2018 Thomas Built Buses Minotour Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 Thomas Built Buses Minotour, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Powertrain (other)150.0%
- Transmission150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
Lost all forward gear. As show in the picture attached of the valve body the number 1 valve body check ball pointed at with the yellow arrow is significantly smaller the the rest of the check balls. This causes the vehical to lose all forward gears and potentialy putting you harms way. This come whithout warning and no check engine light. I run a fleet of about 60 of these vans and it has happened with at least 5 of my vans in the couple of years two of which have been repaired by the dealer. It is just a matter of time a van gets stuck in the middle of an intersection or on a railroad crossing.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
Lost all forward gear. As show in the picture attached of the valve body the number 1 valve body check ball pointed at with the yellow arrow is significantly smaller the the rest of the check balls. This causes the vehical to lose all forward gears and potentialy putting you harms way. This come whithout warning and no check engine light. I run a fleet of about 60 of these vans and it has happened with at least 5 of my vans in the couple of years two of which have been repaired by the dealer. It is just a matter of time a van gets stuck in the middle of an intersection or on a railroad crossing.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .