RoadVitals

2009 Thomas Built Buses Mvp-Ef Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
7
Newest Apr 6, 2011
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

7 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

11V223000

EQUIPMENT:APPLIANCE:AIR CONDITIONER

Apr 6, 2011
64 units potentially affected
The defect: DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER HDX, MVP-EF, AND MINOTOR NON SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
The risk: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
The remedy: DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-604View on NHTSA.gov
11V222000

EQUIPMENT:APPLIANCE:AIR CONDITIONER

Apr 6, 2011
6,831 units potentially affected
The defect: DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
The risk: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
The remedy: DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-604View on NHTSA.gov
10V397000

ENGINE AND ENGINE COOLING

Sep 3, 2010
66 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 MVP-EF NON SCHOOL BUSES MANUFCATURED FROM SEPTEMBER 12, 2008 THROUGH JULY 16, 2010, EQUIPPED WITH THE MEGAFUSE JUNCTION BOX. ON AFFECTED VEHICLES THE MEGAFUSE JUNCTION BOX IS LOCATED IN AN AREA EXPOSED TO EXCESSIVE ROAD SPLASH AND SPRY. IN SOME APPLICATIONS THE CABLE CONNECTIONS MAY CORRODE RAPIDLY. IF UNDETECTED, EXTREME CORROSION MAY CAUSE A POWER CABLE TO BECOME SEPARATED FROM THE POWER SOURCE RESULTING IN AN UNEXPECTED ENGINE SHUTDOWN OR LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS.
The risk: UNEXPECTED ENGINE SHUTDOWN OR A LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS IN CERTAIN TRAFFIC CONDITIONS COULD INCREASE THE RISK OF A VEHICLE CRASH.
The remedy: DAIMLER TRUCKS WILL REPLACE THE MEGA FUSE JUNCTION BLOCK AND ELECTRICAL BOX FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAView on NHTSA.gov
10V396000

ENGINE AND ENGINE COOLING

Sep 3, 2010
1,117 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 MVP-EF THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 12, 2008 THROUGH JULY 16, 2010, EQUIPPED WITH THE MEGAFUSE JUNCTION BOX. ON AFFECTED VEHICLES THE MEGAFUSE JUNCTION BOX IS LOCATED IN AN AREA EXPOSED TO EXCESSIVE ROAD SPLASH AND SPRY. IN SOME APPLICATIONS THE CABLE CONNECTIONS MAY CORRODE RAPIDLY. IF UNDETECTED, EXTREME CORROSION MAY CAUSE A POWER CABLE TO BECOME SEPARATED FROM THE POWER SOURCE RESULTING IN AN UNEXPECTED ENGINE SHUTDOWN OR LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS.
The risk: UNEXPECTED ENGINE SHUTDOWN OR A LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS IN CERTAIN TRAFFIC CONDITIONS COULD INCREASE THE RISK OF A VEHICLE CRASH.
The remedy: DAIMLER TRUCKS WILL REPLACE THE MEGA FUSE JUNCTION BLOCK AND ELECTRICAL BOX FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAView on NHTSA.gov
09V462000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Dec 1, 2009
5,082 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT MVP-EF SCHOOL BUSES MANUFACTURED FROM FEBRUARY 15, 2005 THROUGH NOVEMBER 23, 2009. THE ACCELERATOR PEDAL MAY BECOME WEDGED AGAINST THE SCUFF PLATE AND BECOME STUCK IN FULL THROTTLE POSITION.
The risk: A STUCK ACCELERATOR PEDAL MAY INCREASE THE RISK OF A CRASH.
The remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL RAISE THE ACCELERATOR PEDAL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 17, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-570View on NHTSA.gov
09V394000

OTHER:SCHOOL BUS STOP ARM ASSEMBLY

Oct 2, 2009
2,922 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009-2010 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 31, 2008 AND FEBRUARY 18, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.
The risk: SHOULD THE LED LIGHTS STOP FUNCTIONING, VISIBILITY OF A STOPPED BUS WOULD BE DECREASED, POSSIBLY ENDANGERING A CHILD OR PEDESTRIAN TO INJURY BY PASSING VEHICLES.
The remedy: THOMAS BUILT WILL NOTIFY OWNERS AND LIGHT KITS WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 3, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-562View on NHTSA.gov
08V622000

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Nov 26, 2008
18,198 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING 18,198 MY 2003-2009 THOMAS BUILT ER, MVP-ER, HDX, AND MVP-EF SCHOOL AND TRANSIT BUSES EQUIPPED WITH A DUAL POWER SWITCH AND MANUFACTURED FROM FEBRUARY 1, 2002 THROUGH OCTOBER 17, 2008. SOLID STATE CIRCUIT BREAKERS MAY TRIP UNNECESSARILY POTENTIALLY RESULTING IN A LOSS OF POWER TO THE BUS CHASSIS AND BODY ELECTRICAL CIRCUITS CAUSING AN UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING.
The risk: UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING COULD RESULT IN A VEHICLE CRASH.
The remedy: THOMAS BUILT BUS DEALERS WILL REPLACE THE SOLID STATE DUAL POWER SWITCH WITH A MECHANICAL CIRCUIT PRODUCTION (MEGA FUSE). THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-539View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .