

1. AFTER DRIVING THE 2009 THOMAS HDX BUS FOR A COUPLE OF HOURS, DRIVER WAS BRINGING THE BUS TO A STOP, AND BEFORE HE ACTIVATED THE DOORS OR ANY OTHER ELECTRICAL ACCESSORIES, HE SAW SMOKE COMING UP FROM THE DASH IN FRONT OF THE STEERING WHEEL. HE REPORTED THE SMOKE COMING FROM THE TOP OF THE DASH NEAR THE WINDSHIELD, NOT FROM THE BOTTOM OF THE DASH AND NOT FROM THE VENT LOCATED ABOVE THE SWITCH PANEL TO THE LEFT OF THE OPERATOR'S SEAT. DRIVER SHUT THE BUS OFF. APPROX. 5-10 MINUTES LATER, SMOKE WAS SEEN COMING FROM THE OPERATOR'S WINDOW AND THE OPEN FOLDING DOORS. FLAMES WERE OBSERVED BURNING ACROSS THE INSIDE OF THE FRONT OF THE BUS. FIRE DEPARTMENT NOTIFIED, ARRIVED IN APPROX. 5-10 MINUTES AND EXTINGUISHED THE FIRE. 2. BUS WAS DETERMINED TO BE A TOTAL LOSS. 3. INVESTIGATION TO DETERMINE ORIGIN AND CAUSE OF THE FIRE INDETERMINATE AS TO SPECIFIC COMPONENT IN THE CIRCUIT BREAKER AREA; HOWEVER THOMAS SUBSEQUENTLY ISSUED A RECALL.

NHTSA ID 10323346 · filed Apr 1, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Exterior lighting

Reports naming headlights, tail lights, turn signals and other exterior lighting.

1
report

From owner reports, verbatim

I RECEIVED A NOTICE (NHTSA CAMPAIGN ID NUMBER : 10V177) YESTERDAY REGARDING STOPLAMP FAILURE ON THOMAS C2 BUSES. OUR SCHOOL DISTRICT HAS EXPERIENCED A SIMILAR PROBLEM OF INTERMITTENT STOPLAMP OPERATION ON ONE OF OUR 2009 HDX THOMAS BUSES. A RESISTOR (NOT SHOWN ON THOMAS WIRING DIAGRAMS) WAS PLACED IN THE WIRE FROM THE STOPLAMP SWITCH AND WAS DEFECTIVE. *TR

NHTSA ID 10328929 · filed May 5, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .