RoadVitals

2026 Thomas Built Buses Saf-T-Liner Efx Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Feb 13, 2026
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

26V086000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

Feb 13, 2026
2,843 units potentially affected
The defect: Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2023-2026 Saf-T-Liner EFX and Saf-T-Liner HDX school buses. The heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment.
The risk: Contact with hot heating coolant may burn occupants, increasing the risk of injury.
The remedy: Dealers will inspect and replace the heater hose clamps, as necessary, free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1030.
Daimler Trucks North America, LLCManufacturer number F1030View on NHTSA.gov
25V604000

STEERING:CRITICAL FASTENERS; STEERING:LINKAGES:TIE ROD ASSEMBLY

Sep 11, 2025
99 units potentially affected
The defect: Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2025-2026 Saf-T-Liner HDX, Saf-T-Liner C2, 2026 Saf-T-Liner EFX, and Saf-T-Liner C2 Jouley school buses. The tie rod castle nut and cotter pin may not be installed properly, which can result in a loss of vehicle steering control.
The risk: A loss of vehicle steering control increases the risk of a crash.
The remedy: Dealers will inspect and replace the tie rod assembly, as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is D25R2.
Daimler Trucks North America, LLCManufacturer number D25R2View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources